Volkswagen Transporter vs LDV T60

What's the difference?

The Transporter boasts a level of mechanical refinement, engine performance, ride quality, heavy load-carrying ability and general driver comfort that sets a high benchmark in this category. If not for its lack of an ANCAP rating and unacceptably high internal noise levels at highway speeds, it would be hard to fault.

The Max Plus brings a lot of welcome upgrades to the T60 range, particularly in its previously non-existent active safety suite, but it’s not all good news. There are still a few areas where this ageing ute could use a lot of polish.

Still, there’s something to be said for how refreshingly straightforward much of it is, and for the most part its specs and features are up to the task of competing with many more expensive alternatives.

Our test vehicle’s 3400mm wheelbase is 400mm longer than the standard model, resulting in a corresponding increase in overall vehicle length to 5304mm and a 300mm increase in turning circle to 13.2 metres.

Its 1904mm width is an easy fit in most loading zones and the standard roof’s 1990mm height means it can access most underground and multi-storey carparks which typically cap vehicle heights under 2.2 metres. It comes standard with a kerbside cargo bay sliding door and single-lift tailgate.

The well-developed front wheel-drive chassis is simple and robust with MacPherson strut front suspension and semi-trailing arm coil-spring rear suspension, the latter equipped with stout rubber cones inside the spring coils to provide a second stage of support under heavy loads. Optional heavy-duty and rough road suspension packages are also available. Brakes are four-wheel discs.

You can always pick a van designed for hard work by the amount of black plastic in body areas prone to high wear and/or scrapes, chips and dents and the Transporter has most of those covered, including the front and rear bumpers, lower rear pillars, hubcaps, door handles and mirrors.

The cabin has a back-to-basics look and feel as highlighted by numerous plastic caps blanking dashboard slots where switches are fitted to higher-equipped models. However, it has most of what you need and none of what you don’t for this working role. Even so, the lack of fold-down inboard armrests and a driver’s left footrest are notable omissions and both would be welcome for long stints behind the wheel.

The T60 Max Plus takes the visage of a factory-kitted version of the existing T60 Plus. The most notable difference this time around is the unique gloss black grille design which features a new spot to hide the front radar array for the safety suite, alongside new gloss wheel designs and that huge sports bar fitting atop the tray.

To my eye at least the T60 looks a fair bit more rugged and industrial than most of its rivals, which with every iteration are looking more like passenger vehicles than work-ready utes. Still, there’s an aggressiveness to its contrast black trims and tall ride height which may appeal to some. For others it will be more function-over-form, with less bumper overhang than something like the SsangYong Musso and there’s something to be said for that, too, I suppose.

Inside is where this Max Plus version sets itself apart from the rest of the range with its abundance of screen real-estate, upgraded materials, and an almost EV-like centre console treatment.

It’s certainly more digital-feeling and contemporary than the rest of the T60 range, but it might lose some of the simple but rugged appeal of its interior as a result.

The screens look pretty slick, especially when you’re using phone mirroring to hide the otherwise clumsy stock software suite. It’s one thing to have nice big screens, it’s quite another to have slick, attractive, and customisable software to match.

Sadly, that’s not the case for the Max Plus, which offers one lacklustre look and feel for the dash cluster, paired with an array of confusing menus on the multimedia screen.

With its 1865kg tare weight and 3000kg GVM, our test vehicle has a genuine one-tonne-plus payload rating of 1135kg and up to150kg of that can be carried on the roof. It’s also rated to tow up to 2500kg of braked trailer but that would require a sizeable 583kg reduction in payload to avoid exceeding the 4917kg GCM or Gross Combination Mass, which is how much it can legally carry and tow at the same time. Or you could keep the full payload and reduce the towing limit instead, from 2500kg to 1917kg, which may be a more useful compromise depending on work requirements.

The cargo bay, which offers 5.0 cubic metres of load volume, is 2975mm long, 1700mm wide and 1410mm high with 1244mm between the rear wheel housings. That means it can carry two 1165mm-square standard Aussie pallets, or up to three 1200 x 800mm Euro pallets, secured by a choice of eight load-anchorage points. However, the single-lift tailgate could make rear forklift access tricky, depending on forklift design and reach. The sliding door has a generous 1017mm opening for kerbside loading.

Although the load floor is bare and there’s no standard cargo protection for driver and passenger (optional rubber load floor mats and cargo barriers are available), the cargo bay walls and doors are lined to mid-height and the roof is also lined, with two roof lights providing ample illumination.

Cabin storage includes a large-bottle holder and huge storage bin in each front door, with a narrower second-tier storage shelf above which is ideal for holding smaller items like wallets, keys etc.

The dash provides another small-items cubby to the right of the steering wheel and the top dash-pad has small-bottle/cup holders at each end plus a steeply-angled open tray on the driver’s side which is ideal for storing clipboards, paperwork etc.

There’s no overhead sun-glasses holder but the passenger side of the dash offers two tiers of open storage and a large glovebox, plus another small-bottle/cup holder to the left of the gearshift console. An overhead storage shelf would be handy, given that there’s no centre console.

There are some benefits of the new interior design, and there are some disappointments too. These begin with the seating position, which is still miles off the ground in its lowest setting. This might give you a commanding view of the road, which has benefits, but it also makes you feel like you’re sitting on the T60 rather than in it.

The steering wheel is also only pitch adjustable rather than also offering telescopic adjustment, and even then its range of movement is extremely limited. For me, at 182cm tall, this meant the wheel blocked the top of the digital instruments, and I also felt like I was far too close to the roof. It’s an awkward seating position to say the least.

However, the new cabin layout has quite a bit of storage to play with. There are functional bottle holders and pockets in the doors, a decent glove box, and the new centre console offers a huge tray underneath with a removable dual cup holder insert, which also has two little cutaways for storing your keys. This area also hides some USB ports and a 12-volt outlet, for a nice cable-free interior if need be. The armrest console box offers even more space, and the wireless phone charger perched atop the console area is a welcome touch.

Less impressive is the strip of touch-based controls for the climate which sits underneath the multimedia screen. At least it has some controls which don’t require a screen sub-menu to navigate, but it simply doesn’t compare to having actual buttons and dials.

The most puzzling part of this equation is the lack of physical controls of any kind for the headlights, and no way for the passenger to adjust volume without needing to go one or two sub-menus deep. Inconvenient at best, potentially dangerously distracting at worst.

Again, some rivals get an edge here. The Musso’s multimedia suite looks comparatively old, but has heaps of physical buttons, while the GWM Ute Cannon splits the difference, maintaining buttons but gaining confusing menus. Both are better to use than the T60.

The back seat came as a surprise, as it offers pretty decent legroom for a full-sized adult, something quite rare in this ute segment. It also offers pockets on the backs of both front seats, dual adjustable air vents and a USB port on the back of the centre console, two small bottle holders in the doors, and a further two in a centre drop-down armrest. Underneath the seats there’s access points to small storage areas below.

The tray area seems reasonably well appointed with a pre-applied spray-in tub liner and four tie-down points at the extremes of the bed. The tub dimensions come in at 1485mm long, 1131mm wide (between the arches), and 530mm tall for the standard version. The Mega Tub variant extends the length to 1800mm. Payload for the tray is 840kg for the manual, 830kg for the auto, and 800kg for the Mega Tub.

Interestingly, despite its new coil-sprung rear, the T60 Max Plus maintains its 3000kg braked towing capacity, which isn’t the 3500kg industry standard, but is pretty close.

These specs mean the standard tray version is slightly larger than the Ssangyong Musso with a slightly higher payload, although it can tow 500kg less. It has a lower payload and a smaller tray than the GWM Ute, although it can tow about the same amount.

The T60 Max Plus is the new top-spec version of one of Australia’s most affordable new utes. From the outside it looks very similar to the Max Luxe which sits below it, but hides re-worked suspension, an overhauled interior, and some extra safety kit behind its tweaked grille.

It also continues to be available as a manual at $48,411, an automatic at $50,516 and as an extended ‘Mega Tub’ version at $52,092. LDV deals in drive-away pricing, and you’ll note these prices are roughly equivalent to low-grade versions of the industry leading utes like the Ford Ranger and Toyota HiLux.

The T60 is more likely, however, to compete with other low-cost ute options, like the GWM Ute Cannon also from China (from $52,990 in equivalent XSR form) or the SsangYong Musso from Korea (from $49,500 in equivalent Ultimate form).

Standard equipment is reasonably impressive, with 18-inch gloss black alloys, LED headlights, a sports bar out the rear, spray-in tub liner, a locking tailgate (for the first time), and an abundance of gloss black highlight trims to separate it from lesser models in the range.

On the inside the highlight of the overhauled design is the dual 12.3-inch screens which make up a dash-spanning digital suite. It comes with new-ish software which looks the part at a distance, although I was a little dismayed to discover it had limited functionality, only one ugly theme for the dash cluster, and minimal customisation.

You also score (very) synthetic leather seat trim with power adjust for the driver and front passenger, and an expanded array of soft-touch surfaces throughout. It looks modern and plush from a distance, but feels less impressive once you’re actually inside.

If you want a ute which does a better job of feeling more like a luxurious passenger car, the SsangYong Musso leans into this aspect harder, and if you want something that's bit more accessorised for the rough stuff the GWM Cannon XSR looks more the part. Ultimately it feels as though this new top-spec T60 is left in something of an awkward middle ground between the two.

Of course, the new safety equipment and suspension do add something to the T60 formula, but we’ll talk more about these later in the review.

This engine and transmission combination is the jewel in the Transporter crown with its energetic, flexible and efficient performance. The 2.0 litre, four-cylinder, direct-injection TDI340 turbo-diesel meets Euro 6 emissions using AdBlue and produces 110kW between 3250-3750rpm and 340Nm of torque across a 1500rpm-wide torque band between 1500-3000rpm.

The closely-spaced ratios in the seven-speed dual-clutch automatic are tailored to get the most out of this willing engine, with crisp and virtually seamless shifting. It also offers the choice of manual sequential-shifting, when hauling heavy loads in hilly terrain or simply for those wanting a more ‘sporting’ driving experience, but the seven-speeder usually does its best work when left to its own devices.

The T60 Max range lays claim to one of the most powerful 2.0-litre four-cylinder diesel engines - a bi-turbo unit producing 160kW/500Nm with peak torque arriving from 1500rpm.

It is mated to either a six-speed manual, or an eight-speed ZF-sourced torque converter automatic transmission.

It has a 2H, 4H, and 4L selector (alongside an automatic setting for the Plus Max), and is equipped with a rear differential locker (which can only operate below 30km/h).

For those looking to venture well beyond the tarmac the T60 Max Plus has a 27-degree approach angle, a 24-degree departure angle, 220mm of ground clearance, and a 19-degree rampover angle. Wading depth is 550mm, and it has a 12.7-meter kerb-to-kerb turning circle.

We covered 283km (with auto start/stop disabled) which included about one third of that distance with a maximum payload. The dash display was claiming an average combined consumption of 8.1L/100km when we stopped to top-up the 80-litre tank. Our own figure calculated from fuel bowser and tripmeter readings came in even lower at 7.7 and both undercut VW’s official combined figure of 8.3L/100km. Needless to say, that’s outstanding real-world economy, which based on our figures should deliver a huge driving range of 900-1000km from its sizeable 80-litre tank. Possibly even further with auto start/stop enabled.

The official combined fuel consumption of the diesel-only Max Plus is 9.3L/100km for the manual or 8.9L/100km for the automatic.

With over 500km of testing with plenty of freeway miles, our automatic example produced an as-tested number of 9.3L/100km.

Four-coil suspension provides a noticeably supple unladen ride quality, which is impressive for a commercial vehicle with a one-tonne payload rating. It also feels sure-footed and well planted on the road, particular on the many wet roads we encountered during a rain-affected week of testing.

With its upright steering wheel angle and nicely-weighted steering feel, it offers a comfortable almost car-like driving experience. The driver’s seat has height, backrest rake and lumbar adjustment; there’s no rake adjustment for the base cushion but it doesn’t really need it. There are also clear eyelines to all mirrors, a nicely-positioned gearshift and an uncluttered dashboard/instrument layout that’s easy to read and operate.

The 2.0 litre turbo-diesel has energetic response in its peak torque band between 1500-3000rpm, where most city and suburban driving occurs. Snappy, seamless up-shifting occurs between 1500-2000rpm, providing brisk acceleration with excellent fuel economy. At highway speeds, good gearing ensures the engine needs only 1800rpm to maintain 100km/h and 1900rpm at 110km/h.

We only have two criticisms. One is the size and limited wide-angle effect of the left-side mirror, given the huge blind-spot that a solid-walled long wheelbase van like this creates over the driver’s left shoulder. Although the Transporter is (thankfully) equipped with blind-spot monitoring, a larger kerbside mirror with a more convex shape to increase its angle of view would be welcome.

The other is high internal noise levels at highway speeds emanating from the rear wheel housings. On some grades of coarse bitumen it can sound like the roar of a jet engine, which is too loud for sustained periods and could be a deal-breaker if you do a lot of highway work. We have recently tested rival vans without cabin bulkheads which have appreciably lower cargo bay noise levels at similar speeds (most notably a Chinese brand), so it can be done.

The T60 Max Plus has improved the formula in a few ways, but still feels a bit rudimentary in others.

The awkward seating position does provide quite a commanding view of the road, and makes it easy to gauge where the end of the bonnet is. This is useful parking in a city, but will also have benefits off the road. The 360-degree camera suite also helps with this manoeuvrability.

Interestingly the steering is quite good. This Max Plus is the only variant to score a fully electric power steering rack, as opposed to the lesser power assisted steering rack. It’s initially alarmingly light, but it also makes the T60 a breeze to steer unlike some utes in this class, and I was surprised to find it still had a sufficient amount of feel to give it confidence in the corners.

Yes, this is one of the most powerful 2.0-litre diesels, but it doesn’t feel particularly overwhelming to drive. The transmission, too, despite the brand bragging about its ZF sourcing, feels a bit transparent and rudimentary lumping through the gears with a degree of clumsiness. Still, it’s predictable and does what it says on the tin.

The same goes for the 4H and even ‘automatic’ 4x4 settings, which I found was surprisingly quick to activate if you started slipping on mud or wet tarmac.

Another less than impressive trait is the amount of sound produced. Supposedly this Pro Max version has additional sound deadening over the other variants, and yet the clatter of the diesel engine proved a constant in the cabin at freeway speeds or any time you needed to accelerate hard.

This particular version of the T60 should also feature an improved ride compared to its relations thanks to swapping the leaf sprung rear suspension out for coils, but I was surprised to find it was still quite stiff. No doubt this inherent hardness is down maintaining the same towing capacity. It makes it a bit jiggly when you drive it over the regular sort of road imperfections and corrugations. One wonders what the point of having coil spring suspension is at all if it’s going to feel more or less the same as leaf sprung alternatives.

One area that was particularly pleasing to me was the way the new active safety equipment wasn't overly invasive. There were a few moments where the lane keep tech intervened a bit too hard, but it’s pretty hands off as far as the rest of the systems go.

Overall then it does what it says on the tin, and is surprisingly easy to steer, although it doesn’t really excel at anything, which can be a hard sell in an environment where many utes are more passenger car like than ever.

Perhaps one of the biggest pieces of new equipment on the T60 Max Plus is the more competitive array of safety equipment than before. It includes auto emergency braking, lane keep assist with lane departure warning, and adaptive cruise control. It also gains a set of front parking sensors to add to its 360-degree parking camera suite.

Technically the LDV T60 range maintains a maximum five-star ANCAP rating, but it dates back to 2017 and is thus about to expire. It has a total of six airbags, consisting of dual front, side, and curtain.

Five years/unlimited km warranty with 12 months complimentary roadside assist. Scheduled servicing every 12 months/15,000km whichever occurs first. Capped-price servicing for first five scheduled services up to five years/75,000km of $3082.

LDV continues to have a confusing array of ownership terms across its range. In the case of the T60, it’s seven years and 200,000km, with five years of roadside assist.

It is also one of the only brands on the market not offering any kind of capped-price service program, so it’s a mystery how much it will cost to run. Servicing is required once every 12 months or 15,000km.