Skip navigation
55520 Visits Today

How to care for your auto transmission

  • image

    Regular maintenance of your auto transmission is required to keep it working the way it should.

Most carmakers today tell us that the automatic transmissions in our cars are "filled for life"?.

...on the assembly line and will never need servicing. But to take that advice on face value is to court disaster.

The fluid in an automatic transmission is its lifeblood, it depends on it to operate efficiently over a long period of time, and to ignore it is to risk an expensive meltdown.

While carmakers tell you automatic transmissions don't need servicing, specialists in the field say regular maintenance is required to keep them working the way they should.

It doesn't matter what you're told, oil does break down over time, and with high temperature, and its efficiency is reduced.

The service routine recommended by specialists for cars in normal use is to change the oil and filter every 12 months, which equates to 20,000 km, and carry out a full flush of the transmission every two years.

For vehicles working in more punishing conditions, such as hilly terrain, on sandy tracks, using four-wheel in the bush, or towing regularly, those intervals should be reduced.

It's also important to ensure the fluid doesn't overheat, which usually happens because the transmission is worked too hard. If you plan to tow with your vehicle on a regular basis, like on that dream trip of a lifetime around the country, consider having an external transmission oil cooler fitted.

It's also important to select the best gear in which to tow for the conditions.

On the flat it's ok to drive in top gear, which is usually an overdrive gear in modern five or six-speed gearboxes, but it's important to read the road ahead when you do that, and change down one, or perhaps even two gears, when approaching an incline or hill. Leaving it in top gear will force the engine and transmission to work harder when you hit the hill, and the temperature in the transmission will rise as result.

But selecting a lower gear on the approach to the hill will get you up and over the hill without excessively stressing the transmission.

Comments on this story

Displaying 3 of 3 comments

  • I use an external oil cooler and a filter on the return line, my trans fluid still looks spotless 20,000km later, a worthy investment and far cheaper than a new transmission!

    PB Posted on 22 February 2012 10:25am
  • It’s also the stop start which is causing the most harm. Mums cause the most damage because they are a busy part on the roads and we fix a lot of transmission due to overheating issues .Tony Manual automatics

    Tony Busacca Posted on 25 October 2011 2:36pm
  • I?m an automatic transmission specialist and I?m glad somebody brought this fact to attention. The manufacturers have even gone to the extent where they build transmissions without a drain plug or a FILL plug. How can you service it then? You can’t and the transmission only lasts for the warranty period and then the cost of a repair is in the thousands and you feel like another ten thousands for a new car isn’t that much! Dodgy bastards.

    sam saunders Posted on 17 August 2011 1:29pm

Add your comment on this story

Indicates required

We welcome your comments on this story. Comments are submitted for possible publication on the condition that they may be edited. Please provide your full name. We also require a working email address - not for publication, but for verification. The location field is optional.