Isuzu MU-X vs Mahindra XUV500

What's the difference?

The MU-X has plenty of appeal as a daily driver – dependable and it’s a proven 4WD wagon.

Does the 2.2-litre engine add anything substantial to the mix?

Well, it's better than the 1.9-litre, that's for sure, and there's a lot to like about this MU-X in terms of its off-road capability, driver-assist tech, standard features and all-round driveability. And, while the LS-T lacks the top-shelf polish of the X-Terrain, it’s still an appealing potential purchase.

But the 3.0-litre option is better because while the 2.2L is very effective off-road and general day-to-day driving, it lacks grunt and has to work that much harder and is that much noisier under load than the 3.0-litre in most driving scenarios, including 4WDing.

This petrol-powered and well-priced XUV500 W6 might mark Mahindra's most convincing effort at cracking Australia's congested SUV market, but we're still not completely convinced.

That said, it's certainly cheap, the ownership credentials stack up and it's a very comfortable way to transport seven people.

In terms of appearance, the MU-X remains largely unchanged from the most recent iteration. And that’s a good thing. It’s blocky enough to be recognisable but sleek enough to remain inoffensive. Worth noting the door handles, window trims, front fender accents, roof rails, and side steps on the LS-T are gloss black.

Inside, nothing much has changed (other than a newly-introduced idle start/stop button) and, as such, the MU-X retains a low-key familiarity that makes it a comfortable space. Generally, design-wise, the MU-X more than holds its own against the likes of the Toyota LandCruiser Prado and Ford Everest.

There's no getting away from the fact the XUV500 is not the sleekest, prettiest SUV in the pack. But it's not ugly, either. More that it looks like it's doing its best with a design philosophy hatched a generation or two ago.

Its best angle by far is when viewed straight on, where the piano-black grille, dual bonnet bulges and complicated (read: a little weird) headlight clusters all add some road presence to Mahindra's only SUV.

A side-on viewing, however, is less satisfying, where a combination of strangely placed and super-sharp body creases (including one over the rear wheelarch, which adds a Harbour Bridge-style crescent to the otherwise-straight window line) and serious rear overhang give the XUV500 an inescapable awkwardness.

Inside, expect a vast collection of rock-hard (though nicely patterned) plastics, with the ambiance rescued somewhat by the clean-looking and vertical central control unit, which is home to the media screen and air-con controls. 

Ready for some hashtag real talk? There are better-looking and better-feeling seven-seat SUVs out there. But there aren't many that start at $25,990 drive-away. And I think that's Mahindra's point.

The interior has a familiar and practical feel about it and the cabin is an easy space in which to become comfortable. Controls are easy to locate and operate and charging options are numerous – a mix of USB-A, USB-C (front and second row) and 12V.

Storage places include recesses for the bits and pieces from your pockets, a deep-ish centre console, as well as dual cupholders up front, cupholders in the rear fold-down centre armrest and bottle holders in the doors. There are also cupholders either side of the third row.

The MU-X has physical-button options to activate some functions (including to switch on the audio system, to adjust volume and access sat nav).

Seats are comfortable and supportive through all three rows – yes, even the third row is roomy enough to prevent whining from whoever is back there.

My camera guru/photographer/sergeant-at-arms, Glen Sullivan, reminded me that the third-row seats don’t have ISOFIX or top-tether points for child seats. Thanks, mate.

The cargo area is 311 litres with all three rows in use, 1119L with the third row flat and 2138L with the second and third rows stowed away.

The rear cargo area has a cargo cover, tie-down points, a 12V power outlet, a storage space under the rear cargo area floor and a space for tools inside the driver’s side rear cargo wall. The MU-X’s full-size spare (bravo!) is attached to its undercarriage.

Pretty damn practical, actually, regardless of whether you want to carry people or cargo. Carrying both at the same time, however, is tricky.

But let's start with people. There is a huge amount of room in the third row of the XUV500, a space with enough head and legroom to put plenty of its competition to shame.

Thanks to second-row seat backs that fold flat, before the the entire seat lifts up and pushes forward, climbing into seats six and seven isn't too big a drama, either. 

We rarely say this about seven-seat cars, but at 175cm, I'd feel plenty comfortable back there on a longer drive. There are two air vents in the third row, too, along with bottle storage and side-seat storage for thin items.

All XUV500's are fitted with a 70-litre fuel tank. 

The space in the middle row is ample as well, and you'll find three ISOFIX attachment points, one for each of the three seats. There's also a door pocket in each rear door and storage nets on the rear of the two front seats. A pull-down divider that separates the back seat is home to two cupholders, matching the two for front seat riders. 

The only downside to all this people-lugging happiness is that, with the third row of seats in place, there is absolutely no room for luggage. Mahindra doesn't quote a litre storage figure when seven are seated (mostly because it would probably be embarrassing to write "one litre"), but trust us, you'll be lucky to squeeze a soft backpack in the boot with all seats in place.

Things improve considerably when you drop the third row of seats, though, which unlocks 702 litres of storage, and that number climbs to 1512 litres with the second and third row folded down.

Make no mistake, this Mahindra kills the competition on price. The entry-level W6 version will cost you a lean $25,990, while the fruited-up W8 version will set you back $29,990. You can even have an AWD W8 for $32,990. The best part? All of those are drive-away prices.

Go for the W6, and you can expect 17-inch alloy wheels, cloth seats, air-con with vents (powered by a second compressor) in the second and third row, cornering headlights with DRLs, front and rear fog lights, cruise control, rear parking sensors and a 6.0-inch multimedia screen linked with a six-speaker stereo.

Spring for the W8, and you'll add leather seats, a reversing camera, tyre-pressure monitoring and a bigger, 7.0-inch screen with standard sat-nav.

This MU-X has a 2.2-litre, four-cylinder, turbo-diesel engine, producing 120kW at 3600rpm and 400Nm between 1600-2400rpm and it’s matched to an eight-speed automatic transmission.

Worth noting the 3.0L MU-X has a six-speed auto and produces 140kW (at 3600rpm) and 450Nm (1600-2600rpm) while the outgoing 1.9L MU-X has a six-speed auto and produces 110kW (3600rpm) and 350Nm (1800-2600rpm).

While the 3.0-litre has always been unstressed in most driving scenarios – even low-range 4WDing – the 2.2-litre feels underpowered. More about that in the ‘Driving’ section below.

The MU-X has a part-time 4WD system which includes a dual-range transfer case (with high- and low-range 4WD) and a rear diff-lock. The driver is able to shift from 2H (two-wheel drive, high-range) to 4H (4WD high-range) while on the move up to speeds of 100km/h. The diff-lock may only be engaged when the vehicle is in 4L (4WD low-range).

The MU-X also has a switchable terrain mode system which tweaks the engine, transmission and traction control to suit the driving conditions. 'Rough Terrain' mode, like a steroids-enhanced off-road traction control, is king of these modes when you’re off the bitumin.

There's a diesel engine currently available, but the clock is ticking - Mahindra expects it to be phased out within six months. But the big news here is the new petrol engine, a turbocharged 2.2-litre unit good for 103kW/320Nm. It's paired exclusively with an Aisin-developed six-speed automatic transmission, and will send it's power to the front or all four wheels.

Mahindra doesn't quote official performance figures, but those engine outputs hardly scream excitement, do they?

Official combined cycle (urban/extra-urban) fuel consumption for this MU-X is 6.7L/100km. The 1.9L MU-X offers 7.4L/100km while the 3.0L offers 7.6L/100km.

Actual fuel consumption on this test was 8.7L/100km.

The MU-X has an 80-litre fuel tank, so, going by that on-test fuel consumption figure, you should be able to get a driving range of about 920km. But remember, your fuel consumption may be completely different to mine because chances are you'll have friends, family pets, sporting equipment, camping gear, the whole kit and caboodle on board. I've only been carrying vehicle recovery gear, MaxTrax, and a first-aid kit, so I haven't had a huge amount of weight on board.

Local numbers are yet to be confirmed, but after an admittedly vigorous local test, the on-board computers was reading 13+ litres per 100km. All XUV500's are fitted with a 70-litre fuel tank.  

Before we launch into the off-roading section of this test, it’s worth noting the MU-X has always been decent on-road; composed, reasonably refined (for a 4WD wagon, anyway) and comfortable. And thankfully, with the 2.2-litre engine, not all of those characteristics have been thrown out the window.

It is quite noisy, especially under pressure when you have to do some heavy acceleration or when you have a bit of gear on board. When it has to work that bit harder than it usually does, it can become quite noisy. Admittedly, the 3.0-litre MU-X is also quite gruff, but there's an edge to the roughness in the 2.2-litre that is very noticeable on road.

This MU-X is quite sluggish off the mark, exhibiting a disconcerting lag under heavy throttle from a standing-start. And it’s far from the most dynamic vehicle to drive. But it has a tractability about it that manages to mostly negate these flaws.

Otherwise, the new eight-speed auto deserves credit as it’s slick and smooth in application and feels right at home in this wagon.

Now to off-roading. The MU-X is still very capable. In fact, even with the 2.2-litre engine, it remains one of the better-performing 4WD wagons straight out of the dealership, in terms of pure off-road capability.

The 3.0-litre MU-X is not the torquiest in this segment, but it offers ample pulling power available across a wide rev range – count on peak torque between 1600rpm and 2400rpm – and it delivers that pulling power in an even-handed fashion. The 2.2-litre MU-X has to work harder than its stablemate, and it’s noisier and harsher.

However, those characteristics don’t take away from how effective this MU-X is because it offers impressive off-road performance. It still has a decent amount of low- and mid-range torque, which makes dirt-road cruising and low-speed 4WDing easy.

The MU-X has part-time 4WD with high- and low-range 4WD gearing, a rear diff lock and overall it retains all of that off-road capability the 3.0-litre MU-X has been renowned for – so you don't lose any efficacy there.

The line-up’s off-road traction control system, which once was a bit patchy in its effectiveness, has gone through a couple of phases and it’s been recalibrated/tweaked over the years and it is much better now.

Of course, the MU-X also has Isuzu’s much-vaunted Rough Terrain mode (a form of early-acting off-road traction control which converts lost grip into torque for the wheels with grip), and it is smooth and effective, giving the driver better overall control in challenging terrain.

Some of this MU-X’s listed off-road angles appear shallower than the 3.0-litre MU-X’s – approach: 23.9 (3.0L = 29.2), departure: 26.4 (3.0L = 26.4) and ramp-over: 19.6 (3.0L = 23.1) – but, even if that is the case, it has very similar driving characteristics in low-speed, low-range four-wheel driving to its 3.0-litre stablemate.

If you drive with control and consideration, you shouldn't have any trouble tackling light to moderate 4WDing in this MU-X. It could even, if push comes to shove, handle challenges that may be considered by some to be on the edge of hard-core 4WDing – for a showroom-standard 4WD wagon anyway.

Ground clearance is 235mm and wading depth is 800mm, so there’s an adequate amount of clearance to work.

The MU-X – with a turning circle of 11.6m and a kerb weight of 2130kg (3.0L = 2185kg) – feels quite nimble on bush tracks.

This wagon’s wheel travel – how far the axle can move up and down relative to the chassis – has more than an adequate amount of flex, stretching its tyres close, if not all the way, to the dirt.

A noticeable trade-off is its 20-inch wheel-and-tyre combination, which is best suited to sealed surfaces and so are far from ideal for dirt-track touring. There’s an easy remedy, though. Buy a set of decent all-terrain tyres on 17- or 18-inch rims to replace the showroom-standard 265/50R20 Highway-Terrain tyres. If you are using your MU-X, avoid dropping pressures too much because you’ll risk sidewall pinches and punctures on these low-profile road tyres.

In terms of packability: the 2.2L MU-X has a listed payload of 670kg, whereas the 3.0L version offers 615kg.

The 2.2L MU-X can legally tow 750kg (unbraked trailer) and 3500kg (braked), so theoretically you can tow the same load as a 3.0-litre MU-X. But, as mentioned, the 2.2-litre engine feels underpowered, even in general day-to-day driving, so with a load and/or towing that’s an added burden.

For reference, the 2.2L MU-X has a listed gross vehicle mass of 2800kg and gross combined mass of 5900kg.

About as old school as rocking a pair of button-up tracksuit pants with a Run-DMC cassette stuffed into your Walkman.

On a straight and unchallenging road, there's stuff to like about the petrol-powered XUV500. The engine, while gruff under heavy acceleration, doesn't feel too wheezy when you're not asking a great deal of it, and nor is the cabin overly loud at suburban speeds. It's a comfortable space for driver and passengers, too, and the gearbox performed seamlessly on our short test drive.

But that's about where the good news ends. There's an unshakeable agricultural feel to the way this Mahindra SUV goes about its business, and nowhere is that more obvious than through the steering wheel, which has only a vague and difficult relationship with the the front tyres, making it seriously tricky to approach twisting roads with anything approaching confidence.

The steering is slow and cumbersome - light when you first begin turning the wheel, with a ton of weight appearing by surprise midway through the cornering process - and it has a tendency to fight back should the front wheels find a bump or corrugation in the road, too. 

The body lolls about when challenged, too, and the tyres are quick to give up their grip on tighter corners. All of which would give it a certain retro charm if it wasn't so very new, and I must admit I was cackling maniacally on some of the more twisting roads.

But it's simply not a car I could live with.

Expect dual front, front-side and curtain airbags (though the latter don't extend to the third row of seats), along with rear parking sensors and ESP. Stepping up to the W8 trim adds a reversing camera with dynamic guidelines. The XUV500 was awarded a four-star (out of five) ANCAP assessment when tested in 2012.

The MU-X has a six-year/150,000km warranty and seven years of roadside assistance. Unlimited km in the warranty would be welcome.

Service intervals are scheduled for every 12 months or 15,000km, whichever occurs soonest.

Capped price servicing covers the first five scheduled services for MY24 and later vehicle models (up to 5 years/75,000km – whichever occurs first) – at a flat price of $469 for each service.

Isuzu Ute Australia has a nationwide network of more than 160 dealer sites.

All XUV500s are covered by a five year/100,000km warranty (though the final two years apply only to the drivetrain), along with five years of complimentary roadside assistance.

The XUV500 is also covered by Mahindra's capped-price servicing program for the first three years of ownership, and will require servicing every six months or 10,000km.