Alfa Romeo Tonale vs Volvo EX30

What's the difference?

If you’re an ‘Alfa Romeo person’, or even just an ‘Italian car person’, you’ve got this on your short list and there’s little I can say that will change your mind. 

And you wouldn’t be making a bad decision if you did pick up a Tonale.

But if $80,000 sounds like a lot for a small SUV and you still want something that looks stylish and feels special, the mild-hybrid Tonale Veloce should do, if the likes of the X1, Q3, or XC40 don’t scratch that left-of-centre itch.

And a fun small SUV? A Mini Countryman JCW, Audi SQ2 or VW T-Roc R are all different sizes, but all more powerful than the Alfa and all fall below the $70,000 mark.

But, if you’re keen on that plug-in hybrid drivetrain and have a day-to-day lifestyle that’ll allow you to make the most of its electric range (and most major city-dwelling Australians do to some extent), then the outlay might just be worth it to be able to check out the Tonale in your garage or driveway every day.

There’s a lot to like about the Volvo EX30 Cross Country. It’s an impressive AWD EV. Nice to drive, comfortable and offering the extra driver confidence an AWD system brings.

It also looks good, has a decent stack of features onboard and has plenty of appeal for owners, especially in terms of servicing costs.

As an EV tourer, it has a reasonable driving range and offers enough in terms of AWD flexibility to appeal to those people who may like the idea of an all-electric adventure machine.

But it is small, has a limited scope of off-road capability and pricing is ranging upward for what it offers.

If Alfa any traditionalists are hesitant to embrace the Tonale’s hybrid drivetrain, surely the Tonale’s styling has the opposite effect.

Small SUVs can fall victim to trying to look too much like a hatchback, or being plastered with lots of little trim details to break up large areas. The Tonale, on the other hand, looks like an SUV regardless of size, and its styling elements are decidedly restrained.

Most notably, at the front, Alfa Romeo has employed the ‘scudetto’ shield-shaped grille and horizontal lower grilles to form the ‘trefoil’, a face as familiar as BMW’s kidney grille or the Porsche 911’s round headlights.

The aforementioned ‘3+3’ headlights are sleek, and somewhat mirrored by similarly styled tail-lights that flank a light bar across the middle of the boot. Badging is minimal, the ‘Tonale’ on the rear in a cursive ‘Alfa’ typeface and the small ‘Veloce’ lettering found only on the front three-quarter panels.

The 20-inch wheels are so Alfa Romeo in their ‘teledial’ circular design, though all three wheel options for the Tonale fit into this theme. In a car park or on the driveway, they’re certainly eye-catching to those not expecting them - a friend said upon sight of this test car, "Look at the wheels. They’re silly! I love them!".

Inside, the cabin space isn’t too ‘busy’ with visual elements, though some of those that are there - the row of buttons for climate control or the multimedia screen, for example - are possibly a little too simple. The buttons could be from any old car, and the screen looks like a ‘tacked on’ rectangle.

Just about everything else looks suitably restrained but relatively elegant for a small SUV, though, with elements like the steering wheel remaining rather simple and (in modern terms) timeless. The paddles behind it are a bit of visual theatre, too.

Like the exterior, the interior adopts some circular cues like the air vents, door speakers, DNA drive mode dial, and even the cowl over the driver display. 

The second row is a little more spartan, with little in the way of visual ‘wow’ and a disappointingly basic vent (albeit adjustable in two different directions) and USB ports mounted in hard grey plastic.

For the most part, the interior looks quality, and with relatively minimal hard or scratchy plastic, feels it too.

This Cross Country is 4233mm long (with a 2650mm wheelbase) 1850mm wide, and 1567mm high. It has a listed kerb weight of 1910kg.

It’s a slick-looking compact SUV with more than its fair share of hints at its off-road aspirations including raised suspension so it perches higher off the deck than its regular EX30 stablemates (190mm of ground clearance). It has dark coloured front and rear body panelling, dark wheel-arch extensions (built to cop any loose gravel or dirt while all-wheel driving on well-maintained bush tracks), and if you get on the ground to check, front and rear skid-plates.

Quirky touches include an impression on the front bumper section of a topographical map depicting the highest mountain range in Sweden (as well as the apparent co-ordinates to that location), and interesting doodles under the lid of the front boot (what I like to call the 'froot' whereas as you might call it the frunk for front trunk).

Overall, the Cross Country has a spartan-style cabin. No, I don’t mean there are swords and shields and oiled-up blokes in loin cloths here – just that there’s a clear, basic layout that leans more towards functional than flashy.

It also has a fixed-in-place panoramic glass roof that has no sliding cover built into the ceiling and I’m not a big fan of having my noggin exposed all of the time.

Inside, the Tonale feels relatively spacious for a small SUV, with possibly more places to put things than you might expect from a traditionally enthusiast-focused brand. 

In both front and rear seats, no part of the body or console impedes on passenger space - though the door armrests feel like they're a little far to comfortably rest an elbow on - and nothing gets in the way when reaching controls or the centre console.

Ergonomically, everything falls well to hand and no far reaches are really required, though the cupholders in the centre are a little narrow for some relatively normal-sized cups or bottles, and have rubber grips inside that require a little extra pull to retrieve items from.

Other options for bottles include the door pockets, or for a small bottle even the centre console bin is quite deep (albeit narrow).

Smartphones, even fairly tall ones, will rest securely in the angled - a nice touch - wireless charging bay, though while having the phone in a position it won’t slide out from is a plus, angling a phone screen to be visible to the driver might be too tempting for some. It is, mercifully, a little obscured by the gear shifter.

On controls, the steering-wheel design hasn’t changed for more than half a decade which, honestly, is so, so fine. Really, Alfa’s steering wheel has few buttons including the engine start, a relatively timeless (read: simple) visual style, and a thin rim with moulded thumb rests that encourage 9-and-3 hand positions.

The buttons on the wheel are easy, clear, and feel nice, and controlling the driver display is relatively easy as there aren’t really sub-menus to get lost in.

The main multimedia screen is also relatively well laid out, marking a nice step up from previous Uconnect systems (Jeep and Fiat owners will also know), though the connectivity with wireless phone mirroring, Android Auto in my case, was a little laggy and dropped out occasionally, seemingly in the same spot on the same Melbourne CBD street during my commute each morning.

The downsides are relatively few on the practicality front, but there is another: the boot space in the hybrid suffers due to the battery space needed, so 500 litres for the non-plug-in Tonale variants is down to 385 litres for the PHEV.

That’s still less than an electric Volvo XC40 Recharge (claimed to be 418L), though fortunately it grows to a spacious 1430 with the seats folded down, and is accessible via an automatic electrically opening boot door.

Another important point, while we’re in the boot, is the lack of spare tyre. Instead, a repair kit is provided - something those who enjoy a road trip might lament.

Inside, the driver misses out on a digital instrument display but the centrally-located, vertically-mounted 12.3-inch touchscreen multimedia system offers wireless Apple CarPlay and Android Auto as well as pretty much every control and gauge you could wish for and, as driver, you quickly get used to checking that screen for your current speed etc.

It also offers a way to open the glove box (that sits below the screen) and quick ways to switch off driver-assist aids, such as 'Lane Departure Warning' and the 'Driver Alert System', which could otherwise be a bit annoying. Unfortunately, you have to switch off those systems every time you get back in the car.

The screen is where you’re also able to cycle through drive modes, vehicle settings and the like. The front seats are power-adjustable set-ups and they are heated but not ventilated. There is plenty of durable plastic inside the cabin as well as a denim-like 'tailored wool blend' seat upholstery and soft-touch surfaces.

In terms of space, well, as befitting a compact SUV, there’s not a lot of it for gear or people. The aforementioned glove box is small, there’s no centre console (only sliding cupholders above, and a narrow receptacle below with a wireless charging pad) plus the door pockets are thin and shallow.

And second-row passengers don’t fare too well, either. It’s squeezy back there – even for a Hobbit-sized bloke like me – and there are few amenities.

No fold-down armrest with cupholders, no directional air vents and that panoramic glass roof doesn’t have a sliding cover so those in the front and back cop the full brunt of the summer sun. I can vouch for the ouch too because I had this Cross Country during record-high summer temps in NSW and my gigantic forehead (due to a hairline that keeps creeping rearward) suffered a roasting. That’s about the only circumstance – no sunroof cover and extreme heat – in which it’s okay for someone to wear a hat while driving.

In terms of storage, with both rows in use, there’s a listed 318L of volume in the rear cargo area and 1000L when the second row is stowed away. The rear cargo area has a light and bag hooks and there’s a charging cable and tyre-repair kit in the shallow underfloor storage space.

It’s well worth noting that this vehicle, despite being marketed as an all-wheel drive vehicle with adventure potential, doesn’t have any spare tyre onboard.

At the front of the Cross Country, there is seven litres of cargo volume in what I call the 'Froot' (front boot) rather than the 'Frunk' (front trunk).

The Volvo EX30 Cross Country is top-of-the-range in the three-variant EX30 range and it has a manufacturer suggested list price of $69,990. It’s the best variant in the range if you’re keen to travel beyond the bitumen. For reference, at time of writing, the 2026 Volvo EX30 Single motor Extended range Plus is $59,990, before on-road costs, and the Extended Range Ultra is $66,290, excluding on-roads.

Standard features include a 12.3-inch touchscreen multimedia system (with wireless Apple CarPlay and Android Auto, and over-the-air software updates), wireless charging, AWD, three driving modes, a Harman Kardon stereo with front sound-bar, a 360-degree camera view, semi-autonomous parking assist and 19-inch alloy wheels.

It also has LED headlights and tail-lights, a digital key (Bluetooth phone unlocking), heated steering wheel, power tailgate and a fixed panoramic glass roof (but no sliding cover).

In terms of off-road-specific features it has a 'Performance' drive mode (which optimises all-wheel drive), 'Hill Descent Control' and front and rear skid plates.

Exterior paint options include 'Cloud Blue', 'Crystal White', 'Onyx Black', 'Vapour Grey' and 'Sand Dune'.

For reference, vehicles that you might consider rivals in the same realm as the Cross Country – such as the Kia EV3 (about $63,950 MSRP for a top-spec GT-Line), Zeekr X (about $64,900 MSRP for the top-of-the-range all-wheel drive variant), and Skoda Enyaq (about $65,990 MSRP for the 85 Sportline) – are a few grand cheaper while packing as much, if not more, features onboard and managing to look and feel more premium than the Volvo. The Cross Country's price is creeping up for a vehicle that is quite spartan inside. More about that soon.

Engaging driving is key to an Alfa Romeo justifying being somewhat on the pricier end of the cost spectrum, so numbers like ‘208kW’ for a total system output in a small SUV are welcome to see on paper.

The Tonale’s 1.3-litre turbocharged petrol four-cylinder engine alone makes 132kW and 270Nm, aided by an electric system outputting 90kW and 250Nm. The 208kW is its total useable peak, with Alfa not stating a peak torque figure, but a 0-100km/h claim comes in at a fairly impressive 6.2 seconds.

That’s helped by the Tonale’s all-wheel-drive nature, the front wheels driven by the engine via a six-speed torque converter automatic, and electricity powering the rears.

The EX30 Cross Country has a twin-motor electric set-up, producing a combined 315kW and 543Nm. It has a single-speed transmission and a 69kWh battery.

Drive modes include 'Standard', 'Performance' (taps into all-wheel drive and is the preferred mode for light off-roading) and 'Range' (defaults to rear-wheel drive to get most out of battery).

It does not have any off-road driving modes (like Sand, Mud or Snow) but it does have 'Hill Descent Control'.

Claimed 0-100km/h time is just 3.7 seconds.

A 42.5-litre petrol tank and a 15.5kWh lithium-ion battery combine to provide an electric driving range of 60.5km that’s backed up by the ability to charge or save power for when it’s needed by letting the internal-combustion engine (ICE) kick in.

And while this has the potential to mean essentially no fuel is used in short-run, day-to-day driving, anything resembling a longer trip means you’re unlikely to reach the kind of efficiency figures Alfa Romeo claims.

The official combined fuel consumption figure for the Tonale PHEV is 1.5L/100km, though achieving this would require stopping and recharging the battery every 100km of driving, and the driving would need to be in perfect conditions for battery range - i.e. relatively low speeds.

The Tonale PHEV is efficient, yes, but it’s not ‘1.5L/100km efficient’ in the real world if you need to take a drive longer than a standard work day with maybe an errand or two.

After 23 kilometres of real-world driving, the indicated battery range dropped from 65km (odd given Alfa’s spec sheet provided claims a 60.5km range) to 30km, an indicated drop of 35km.

A 12 km discrepancy between over just 23km of standard driving isn’t ideal, though the trip included some highway driving - not an electric drivetrain’s best stage.

Alfa Romeo says a household-style 3.0kW charger should fill the battery from empty in 5.5 hours, while a ‘fast’ charger at 7.4kW should take 2.5 hours via the Type 2 charging port.

Official combined cycle (urban/extra-urban) energy consumption is listed as 19.1kWh/100km. On this test, I recorded 18.4kWh/100km, which is impressive, especially considering I took this Volvo on some tracks that pushed the limit of its capabilities.

For reference, the 2026 Subaru Solterra AWD Touring has claimed energy use of 16.0kWh/100km, but I've yet to test it to gauge its real-world energy consumption, under pressure in tough (for an AWD) conditions.

The EX30 Cross Country has a 69kWh battery and according to Volvo can be charged from 10 to 80 per cent in as little as 30 minutes on a fast 175kW DC charger.

It took me about 18 hours to get it from 20 to 80 per cent on a household socket (16 amp/3.6kW).

It has a listed driving range of 417km (WLTP) on a full charge. Official driving range is “up to 417km (WLTP)”.

This might be the make-or-break topic for a select few Alfa Romeo customers - is the Tonale fun to drive?

Yes, thankfully.

Where the mild-hybrid was sometimes criticised for being slightly underwhelming for a car wearing the snake-adorned badge from Milan, the extra power, all-wheel-drive grip and electric torque delivery make the Tonale feel spirited enough for a sporty-leaning small SUV.

The DNA dial really does come into play plenty, too. 

D, for dynamic, is pretty much reserved for when you’re actually ‘driving’ the Tonale - its stiffened suspension and relatively greedy power draw isn’t for low-speed commuting or daily efficiency.

N, or natural, is best for most long-ish commuting or trip situations, particularly highway driving where relying fully on the battery range isn’t ideal, as mentioned.

A, for advanced efficiency, is the ‘EV mode’ and best suits anyone whose daily commute takes them between urban or suburban areas which can be done under EV driving, though it can be used up to 206km/h.

If you don’t mind the petrol engine kicking in on occasion, leaving ‘natural’ to its own devices will result in some relatively frugal driving - a week of testing, commuting, filming and enjoying the Tonale used less than a tank of fuel, including one round trip of more than 140km.

Commuting in the Tonale proved comfortable enough - the steering is light and the dual-stage valve suspension in its softer mode combined with the electric drivetrain resulted in a calm and controlled feeling.

Its suspension soaks up bumps well, though a consistently uneven road surface can feel a little jittery (though not harsh or crashy) after a while.

Getting more dynamic (yes, the D on the dial), however, brought out some interesting characteristics of the Tonale. That light steering is paired with a quick rack (a 14.8:1 ratio, or two-and-a-half turns lock to lock), meaning the Tonale is easy to turn in hard, and a 53F/47R weight distribution provides enough balance (paired with a low centre of gravity thanks to the battery) to keep on top of the small SUVs movements.

All four wheels being driven under its ‘dynamic’ hybrid mode means grip and acceleration in cornering is plenty useful, though braking coming into the corners via the Tonale’s ‘brake by wire’ system could be a little more feelsome.

The gearbox is very eager under acceleration, too much so for commuting, but if it doesn’t suit your needs even for spirited driving then the manual mode is there.

It’s worth noting that those huge brushed alloy shift paddles come into play here, though being attached to the column steering rather than the wheel presents a key ‘pro’ and ‘con’ each: the paddles are always in the same place, just not always in relation to your hands.

This compact, all electric SUV has a ton of power and torque from the get-go. It’s impressive on almost all surfaces and it really is fast.

It has listed kerb weight of 1910kg and a turning circle of 11m, and this is a highly manoeuvrable vehicle.

The driving position is at best low and sporty, and there’s adequate visibility, even though it is pinched in places, especially looking back towards the rear of the vehicle.

This is a smooth and refined compact SUV that's nice to drive on- and off-road.

The Cross Country punches well above its weight in terms of power and torque and throttle response is great. It even errs on the side of too energetic, but steering is precise, the transmission is slick and the brakes have plenty of bite.

You’re able to change driving characteristics on the main screen by cycling through the drive modes (Standard, Range and Performance). Performance is a key mode when you hit the dirt because that fully engages and optimises the all-wheel drive system to give you that sure-footedness on looser surfaces.

Range is aimed at optimising the vehicle’s energy efficiency and Standard is not too bad for general day-to-day driving conditions.

When you do get off road, it handles minor corrugations well. It also deals with deeper, more severe potholes reasonably well. It’s pleasantly surprising that it stays so settled and composed while you're going through some lumpy and bumpy stuff.

The Cross Country is not an off-road animal as such, it can handle things when the road surface becomes more traction-compromised than you may normally face. But with limited ground clearance (even if it’s 19mm higher off the ground than the regular EX30 for a total of 190mm) the Cross Country is not a rock-crawling beast.

It doesn't have any off-road driving modes, however it does have hill descent control. But that's really for mild inclines and downhills where it has to hold a safer speed than it may otherwise achieve.

In terms of dimensions, it's not that well set up for off-roading. You don't want to take this anywhere near four-wheel drive only terrain. But having said that, it is more than capable of handling light to moderate off-road conditions – mild corrugations, some deeper potholes here and there, loose gravel, loose stones, those sorts of things.

In fact, there's no reason why you can't drive this vehicle on well-maintained tracks in dry conditions to your favourite campsite in a national park, even if it's a bit slippery.

The suspension set-up – Macpherson strut front, multi-link rear – is well suited to on-road driving. And while the Cross Country tends to feel a bit firm in places, it remains composed and settled when things become lumpier and bumpier, say, for instance on dirt tracks and gravel roads.

Its raised suspension (compared to the regular EX30) is on the firm side of things and it become a little jittery when the road becomes more corrugated and less well-maintained. But otherwise it is mostly well settled, well composed and ride and handling is nicely controlled.

This Volvo’s towing capacity is 1600kg.

Its all-season tyres – Goodyear EfficientGrip Performance SUV (235/50R19) – are on 19 inch rims and that’s not a package well suited to off-roading of any kind, really. There’s always the option of swapping them for some all terrain tyres on an 18-inch rim and that combination would instantly make this Cross Country even better for mild to moderate off-roading.

The Volvo EX30 Cross Country has the maximum five-star ANCAP rating from testing in 2024.

It scored 35.27 out of 40 (88%) for Adult Occupant Protection, 42.03 out of 49 (85%) for Child Occupant Protection, 50.36 out of 63 (79%) for Vulnerable Road User Protection, and 14.48 out of 18 (80%) for Safety Assist (includes AEB, driver monitoring and lane support system).

As standard, it has seven airbags and a comprehensive suite of driver-assist tech including AEB (with pedestrian, vehicle, large animal and cyclist detection), 'Lane Departure Warning' (intrusive in operation, but easy to switch off), a 'Driver Alert System' (also over-reactive but easy to switch off), adaptive cruise control, hill descent control, a 360 degree camera view (with a 3D view) and a tyre pressure monitoring system.

As mentioned, it’s missing any real off-road driving modes but then again, the Cross Country isn’t built to tackle anything too rough and tumble.

There is a ISOFIX child seat attachment on each outer seat in the second row and top-tether anchor points on all second-row seatbacks.

Alfa Romeo has a relatively industry standard five-year/unlimited kilometre warranty for its models, and the Tonale falls under this, with five years of free roadside assistance thrown in, too.

Being a plug-in hybrid, the battery does have its own specific warranty, that being eight years or 160,000km, whichever comes first.

The first five services are priced at a maximum on Alfa Romeo’s website, listed at a top of $500 for the first (15,000km/12 months), $600 for the second (30,000km or 24 months, as the intervals go), while the third is $500, the fourth a whopping $1000 max, and the final capped price back to $500.

The Volvo EX30 Cross Country is covered by a five-year/unlimited km warranty (with roadside assistance included) and an eight-year/160,000km warranty applies to the battery set-up.

A five-year/150,000km servicing plan applies and is free – and that is well worth noting here. While free/complimentary servicing is not unheard of in the EV space – it's offered with Audi e-tron, Polestar 4 (Long Range AWD), Genesis (GV70), BYD (Sealion 7) and more – the fact Volvo offers it on a variant that may spend at least some time on unsealed roads is commendable.

Servicing appointments are set for every 24 months/30,000km, whichever occurs soonest.

Volvo Group Australia has more than 40 dealerships as well as numerous Volvo-approved workshops across the country.