Ssangyong Tivoli vs Mahindra XUV500

What's the difference?

I was asked the critical question while I had the Tivoli ELX on test – “Do you think people will buy this car?” After some time in thought, my answer was – “Not many… yet.”

Those who can look past the brand perceptions are getting an SUV which is damn near as good as anything on the market – and likely cheaper to run.

To that, you can say a lot of things: If only it cost slightly less. If only its rear was better looking. If only it had a five-star safety rating.

But here it is – the fact that the Tivoli can even hold a candle to its slick, finely tuned competition says a lot. The Double Dragon is back, and if it can afford to stick around for a while, perhaps it will stand a chance of putting the big players on notice.

This petrol-powered and well-priced XUV500 W6 might mark Mahindra's most convincing effort at cracking Australia's congested SUV market, but we're still not completely convinced.

That said, it's certainly cheap, the ownership credentials stack up and it's a very comfortable way to transport seven people.

SsangYong is hardly a brand known for its consistent or good-looking design. In the past, the brand has floundered between the squared-off lines of the Musso and the unresolved bulbous curves of the last-gen Korando.

The brand’s re-launch has finally brought it up to speed, with every car across its range featuring a consistent design language. It’s improved out of sight, but still isn’t without its flaws.

Up front, there’s an angry-looking, squared-off horizontally slotted grille, with angles galore wrapping around the small SUV’s sides.

The angles continue up the A-pillar and across the roof for a squared-off, European-influenced roofline.

Then, around the back things get… strange. A pronounced curvy ridge makes its way over the rear wheels and into a rounded-out boot. It seems at odds with the angular rear glass and lower garnish.

There’s just way too much going on around the back; it’s overly styled. The chintzy chrome finish around the lower reflectors doesn’t help, nor do the big round SsangYong badge and bold ‘T I V O L I’ typeface.

The 16-inch alloys on the EX and ELX grade are a simple 10-spoke matte-silver. They’re nothing special, but at least they're easy to clean.

Inside, things are also mixed. There’s plenty of good and bad. The seats are clad in a robust cloth with plenty of sponge for comfort, and there are sensibly placed soft surfaces in the doors and on the centre console for your elbows.

The dash has an aesthetically pleasing symmetrical theme to it and is finished mostly in decent plastics. The 7.0-inch media screen is pretty good, too, but the rest of the centre stack is a bit nasty and old fashioned.

There’s the mix of gloss plastic and silver surfaces, a giant climate control dial and the so-so buttons that litter its surface. It reminds me of Korean car designs past, like the Holden (Daewoo) Captiva and generations-old Hyundais. Credit where credit is due, though - it all feels much better built.

I’m actually a big fan of the Tivoli’s steering wheel, it has a ridged, chunky shape and is finished in a pleasing artificial-leather material. The function stalks behind it are solid, with rotary dials on them to control lights and wipers. As the primary touch-points for the driver it’s neat that they have a unique, SsangYong personality to them.

There's no getting away from the fact the XUV500 is not the sleekest, prettiest SUV in the pack. But it's not ugly, either. More that it looks like it's doing its best with a design philosophy hatched a generation or two ago.

Its best angle by far is when viewed straight on, where the piano-black grille, dual bonnet bulges and complicated (read: a little weird) headlight clusters all add some road presence to Mahindra's only SUV.

A side-on viewing, however, is less satisfying, where a combination of strangely placed and super-sharp body creases (including one over the rear wheelarch, which adds a Harbour Bridge-style crescent to the otherwise-straight window line) and serious rear overhang give the XUV500 an inescapable awkwardness.

Inside, expect a vast collection of rock-hard (though nicely patterned) plastics, with the ambiance rescued somewhat by the clean-looking and vertical central control unit, which is home to the media screen and air-con controls. 

Ready for some hashtag real talk? There are better-looking and better-feeling seven-seat SUVs out there. But there aren't many that start at $25,990 drive-away. And I think that's Mahindra's point.

The Tivoli might be a small SUV but it has a cavernous cabin. It’s seriously impressive and rivals some of the best players in this segment, like the Honda HR-V.

The front seat offers huge amounts of headroom, leagues of legroom, great space for your arms on either side and a fully telescopically adjustable steering wheel.

Storage is comprised of a shallow trench under the climate-control stack, decently sized cupholders in the centre console and doors, as well as a deep console box and a glovebox, which seems to disappear forever into the dash.

There’s also a rather odd trench cut out of the dash above the console box. It’s ridged and has a rubbery surface but seems useless for storing things, which will simply topple out when you accelerate.

As previously mentioned, there are comfortable surfaces for resting your elbows on for front occupants.

Room for back-seat dwellers is also excellent, with awesome legroom for the segment and leagues of airspace even for taller folk. There are the same padded elbow-rests in the doors and deep cupholders, but no air-conditioning vents or USB ports.

There are also weird elastic ropes on the back of the front seats for storing things (with mixed success) and a pull-down armrest.

The boot is rated at 423-litres (VDA), which is deceptively large (size-wise not far off the HR-V’s 437-litre space). The problem here is the shape of the boot itself. It’s deep from the floor to the retractable screen, and SsangYong says it will hold three golf bags, but it’s the narrow width and length which limit  its potential.

I found it awkward to move some odd-shaped objects, like a heater and some boxes, and the high entry-point to the bootlid makes things a little difficult when moving heavier items.

Our ELX has significantly more room thanks to a space-saver spare under the boot floor. The Ultimate, which sits above has a full-size spare, further limiting boot space.

There are the same odd elastic ropes in the edges of the boot wall for smaller loose objects or cables.

Pretty damn practical, actually, regardless of whether you want to carry people or cargo. Carrying both at the same time, however, is tricky.

But let's start with people. There is a huge amount of room in the third row of the XUV500, a space with enough head and legroom to put plenty of its competition to shame.

Thanks to second-row seat backs that fold flat, before the the entire seat lifts up and pushes forward, climbing into seats six and seven isn't too big a drama, either. 

We rarely say this about seven-seat cars, but at 175cm, I'd feel plenty comfortable back there on a longer drive. There are two air vents in the third row, too, along with bottle storage and side-seat storage for thin items.

All XUV500's are fitted with a 70-litre fuel tank. 

The space in the middle row is ample as well, and you'll find three ISOFIX attachment points, one for each of the three seats. There's also a door pocket in each rear door and storage nets on the rear of the two front seats. A pull-down divider that separates the back seat is home to two cupholders, matching the two for front seat riders. 

The only downside to all this people-lugging happiness is that, with the third row of seats in place, there is absolutely no room for luggage. Mahindra doesn't quote a litre storage figure when seven are seated (mostly because it would probably be embarrassing to write "one litre"), but trust us, you'll be lucky to squeeze a soft backpack in the boot with all seats in place.

Things improve considerably when you drop the third row of seats, though, which unlocks 702 litres of storage, and that number climbs to 1512 litres with the second and third row folded down.

Make no mistake, this Mahindra kills the competition on price. The entry-level W6 version will cost you a lean $25,990, while the fruited-up W8 version will set you back $29,990. You can even have an AWD W8 for $32,990. The best part? All of those are drive-away prices.

Go for the W6, and you can expect 17-inch alloy wheels, cloth seats, air-con with vents (powered by a second compressor) in the second and third row, cornering headlights with DRLs, front and rear fog lights, cruise control, rear parking sensors and a 6.0-inch multimedia screen linked with a six-speaker stereo.

Spring for the W8, and you'll add leather seats, a reversing camera, tyre-pressure monitoring and a bigger, 7.0-inch screen with standard sat-nav.

Our Tivoli is powered by a 1.6-litre four-cylinder turbo diesel engine producing 84kW and 300Nm of torque.

That seems a little low on the power front compared to petrol competitors, but the strong torque figure available from an almost instantaneous 1500rpm gives this engine a solid amount of get up and go.

If you aren’t opposed to diesel, I would strongly suggest this engine over its underpowered 1.6-litre petrol equivalent, as it has almost twice the available torque.

It might seem risky for SsangYong to be offering diesel in a segment where the fuel type is unpopular, but it makes sense from a global supply point of view, as diesel is largely the fuel of choice in the Tivoli’s home country of South Korea.

The ELX is front-wheel drive and can only be had with a six-speed torque converter auto transmission manufactured by Aisin.

There's a diesel engine currently available, but the clock is ticking - Mahindra expects it to be phased out within six months. But the big news here is the new petrol engine, a turbocharged 2.2-litre unit good for 103kW/320Nm. It's paired exclusively with an Aisin-developed six-speed automatic transmission, and will send it's power to the front or all four wheels.

Mahindra doesn't quote official performance figures, but those engine outputs hardly scream excitement, do they?

Over my week of mainly urban driving I scored a fuel-consumption figure of 7.8L/100km against a claimed urban figure of 7.4L/100km which is not too bad, but also not stellar.

The official claimed/combined usage figure is at a bold-sounding 5.5L/100km.

The Tivoli has a 47-litre fuel tank.

Local numbers are yet to be confirmed, but after an admittedly vigorous local test, the on-board computers was reading 13+ litres per 100km. All XUV500's are fitted with a 70-litre fuel tank.  

We never recommend that you drive blindfolded, but if you could and you drove the Tivoli, I honestly believe you’d have trouble telling it apart from any other small SUV on sale today. 

The diesel engine feels strong from the get-go and pushes the 1390kg SUV along with a reasonable urgency. It’s no performance drivetrain, but it's as good as, if not better than, most of the petrol competitors.

The six-speed torque converter auto is mostly great around town but is old-school in that you can definitely feel each ratio. It also had the unfortunate habit of occasionally grabbing the wrong gear.

I once caught it out altogether under heavy acceleration and it spent a whole second fishing for the ratio it wanted. It’s still better than a continuously variable transmission (CVT) for driver engagement, though.

Steering is on the light side but is direct and offers decent feedback. The ELX offers three steering modes - 'Comfort', 'Normal', and 'Sport', which artificially alter the weight behind the steering. 'Normal' is by far the best.

The suspension was also notably impressive. Fellow Korean brands, Hyundai and Kia, have harked on for a long time about local tuning efforts, but I found the Tivoli’s suspension tune almost as good. It’s a slightly more spongey, comfort-focused tune, but I was impressed at how composed it felt in the corners.

The ELX has a cheap torsion-bar rear suspension setup, which could only really be noticed over rough road conditions.

Behind the wheel, the Tivoli was also surprisingly quiet at lower speeds. This makes for a nice, quiet drive around town, despite the diesel engine, but at speeds above 80km/h and engine rpms above 3000 the noise became significantly worse.

I’d say the Tivoli drives just as well as most Hyundais and Kias from just a few years ago. There’s room for improvement in the little details, but for the brand’s first effort since its international re-boot, it does a darned good job.

About as old school as rocking a pair of button-up tracksuit pants with a Run-DMC cassette stuffed into your Walkman.

On a straight and unchallenging road, there's stuff to like about the petrol-powered XUV500. The engine, while gruff under heavy acceleration, doesn't feel too wheezy when you're not asking a great deal of it, and nor is the cabin overly loud at suburban speeds. It's a comfortable space for driver and passengers, too, and the gearbox performed seamlessly on our short test drive.

But that's about where the good news ends. There's an unshakeable agricultural feel to the way this Mahindra SUV goes about its business, and nowhere is that more obvious than through the steering wheel, which has only a vague and difficult relationship with the the front tyres, making it seriously tricky to approach twisting roads with anything approaching confidence.

The steering is slow and cumbersome - light when you first begin turning the wheel, with a ton of weight appearing by surprise midway through the cornering process - and it has a tendency to fight back should the front wheels find a bump or corrugation in the road, too. 

The body lolls about when challenged, too, and the tyres are quick to give up their grip on tighter corners. All of which would give it a certain retro charm if it wasn't so very new, and I must admit I was cackling maniacally on some of the more twisting roads.

But it's simply not a car I could live with.

Expect dual front, front-side and curtain airbags (though the latter don't extend to the third row of seats), along with rear parking sensors and ESP. Stepping up to the W8 trim adds a reversing camera with dynamic guidelines. The XUV500 was awarded a four-star (out of five) ANCAP assessment when tested in 2012.

The SsangYong Tivoli now leads the small SUV segment with a seven-year/unlimited-kilometre warranty, which is miles ahead of the acceptable industry standard of five years/unlimited kilometres offered by most competitors.

Service pricing comes in at a completely fixed and impressive-for-a-diesel $322 per yearly 15,000km service for the life of the warranty.

Extra service items are tidily laid out in a chart breaking down parts cost, labour, and total price, with the most notably expensive item being transmission fluid ($577), which, at worst, is recommended to be changed at 100,000km.

From this we can tell SsangYong intends to target Kia’s audience and use this part of the business to categorically beat its competition.

All XUV500s are covered by a five year/100,000km warranty (though the final two years apply only to the drivetrain), along with five years of complimentary roadside assistance.

The XUV500 is also covered by Mahindra's capped-price servicing program for the first three years of ownership, and will require servicing every six months or 10,000km.