LDV Deliver 9 vs Toyota HiLux

What's the difference?

It has its flaws, like any vehicle, but it’s not as far away from segment leaders in terms of refinement and performance that its bargain-basement pricing might suggest. Whichever way you look at it, this is a lot of van for not a lot of money.

The Toyota HiLux SR5 now feels nicer and more modern inside and out and it no longer lags behind some other utes – even some of the cheaper ones – in terms of comfort, refinement and all-round driveability.

Toyota has in the past been guilty of sometimes doing the bare minimum when it comes to producing a ‘new’ vehicle – especially LandCruisers or HiLuxes – but this time even though this HiLux is definitely not a new model, the exterior revamp and interior refresh have added more than enough to the HiLux package to keep fans and new buyers happy.

This is the best HiLux so far.

If imitation is the greatest form of flattery then Ford should be blushing, because the Deliver 9 appears to draw a lot of exterior design inspiration from the Transit van. It’s a substantial vehicle, as they tend to be in this weight division, with a 3750mm wheelbase and 14.2 metre turning circle, length of almost 6.0 metres (5940mm) and width of 2466mm. Its 2535mm height excludes it from underground and shopping centre carparks with typical height limits of 2.2 metres.

The rear-wheel drive chassis construction is simple and robust, with MacPherson strut front suspension, multi-leaf live axle rear suspension with supplementary rubber cones to boost support of heavy loads, rack and pinion steering and four-wheel disc brakes. There’s also ample use of hard-wearing black plastic on lower body sections where most scrapes and dents appear.

The cargo bay is accessed by one kerbside sliding door and dual rear-barn doors with 180-degree opening. The walls are lined to mid-height and there’s no roof lining. Bright LEDs provide ample lighting and even though our test vehicle was not the high-roof model, there was enough headroom for tall adults to stand without stooping. 

The cabin has a spacious and airy feel, even with a crew of three aboard, thanks largely to a banana-shaped dashboard with ends that curve towards the windscreen providing wide entry access and passenger legroom which is unusually generous for a commercial van.

The cabin has higher-grade look than you would expect at this price, with a tasteful two-tone blend of light/dark grey plastics and faux carbon fibre inserts on the dash along with comfortable, supportive seats with quality-feel fabrics.

However, there is room for improvement, as there’s no cargo protection for driver and passengers, no driver’s left footrest, crackly AM radio reception (too bad if you like talkback) and a poor-quality image projected by the reversing camera.

This HiLux is 5320mm long (with a 3085mm wheelbase), 1885mm wide and 1865mm high. No change there.

It does, however, have a new distinctive front end incorporating a revised design, which includes LED headlights, retro-style ‘Toyota’ brand across the front, and honeycomb-style mesh grille.

Initially I wasn’t keen on the HiLux’s revised front end, but it looks a lot better in the metal than it does in photos and it has grown on me.

This ute’s profile remains the same as before, but the rear end has also been given a sly slap and tickle, giving it a squared-off look.

The interior has also undergone a glow-up – there’s a real 250 Series LandCruiser look and feel to this cabin – and it now has a 12.3-inch touchscreen multimedia system rather than the old 8.0-inch unit.

It still has plenty of hard plastic surfaces but, overall, the HiLux interior doesn’t look or feel anywhere near as old as it used to.

While it remains definitely a HiLux, the new look brings this Toyota ute closer to its rivals, such as the Ford Ranger, in terms of contemporary styling.

Its 2358kg kerb weight and 4000kg GVM leaves a competitive maximum payload of 1642kg. It’s also rated to tow up to 2800kg of braked trailer but given the GCM figure (or how much you can legally carry and tow at the same time) is not published, we can’t tell you how much payload it can legally carry while towing that weight. 

We struck a similar problem testing a G10 LDV van as far back as 2017, when LDV could not provide the GCM despite a direct approach to the factory in China. Why such a fundamental figure must remain secret is a mystery to us and could be a deal-breaker if you need to tow and carry.

The cargo bay offers a competitive 10.97 cubic metres of load volume. Its load floor’s 3413mm length, 1800mm width and 1366mm between wheel housings means it can easily carry two 1165mm-square Aussie pallets or up to four 1200 x 800mm Euro pallets, held in place by a choice of eight sturdy load anchorage points. There’s also a small cave above the cabin which is ideal for carrying straps, ropes, load padding, tarps etc.

There’s more than ample cabin storage too, with large-bottle holders and two levels of storage in each front door, numerous nooks of different shapes and sizes across the dashboard including a driver’s cup holder, plus a single glove-box and large overhead storage shelf with central sunglasses holder.

Pivoting the two passenger seat base cushions forward reveals another big storage area beneath them. The centre seat backrest also folds down to reveal a handy work desk on the back if it, which includes two cup holders. Overall, there’s smart use of space here.

The HiLux cabin is very familiar – you know where everything is and how to use it and that’s reassuring – but besides some minor changes and the introduction of an electric park brake the most noticeable change is that aforementioned new 12.3-inch unit.

Apple CarPlay is easy to get working via the multimedia system, and the screen is now big enough and clear enough to operate with ease.

Beyond that, there are plenty of durable hard plastic surfaces, numerous storage spaces, a reasonable number of charging points up front – two USB ports as well as a wireless charging pad and two 12V sockets and a 240V socket inside the centre console.

The driver’s seat is power-adjustable and comfortable without ever being at risk of being described as “plush”.

The rear seat is on the wrong side of squeezy across the shoulders and is best suited to accommodating three children, three jockeys or two adults.

People seated back there have access to two USB-C ports, bottle holders in each door and a dual cupholder in the fold-down centre armrest.

In terms of packability for touring, the SR5’s tub is 1550mm long (1100mm between the wheel arches), 1520mm wide and the load space itself is 490mm deep. Load height is 830mm.

There is nothing extra-special going on in the SR5’s tub – no marine-grade carpet, LED strip lighting, or hidden storage compartments – but it does have four tie-down points.

In terms of practicality, the HiLux, while it does have a barebones approach, still holds its own against the likes of the Ford Ranger.

The SR5 sits in the middle of the HiLux line-up. This version – with a six-speed manual gearbox – has pricing starting at $63,990 before on-road costs. Our test vehicle has Toyota’s premium interior pack ($2500) and premium paint ($675).

Standard features include a 12.3-inch touchscreen multimedia system (with wireless Apple CarPlay and Android Auto plus wireless charging), eight-speaker stereo, dual-zone climate control, and 18-inch alloy wheels.

Other features include high-grade LED headlights, a “comfort-oriented” leaf-spring rear suspension tune, larger front brake discs, power-folding, heated exterior mirrors, an integrated tow-bar, as well as LED tail-lights and LED rear fog lights.

Exterior paint choices include 'Glacier White', 'Frosted White', 'Ash Slate', 'Eclipse Black', Feverish Red' and 'Sunglow'. Some – like 'Stunning Silver' on our test vehicle – cost $675.

The HiLux offers reasonable value for money when cross-shopped against the likes of Ford Ranger, especially the XLT (approx. $64,000) or Sport (approx. $72,000) variants.

LDV’s Euro 5-compliant 2.0-litre four-cylinder turbo-diesel produces 110kW at 3500rpm and 375Nm between 1500-2400rpm, which is adequate but not class-leading. It also offers a choice of Eco and Power driving modes and auto stop/start. 

The six-speed torque converter automatic is smooth-shifting and easy to use. It also has the option of sequential manual-shifting which can be handy at times when hauling heavy loads, particularly in hilly terrain to save the transmission from continually hunting for gears.

This SR5 has a 2.8-litre four-cylinder turbo-diesel engine, producing 150kW at 3400rpm and 420Nm at 1400-3400rpm and a six-speed manual gearbox; the six-speed auto SR5 gets 500Nm at 1600-2800rpm and auto HiLuxes also have the 48-volt mild-hybrid technology onboard.

This is a proven engine-and-gearbox combination, with plenty of lowdown torque, and it’s more than a match for the likes of Ranger and D-Max/BT-50 in terms of overall performance.

This SR5 has part-time four-wheel drive and a rear diff-lock.

The dash display was showing an average combined figure of 11.0L/100km at the end of our 290km test, with the auto start/stop function disabled and about a third of that distance hauling maximum payload. Our figure crunched from fuel bowser and tripmeter came in at 12L/100km, so you could expect a real-world driving range of around 660km from its 80-litre tank.

Official fuel consumption for the manual is listed as 7.1L/100km on a combined cycle. The auto is 7.4L/100km.

Fuel consumption on this test was 9.1L/100km, which is pretty good because I have done a lot of low-range 4WDing.

The SR5 has a 80-litre fuel tank so, going by that fuel figure, you could reasonably expect a driving range of about 879km out of a full tank

It’s pleasantly civilised to drive unladen, even on bumpy roads. With rock-hard tyre pressures (front 51psi, rear 71psi) recommended for load-carrying, the unladen ride remained disciplined and relatively smooth, so LDV has done a good job with the suspension tuning.

We were also pleasantly surprised by the low internal noise levels, not only in city and suburban driving but also at highway speeds. We can only assume that the load floor’s thick rubber flooring, which also covers the rear wheel housings, is effective in reducing the higher noise levels typically experienced in vans without cabin bulkheads like this one.

There are clear eye-lines to the door mirrors and the view through the rear doors using the central mirror is also uncluttered. There’s evenly-balanced elbow support for the driver between the fold-down inboard armrest and door moulding. However, we did miss having a left footrest.

With maximum torque available across a broad band between 1600-2400rpm, the engine displays good flexibility in city and suburban driving, even though it lacks the instant punch of rivals like the Transit’s stellar 2.0 litre EcoBoost engine when operating in its peak torque zone. The engine only needs 2000rpm at 100km/h and 2250rpm at 110km/h, but the degree of push required on the accelerator pedal to maintain it feels like it’s punching above its weight a little in either drive mode.

Our only major gripe is the adaptive cruise control. Usually these systems will automatically resume their pre-set speed, after being given clear road ahead following a lane change from behind a slower vehicle. However, our test vehicle required tapping the accelerator each time a lane change was made to resume the set speed. It also required this reset technique after downhill braking, so some refinement here would be welcome.

As mentioned, there have been no major mechanical upgrades to the HiLux, but it does now have electric power steering (rather than the hydraulic assistance it’s had in the past). Result? There’s a smoother, more precise feeling to the steering, with a nice weight and balance to it, on sealed and unsealed surfaces.

The HiLux, with a listed kerb weight of 2215kg and a turning circle of 12.6m, is not an insubstantial vehicle but, at the same time, it’s not unwieldy either and manages to feel quite nimble on and off the road.

On sealed surfaces it yields a surprisingly high level of ride and comfort. It’s actually quite compliant, controlled and somewhat refined. That’s largely because this SR5 has multi-purpose suspension on board rather than the heavy-duty suspension, which is on lower-spec, work-focussed HiLux variants for load-carrying duties.

This set-up is intended to offer a softer ride on road – and it does – but off-road it's a different story. Even on minor imperfections (small potholes, minor corrugations and the like) on dirt tracks it tends to thump and bump in and out and it doesn't offer such a comfortable all-round ride as you might be hoping.

I didn’t have much weight onboard – vehicle-recovery gear, a first-aid kit, four Maxtrax and an air compressor – and it will, of course, settle down with more of a load but I was expecting the multi-purpose suspension to be better than it was at soaking up a track’s lumps and bumps – it’s not terrible, but it is noticeable.

However, in terms of pure off-road effectiveness, the HiLux is impressive.

It's never been an underperforming 4WD, it’s simply never been as refined or as comfortably capable as others, such as the Ranger, but it is much more comfortably capable now than it used to be.

There is plenty of power and torque in this HiLux and while this six-speed manual version has 80Nm less than the auto version, it uses what it has really well. The 2.8-litre is a tractable engine and works well as part of an effective powertrain that is well suited to low-range 4WDing. There is a heap of torque at low revs, which is great for low-speed, technical off-roading.

Low-speed throttle response is also impressive, offering nice control when you need it.

I have driven auto HiLuxes in the past and the auto is very clever and it may be your better bet, but I like the manual.

Ground clearance is listed as 224mm and while the HiLux doesn’t have any trouble clearing most jagged rock steps or tree roots you’ll likely encounter on a weekend trip, I didn’t have the opportunity to seriously scrutinise the 700mm wading depth because our testing area was pretty dry. Next time.

Off-road angles – 29-degree approach and 26-degree departure (no rampover is listed) – all check out, even though they are a little shallower than the Rugged or the Rogue variants, they are fine for light-to-moderate 4WDing.

The off-road traction control system in this HiLux is well calibrated and if you do need more dirt-grabbing ability, then this ute does have a rear diff lock.

The only real off-roading weaknesses in the HiLux package are the tyres (Dunlop Grandtrek A/T 31, 265/60R18 110H). They’re not well suited for anything more than light to moderate 4WDing. If you’re planning anything rougher than a well-maintained dirt road in dry weather then consider replacing the showroom tyres with a set of decent all-terrain tires, light-truck construction preferably and away you go.

In terms of towing capacity the SR5 is rated to tow 750kg unbraked, and 3500kg braked.

Payload is a listed 900kg, Gross Vehicle Mass is 3090kg and Gross Combined Mass is 6300kg (a 450kg increase).

While nothing mechanical has changed onboard this vehicle, the combination of 4WD set-up, driver-assist tech, rear diff lock, as well as structural modifications (such as thicker steel in the ladder-frame chassis, a stiffer roll-bar, and reinforced side rails) and suspension tweaks (including retuned dampers and re-rated coil springs at the front, and new dampers and softer spring rates on the live-axle rear) all works well together in this current HiLux package.

The HiLux has now drawn closer to the Ranger in terms of comfortable capability, if not matched it.

The Toyota HiLux SR5 has the maximum five-star ANCAP safety rating, as a result of testing in 2025.

As standard, it has eight airbags (now with a front-centre airbag) and an upgraded suite of driver-assist tech including improved auto emergency braking (AEB), lane-keep assist, adaptive cruise control, and blind-spot monitoring.

LDV’s national network of 82 dealers inspires more confidence than the three years/160,000km warranty, which is less than the major players – but then its purchase price is much lower too. Scheduled servicing is six months/5000km then 12 months/35,000km whichever occurs first and 12 months/30,000km after that. Capped-price servicing program of $1895 covers the first three years or 95,000km whichever occurs first.

The HiLux has a five-year/unlimited kilometre warranty.

Service intervals are scheduled for every six months or 10,000km and cost $395 per service.

Toyota Australia has about 300 dealerships across the country.

This type of warranty is pretty standard among the HiLux's rivals so the Toyota ute does remain competitive, in terms of these ownership costs.