Mazda CX-60 vs Toyota C-HR

What's the difference?

Have no doubts. The MY25 version of the CX-60 is the SUV that Mazda should have launched in Australia in 2023.

It fulfils the promise of its sophisticated specification, builds on the extensive dynamic abilities of previous models, and now provides a compelling – and unique – choice for medium-SUV buyers who do not need an extended seven-seater.

It may still looks a bit daggy from some angles outside, and we’d like a little bit less suspension noise on the inside, but the CX-60 should now be on Australian family-car shortlists.

Note: CarsGuide attended this event as a guest of the manufacturer, with accommodation and meals provided.

There’s not much in terms of practicalities that are going to convince you the C-HR is a better option than Toyota’s other small SUV, the Corolla Cross.

Even other ‘stylish’ small SUVs like the Mazda CX-30, fuel savers like the electric MG ZS EV, or performance small SUVs like the Hyundai Kona N are more affordable than the GR Sport version of the C-HR.

In the case of this car, unlike most of its Toyota stablemates, buyers will likely be making a decision from the heart based on exterior styling and its interior rather than value or practicality.

And who would anyone be to tell you not to buy a car you like for its styling?

If you’re searching for something new in the looks department for the CX-60, you won’t find it, since this is essentially the same car as last year’s model from the outside. Except there’s a new beige colour option.

Which means the same long-bonnet/cab-backward silhouette remains, along with the corporate wing-motif grille, hunched-over styling (that looks awkward from some angles) and short rear overhangs.

Still, the overall effect remains modern, clean and distinct from the nearly-identical and very closely-related CX-70, CX-80 and CX-90 further up the Mazda food chain.

Note that the CX-60 is usefully larger than the CX-5, with the former coming in at 4740mm long, 1890mm wide, 1675mm tall and 2870mm in wheelbase length, compared to the latter’s 4575mm, 1845mm, 1680mm and 2700mm dimensions respectively.

Which, of course, elevates it from an interior point of view.

There’s a fair bit going on here compared to most of Toyota’s other products, much like the first generation, but being designed with Europe as the key market and Australia as a secondary means the styling team needed to take on some fairly fashionable brands.

All three variants of the C-HR are relatively close in aesthetics, with major differences being two-tone paint or specific trim elements for the top-spec GR Sport.

It uses new Toyota design elements that have been seen on some models already, the ‘c-shape’ lights have been used on the new Prius, which we no longer get in Australia, for example.

The black roof was also available on the previous generation, where this car has carried over the ‘egg-like’ silhouette from.

The overall relatively aquatic styling and shape must be for aerodynamic advantage - its chief engineer told us the drag coefficient is just 0.318Cd - but the removal of the rear wiper to lower drag might have been unnecessary for a city-focused small SUV.

The cabin isn’t as wild as the outside, which may be a let-down in some ways, though it’s still a little more visually interesting than its more mainstream stablemates.

The 64-colour ambient lighting changes based on settings including time of day or drive mode, but can be set to a specific single colour if you wish.

The centre stack on the dash is gently angled towards the driver with a small separation between it and the passenger, creating a slight ‘cockpit’ feeling.

Seats are made from different materials depending on the grade, though no real leather is used even in the GR Sport, where synthetic suede and leather are the main upholstery.

The cloth textiles are made from entirely recycled materials, while the synthetic suede is made from a little less than half recycled materials.

They don’t look cheap, but they also don’t look particularly luxurious.

Like the exterior, the changes for the MY25 CX-60 are pretty much under the skin, with improved noise/vibration and harshness-quelling measures to quieten things down more.

And an exhaust-sound enhancer through the audio system to liven things up if you desire.

Representing the aforementioned $10K saving over the previous entry-level Evolve, the Pure does possess less opulent trim and (nice) cloth seat fabrics, but otherwise the CX-60 does present a larger-than-usual cabin environment compared to smaller medium-sized SUVs.

But fans of big, showy screens may be underwhelmed.

The dash is elegant but somewhat old-fashioned, especially compared to, say, the latest BMW X3’s dazzling displays. It feels like a hangover from last decade’s CX-9.

Yet there’s no denying how satisfyingly easy and logical most of it is, from the super-clear, electronic instrumentation to the simple and effective climate control layout, while the iDrive-style rotary controller means less time with eyes off the road. Safe, intuitive ergonomics. Thank you, Mazda.

Additionally, there’s a quality solidness to the fit and finish that elevates the social-climbing Mazda beyond what a CX-5 could achieve.

All the essentials are also well thought out, from storage and vision out to ventilation and, not least of all, space and seat support, especially when sat on over long distances.

That also carries over to the expansive back-seat environment, with air vents, USB ports, lighting, cupholders and grab handles. The CX-60 is an SUV that a family could grow into without it feeling excessive.

Is this ‘big-medium’ or ‘small-large’ sized?

From the boot’s perspective, either fits, and is one of the reasons why you might consider stepping up to a CX-60. The floor is low, wide, flat and easy to load, as well as beautifully finished.

The 40/20/40 split fold backrests can be folded remotely via Mazda’s Karakuri function, boosting capacity from 477 litres (VDA) to 1726L, while the in-line six-cylinder models have a space-saver spare wheel underneath, leaving PHEV owners with an inadequate tyre repair kit.

When it comes to interior layout and ergonomics, there’s never much to criticise in a Toyota, unless playing it safe is a downside for you.

The buttons you’re most likely to use regularly, across the climate control, centre console and steering wheel, are all very obvious and easy to find, if a little uninspiring, as is wheel design itself - form definitely doesn’t sacrifice function here.

Welcome are the two large screens, the multimedia touchscreen a large 12.3-inch unit and the driver display either 7.0-inch or another 12.3-inch version depending on variant.

Toyota’s software is simple and accessible, using a few main menu sections, though many will likely bypass this with wireless phone mirroring.

Everything’s in a sensible place: a tall bottle in the cupholders won’t block access to anything, the phone charging pad is tucked away to minimise distraction, and Toyota has kept things like the gear selector and stalks behind the steering wheel relatively traditional.

While the interior feels a little dated by its many buttons and some of its simple graphics, there’s certainly something to be said for a welcome change from distracting screens and menus - if the aim was to not exclude Toyota’s older market, it seems like mission accomplished.

In terms of comfort and space, the C-HR makes pretty good use of its interior from the front, the seats are relatively comfortable and visibility is fine, though the back seat starts to feel a bit cramped.

While cupholders and door bottle storage is plentiful in the front, there’s no armrest and no bottle storage in the rear, only relatively shallow cupholders on the armrests in the doors.

Visibility is also relatively poor with high windows, a narrow rear window, and not a lot of light unless there’s a sunroof.

Behind that, with the seats up, the C-HR’s boot has a claimed VDA capacity of 388 litres in the GXL and Koba, or 362L in the GR Sport. Total volume with the seats down is 1154L and 1490L respectively.

While a Corolla Cross starts at $33,980 before on-roads, or $36,480 for a hybrid, the C-HR is just under $43K in its lowest spec.

And even though you’re paying more for a new hybrid drivetrain and some fun Euro styling, the Corolla Cross’ drivetrain isn’t far behind, and it still looks good enough to sell quite well.

So what’s the C-HR got going for it that the Cross doesn’t?

The base GXL starts from $42,990 plus on-road costs and comes with a bit more than you might expect from a base variant Toyota.

A 12.3-inch touchscreen, a 7.0-inch driver display and wireless Android Auto and Apple CarPlay have things covered for multimedia, while dual-zone climate, keyless entry and start, rain-sensing wipers, and USB-C and 12-volt ports and chargers cover off convenience.

The GXL has manually adjustable seats with recycled fabric - which I’ll come back to later - plus a synthetic leather-accented steering wheel.

The Koba, at $49,990, scores heated sports seats with synthetic suede trim, plus power adjustment for the driver seat and a digital rearview mirror as well as cabin ionisation via the climate control.

A wireless smartphone charger, a head-up display above a larger 12.3-inch driver display, plus adaptive high-beam all add to the convenience, while a nine-speaker JBL sound system and 64-colour ambient lighting add to the vibes.

Atop the range is the GR Sport, which starts from $54,990.

As well as being more powerful - we’ll come back to that, too - it gets unique styling outside, plus synthetic leather-accented and suede seats inside, aluminium scuff plates, and a heated GR Sport steering wheel.

For now, the base engine is the 209kW/450Nm G40e, a 3.3-litre turbo-petrol ‘six’ delivering the sort of healthy power figures that late-model Commodore and Falcon buyers would appreciate.

There’s also the 187kW/550Nm D50e turbo-diesel version, for extra pulling power and economy, and we’re getting into premium Euro territory here, because both offer a 48-volt, mild-hybrid system, employing a small electric motor located behind the engine to boost torque yet cut fuel consumption and CO2 emissions.

Mazda says new motor control and clutch slip control software facilitates “…smoother transitions as the electric motor is activated and deactivated”. We hope so!

Last but not least, there’s the 241kW/500Nm P50e plug-in hybrid electric vehicle powertrain, combining the familiar 2.5-litre four-cylinder petrol engine with a larger, 129kW electric motor powered by a 17.8kWh Lithium ion battery. The latter allows up to 76km of pure-electric driving, and can be recharged either by regenerative braking when driving or plugged into a Type 2 port.

All three engines use a revised eight-speed, wet multi-plate-clutch automatic transmission, still driving the rear or, as traction and/or performance needs arise, all four wheels.

Yep, this is essentially a rear-drive-biased family SUV, with a sophisticated double wishbone front and multi-link rear suspension set-up to keep everything in line.

So, what’s changed underneath compared to last year’s CX-60?

Among the modifications are stiffer dampers and softer rear springs to address ride-comfort issues with the old car; relocated front knuckle mounts; altered rear axle bushes and the removal of the rear anti-roll bar for more stable control; shorter rear bump stops for greater suspension travel; an extra joint in the steering column quells vibrations while updated software improves steering feel and electronic stability control operation. The goal is for noticeably smoother, comfier and more linear dynamics. 

Result? To find out how much better or worse Mazda’s latest mid-sized SUV is, we drove the it in a variety of conditions, from the push-and-shove of Melbourne’s bumper-to-bumper peak-hour traffic, to a series of demanding emergency-swerve and multi-speed ride and handling test manoeuvres at the legendary Lang Lang proving ground that shaped so many of our iconic Holdens.

More on that a bit later on.

The difference in boot space is likely because the hybrid-only C-HR comes with two drivetrain options, depending on which variant you have.

The GXL and Koba both use Toyota’s 1.8-litre four-cylinder engine aided by a front-mounted electric motor to produce a 103kW output at the front wheels via a continuously variable transmission.

The GR Sport, however, gains a rear electric motor (taking up some boot space) and a more powerful front motor, helping a larger 2.0-litre four-cylinder petrol engine make a total 146kW - still via a CVT.

Don’t expect to be getting to 100km/h from a standstill in any less than 8.0 seconds in either variant, but both have a claimed top speed of 170km/h.

One area where the Mazda did not need fixing is in its fuel economy.

All of the CX-60’s powertrains are rated at Euro 5.

Officially, the G40e 3.3-litre petrol averages 7.4L/100km, on the combined cycle, and emits 174 grams per kilometre of CO2. Urban and Extra Urban numbers are 9.9L/100km and 6.0L/100km.

Fitted with a 58L petrol tank, expect an average range of around 780km. And it will run on standard 91 RON unleaded petrol to boot.

Moving on to the D50e 3.3L diesel, it manages an impressive 5.0L/100km, for a CO2 figure of 132g/km, resulting in a range average of about 1160km. Its Urban/Extra Urban figures are 5.5/4.7L/100km respectively.

And, finally, there’s the P50e 2.5L PHEV, offering a theoretical 2.1L/100km, for a CO2 figure of just 49g/km, for an unlikely range average of 2380km from its 50L tank, though on 95 RON premium unleaded brew.

Out in the real world, and mostly driven harder than a typical owner might, the trip computer in the PHEV showed low sevens, while the diesel displayed mid-eights and the petrol high nines, which aren’t too bad at all.

Toyota says the C-HR uses just 4.0L/100km on the combined cycle test, which is 0.3L less than the previous generation’s claim, but it should be noted the 2.0-litre in the GR Sport drinks a claimed 4.1L/100km.

During testing on the launch drive, but without being able to measure properly from fill to fill, one quite spirited leg of driving netted a 6.9L/100km reading on the trip computer, while a more sedate drive returned 5.4L/100km.

This is the acid test. Does the CX-60 drive like a Mazda should?

In the engine department, definitely.

The changes that Mazda has made to the transmission calibration means that it no longer hunts indecisively between ratios like it used to, and that results in smoother shifts as well as a more relaxed driving experience.

And that's across the range, whether we're talking about the six-cylinder diesel or petrol, or four-pot plug-in hybrid. And the latter brings the biggest surprise, because the changes made to the gearbox have resulted in a much more pleasant car around town, with no more shunting or jerky movements to contend with.

And then there's the ride, which is palpably softer than before. The suspension is significantly more pliable and comfortable as a consequence, offering better bump absorption, improved control at speed and basically just a more refined experience. We tried several of the Lang Lang Proving Ground’s rough-road tests, which the CX-60 sailed over without any of the hard jarring of the previous model, which Mazda helpfully provided for back-to-back assessments.

So, how does all that translate in everyday driving?

Well, the latest CX-60 is way more comfortable to ride in across the board, it handles and corners with greater control and linearity, seems quieter and it's just a suppler experience overall.

As there was so much that was good with the original CX-60 anyway, including muscular performance from the inline six-cylinder turbos, impressive high-speed stability and exceptional body control through fast turns, the modifications for 2025 do much to elevate an already good thing.

So, it's a win-win situation. If you are in the market for a sub-premium, mid-sized SUV with performance and space, as well as newfound comfort and sophistication, you can do a lot worse than check out the CX-60. It is that much better than before.

There’s nothing particularly offensive about the way the new C-HR drives, but there’s nothing riveting either.

If you’ve driven anything on the Toyota TNGA platform, this will feel familiar to you - and that’s not a bad thing, it’s generally pretty stable, comfortable and controlled.

The modified Corolla platform it rides on is a very good thing, but the C-HR doesn’t have anything in the way of sporting tendencies its styling might suggest.

The hybrid drivetrain in the two 1.8-litre versions of the small SUV don’t offer up a whole lot in terms of keen acceleration, but even the GR Sport and its 146kW drivetrain need a push to get things feeling properly quick on a twisty road.

The added stability of the all-wheel drive in the top variant is noticeable, the front-drive variants feeling a little less planted when pushed.

Steering is on the slightly lighter side of still being well-weighted - it doesn’t wow, but Toyota’s engineers know what they’re doing and it does everything it needs to in terms of communicating feeling to the driver.

Some particularly rough roads on the test drive showed the suspension to handle short, sharp bumps well and not feel crashy over larger imperfections.

The suspension has been retuned in this TNGA-C platform to be stiffer for more control but also more compliant in terms of comfort.

But it’s around urban and suburban streets where the C-HR will spend most of its time, and neglected streets, speed bumps, or tram lines won’t shake you too much from in the cabin.

All three variants of the C-HR come with a version of the Toyota Safety Sense suite of tech which includes things like pre-collision, active cruise control, speed limit sign assist, a surround-view parking camera, plus all the expected inclusions like ABS, blind-spot monitoring and rear cross-traffic alert.

The rear outboard seats are equipped with ISOFIX tethers, too, while the ADR-necessary top tethers are also present.

It hasn’t been tested by ANCAP, but in the case of a collision the C-HR does have a pretty decent airbag count of 10.

Mazda could also do a bit better with its warranty nowadays, since its five-year/unlimited kilometre warranty and roadside assistance is decidedly average.

Service intervals are at 12 months or every 15,000km, while a fixed-price service scheme is available, starting from $463 per service depending on powertrain. That’s for the petrol. The diesels start from $500 while the PHEVs commence from $435.

Toyota has a five-year/unlimited-kilometre warranty which covers the C-HR, as well as capped-price servicing for the first five years or 75,000km, whichever comes first, with each 12-month/15,000km service costing $250.

The C-HR also comes with a 12-month subscription to Toyota Connected Services, with features accessible through the myToyota Connect smartphone app.