Mitsubishi Pajero Sport vs Volvo XC40

What's the difference?

The Pajero Sport is reasonable on-road, more than satisfactory as a daily driver and it’s still a very effective 4WD.

This is a proven touring vehicle and while this update treatment doesn’t add a whole lot to the Pajero Sport package – and nothing in terms of power, torque or performance in general – it’s easily enough to tempt those who aren’t patient enough to wait for the next-generation version to arrive here.

The Volvo XC40 Recharge Twin Motor is a cute small electric SUV that offers a decent specs list and a sweet urban driving experience. It’s not the nicest ride on a longer journey but it does have a decent range to be able to tackle one, if needed. I didn’t love the interior design but there’s lots the XC40 gets right.

Most of the Pajero Sport’s latest round of upgrades is focused on styling refreshes, inside and out.

The upgraded interior in the GSR includes quilted two-tone burgundy and black synthetic leather upholstery.

This adds a welcome touch of understated class to an interior which is otherwise looking and feeling old.

The Pajero Sport now also has a three-spoke leather steering wheel and revised digital instrument display graphics, which may be difficult to discern for those unfamiliar with the previous renderings.

Outside, the GSR retains the distinctive Pajero Sport shape, albeit now with updated upper and lower grilles, front and rear bumper enhancements and black headlamp extensions (those are range-wide inclusions), as well as black door mirrors, door handles and tailgate handle.

The XC40 Recharge sees some design changes from its fuel-based counterparts and that’s mainly seen in the front because you get a body-coloured panel instead of a standard grille. The 20-inch alloys feature a chunkier-looking design but the front still boasts the cool ‘Hammer of Thor’ headlights (which I'm rather fond of).

The interior is where the electric powertrain loses me because the fuel-based equivalent is so much nicer inside with its leather-accented upholstery and trims.

It's lovely that there has been a conscious effort to use recycled materials and non-leather upholstery throughout but I'm left with the strange-feeling that synthetic seats don’t reflect the grade or price level of this car. 

Other than the cool-looking topography inserts on the dash and front doors and the 9.0-inch vertical multimedia system, it’s pleasant but a little basic in the cabin. Which is shame because the exterior is cute as hell.

The Pajero Sport cabin is practical, but now, as a result of the upgrade, it has more of a premium look and feel. Sure, it’s still on the wrong side of aged and it’s cramped, but at least it has a layer of gloss to it.

From front to back, it’s a well set-up space. The driver and front passenger seats (both power-adjustable) are very supportive, with a nice wrap-around feel to them. The other seats are also fine.

The reach- and height-adjustable steering wheel has paddle shifters for energetic shifting if you get the urge.

The dash and touchscreen media unit are nicely integrated, but that 8.0-inch screen is too small – and thankfully the likely introduction of a 9.0-inch screen in the 2025 Pajero Sport will sort out that issue.

The cabin’s familiar feel includes the fact that all buttons and dials are easy to locate and operate, even when you're bouncing around off-road.

The second row is comfortable and roomy enough, though the entire cabin tends towards the squeezy end of the spacious spectrum. Having said that, I slotted in behind my driving position and I had plenty of head, knee and foot room. 

There are three top tether points, two ISOFIX anchors and a fold-down armrest with cupholders in the second row. There are USB charge points and a power socket in the back of the centre console bin.

Third-row seating is a bit of a straight-up-and-down affair with a flat seat base, but passengers back there – god bless ’em – have access to cupholders and air vents.

In terms of packability, the Pajero Sport’s cabin, as mentioned, is quite narrow compared to most of its rivals and there are plenty of other SUVs and 4WD wagons around that offer more room inside for people, gear and dogs.

With the third-row seats in use, boot space is listed as 131L. There are power sockets and tie-down points in that rear cargo area. 

With the third row stowed away, there’s a claimed 502L of cargo space, which is pretty handy. With the second and third rows stowed, there’s a claimed 1488L.

Front passengers enjoy the most space and I have plenty of head- and legroom up front. It’s a really easy car to get in and out of and the individual storage is very good for the class. 

Front passengers enjoy a glove box, middle console with a removeable bin, two cupholders, utility tray and skinny drink bottle holders in the storage bins in the doors.

In the rear, passengers get map pockets on the backs of the front seats, two cupholders in the fold-down armrest and small storage bins in each door.

The synthetic leather-trimmed seats look neat and tidy but are very hard in the cushion, which makes them a tad uncomfortable on longer trips. The rear seats are much the same.

Charging options throughout the car are good with the front enjoying a 12-volt port, two USB-C sockets and a wireless charging pad to choose from. The rear also gets two USB-C ports and there's another 12-volt outlet in the boot.

The rest of the technology is easy to use once you spend some time with it. The 9.0-inch touchscreen multimedia system features built-in Google Maps, Assistant and Play Store apps, as well as, YouTube.

The 12.0-inch digital instrument panel isn’t customisable but I like the way it pulls through the satellite navigation screen and directions.  

Because of the dual-motor powertrain, your boot capacity drops to 419L from 452L for the single-motor variant. It is large enough for my grocery shop and random errands and you can fold the floor up to create a deep storage well for additional space. Fold the 60/40 split-folding rear seat and available space expands to 1295 litres.

I don’t like the hardened cargo liner, it feels and looks a little cheap, but I do like the powered tailgate. There’s also handy frunk storage of 31L, which is perfectly sized for any charging cables you will have.

There are two powertrain options in the XC40 family, a mild-hybrid or pure electric. The latter gets two variants and we’re in the top-spec Recharge Twin Motor, which is priced from $85,990, before on-road costs. This positions it in the middle of its nearest rivals but in its family line-up it’s a big $23K jump from its Ultimate B4 AWD combustion equivalent.

The standard features list for the XC40 is robust and there are some great premium features, like the electrically-adjustable and heated front seats with extendable under-thigh support and electric lumbar control.

A panoramic sunroof makes the cabin feel light and airy, the rear outboard seats have heat functions and the driver enjoys a heated steering wheel. You also get a premium 13-speaker Harman Kardon sound system in the Twin Motor.

Other premium features include pre-entry and after-park climate control (perfect for those super-hot days) and a hands-free powered tailgate.

Technology highlights include a complimentary four-year subscription for the built-in Google Assistant, Google Maps and Google Play Store which are accessed via the portrait-style 9.0-inch multimedia touchscreen.

There's also access to apps like YouTube, which delighted my seven-year old and would be handy on any charging stints for some diversion. It's surprising there isn't wireless functionality for Apple CarPlay and Android Auto but they can be hooked up via cable.

The Pajero Sport has a 2.4-litre, four-cylinder, turbo-diesel engine producing 133kW at 3500rpm and 430Nm at 2500rpm – and that’s matched to a eight-speed automatic transmission.

This is a solid but lacklustre combination – it’s agricultural, truck-like and it takes a heavy right foot to punch it off the mark. But overall, I don’t mind the driving experience.

This is a respectable and well-proven combination, more than a bit sluggish and far from dynamic, but it does the job. 

The GSR has Mitsubishi’s 'Super Select II' 4WD (a full-time 4WD system), selectable off-road modes and a rear diff lock.

The Super Select dial is positioned at the rear of the shifter and enables the driver to switch from '2H' (two-wheel drive), '4H' (4WD high-range), '4HLc' (4WD High Range with locked centre diff) and '4LLc' (4WD Low Range with locked centre diff).

The driver is able to safely switch between 2WD (2H) and 4WD (4H, 4HLc) at speeds of up to 100km/h.

The GSR has a button-operated off-road mode system – with 'Gravel', 'Mud/Snow', 'Sand' or 'Rock' settings, each of which tweaks engine output, transmission settings and traction control to best suit the terrain. It also features hill descent control. 

The 2025 Pajero Sport will have the new Triton’s twin-turbo four-cylinder diesel engine (producing 150kW and 470Nm) and it’ll be paired with an eight-speed auto.

The XC40 Recharge Twin Motor features two electric motors which are powered by a large 82kWh lithium-ion battery and produce a combined power output of 300kW and 670Nm of torque.

Which is downright fun because it can do a 0-100km/h sprint in just 4.8-seconds!

The Pajero Sport has an official fuel consumption figure of 8.0L/100km on a combined (urban/extra-urban) cycle.

I recorded 9.8L/100km on this test. I did a lot of high- and low-range 4WDing and the Pajero Sport was never working hard.

The Pajero Sport has a 68L fuel tank, so, going by my on-test fuel-consumption figure, you could reasonably expect a driving range of about 694km from a full tank. 

The official energy consumption figure is 19kWh/100km and I averaged 19.2kWh over a fair mix of urban and open-road driving. The energy consumption isn't bad but some rivals do sit closer to that 16.5kWh mark.

The official driving range is up to 485km for this model but I only ever saw a top range of 410km. That's not terribly surprising given I wasn't shy with the power use but there was a little bit of range anxiety on longer trips.

The XC40 Recharge Twin Motor has a Type 2 CCS charging port which means you can benefit from faster charging speeds. On an 11kW AC charger you can go from 0-100 per cent in eight hours but on a standard three-pin house plug socket expect that wait time to go up significantly.

On a DC fast charger expect to go from 10-80 per cent in as little as 33-minutes.

There have been no power, torque or driver-assist tech changes to this upgraded Pajero Sport – you’ll have to wait for the next-gen version for those – so no surprises lay in wait when driving.

But that’s okay, because the Pajero Sport in its current guise is a solid daily driver – not spectacular, but far from atrocious.

The Pajero Sport is 4840mm long (with a 2800mm wheelbase), 1815mm wide, 1835mm high and has a kerb weight of 2130kg.

Compared to other similarly-sized 4WD wagons, the Pajero Sport is narrower and has a higher centre of gravity, so it’s nimble – the turning circle is a respectable 11.2m – but it also feels a bit floaty on roads and tracks, but not despicably so.

The Pajero Sport is reasonable on sealed surfaces, although it is sluggish, noisy and there’s quite a lot of body-roll through sharp turns, especially compared to some of its more refined rivals, such as the Ford Everest.

But it is a very capable off-roader, mostly because the driver has access to a raft of technical advantages engineered into the Pajero Sport aimed at making 4WDing a safer challenge.

One of the major points of difference it has with its rivals is Super Select II 4WD. You can switch, via a dial to the rear of the auto shifter, from 2H into 4H (four-wheel drive, high-range), if you're not already driving with 4H engaged, and that gives you the best traction possible in low-grip conditions, which you may face on rough back-roads and dirt tracks peppered with loose rocks and potholes.

There's no risk of transmission wind-up because the centre diff is open when 4H is engaged in the Pajero Sport, so Super Select II 4WD adds an extra element of safety and sure-footedness to your driving experience.

Then turn the dial to 4HLc (four-wheel drive, high-range, locked centre diff) and you're ready to take on more difficult terrain but at lower speeds, because the centre diff is no longer open.

If you want to tackle even harder stuff than high-range territory, turn the dial to 4LLc (four-wheel drive, low-range, locked centre diff) and the Pajero Sport has an opportunity to excel in low-speed, low-range four-wheel driving.

Turn the dial to 4HLc and you're ready to take on more difficult terrain but at lower speeds.

So, along with decent high- and low-range gearing and a centre diff-lock – activated when 4HLc (4WD high-range, locked centre diff) or 4LLc (4WD low-range, locked centre diff) is selected – the Pajero Sport has a rear diff lock, which is engaged/disengaged via a button in front of the shifter and this further help you to easily maintain safe forward momentum.

Hill descent control sustains a controlled low speed of 3.0-4.0km/h all the way down steeper, longer hills.

The GSR also has selectable off-road modes, including Gravel, Sand, Mud/Snow (when in high-range 4WD) and Rock (when in low-range 4WD).

Each of these modes adjusts engine output, transmission settings and braking, the aim being the acquisition of superior traction to suit specific conditions and terrains. 

The Pajero Sport is riding on Toyo Open Country A32 all-terrains (265/60R18 110H), which are decent tyres, but it would perform even better with more aggressive rubber.

Wheel travel is adequate, ground clearance (218mm) is reasonable, although you still have to mind your driving line through rough terrain and be mindful of this 4WD’s approach (30 degrees), departure (24.2) and ramp-over (23.1) angles. Wading depth is listed as 700mm.

While it’s never been regarded as a tow rig in the same vein as something like the Toyota LandCruiser or the Nissan Patrol, the Pajero Sport offers sensible claimed towing capacities of 750kg (unbraked) and 3100kg (braked).

Payload is listed as 645kg (so about standard for this size 4WD wagon), gross vehicle mass (GVM) is 2775kg and gross combined mass (GCM) is 5565kg.

Like the Polestar 2 there’s no ignition button on the XC40. You shift into drive to ‘turn on’ and after you park, you simply get out to turn it off. It takes a little while to get used to but it’s a cool feature. 

The twin motors deliver a hefty kick and you never worry about not having ‘enough power’. In the city it’s zippy but on the open-road you also feel comfortable getting up to speed or overtaking because the power distribution is so well-balanced because it’s an AWD.

I customised my steering wheel ‘feel’ to firm and it makes the handling crisp and direct. You feel like you’re in total control whenever you have to tackle be it tight streets or small car parks.

The blind-spot visibility is compromised by how wide the B and C-pillars are and I find that I'm relying a lot more on the blind-spot monitoring system to compensate.

The XC40 loses a few points for me in terms of ride comfort. As mentioned, the seats aren't terribly comfortable but the suspension is hard enough that you notice every bump, as well.

Road noise is also quite pronounced and it doesn’t sound refined when you drive at higher speeds, which is a shame. The flip-side, though, is that you don’t notice those things as much on short, urban trips.

The standard regen braking isn’t customisable and you don’t notice it until you switch over to a 'one-pedal' function. I found this function uncomfortable to use as it’s very aggressive and creates a jerky driving experience. 

Because of its 4440mm length and tiny 11m turning circle, you won’t struggle in a car park! The 360-degree view camera system and front and rear parking sensors make it easy to navigate a tight spot.

This is a joy to park. It’s so easy.

The XC40 has a long safety features list but a standout is the Volvo designed 'Side Impact Protection System' (SIPS) that reinforces the car's steel framework at the sides and disperses energy in a side collision.

Other standard features include full LED external lights, daytime running lights, adaptive cruise control, rear cross-traffic alert, blind-spot monitoring, driver attention alert, forward collision warning, lane departure alert, lane keeping aid, intelligent seatbelt reminders, traffic sign recognition, 360-degree camera system, front and rear parking sensors.

The XC40 has a maximum five-star ANCAP safety rating from testing done in 2018. It has seven airbags, including a driver's knee bag and features high individual scoring for adult and child occupant protection at 97 per cent and 84 per cent, respectively. 

The XC40 has AEB with car, pedestrian and cyclist detection and is operational from 4.0-210km/h. It's usual to see that top speed sit closer to 180km/h, so that's very good.

A cool feature for any parents out there is the second key which you can program to limit stereo volume levels and set a maximum speed allowance. It's even coloured bright orange so there are no chances of a sneaky switcheroo!

There are ISOFIX child-seat mounts on the rear outboard seats and three top-tether anchor points for any families out there but two seats will fit best.

The Pajero Sport has a 10-year/200,000km manufacturer’s warranty as long as you get it serviced as per the schedule at an authorised Mitsubishi dealer.

Mitsubishi’s 10-year capped price servicing applies – with prices ranging from $399 to $999 – and servicing is scheduled for every 12 months or 15,000km whichever occurs first. Check with your dealership for up-to-date servicing costs.

All Pajero Sports come with 12-months roadside assistance, but that can be extended to four years if the vehicle is serviced at an authorised Mitsubishi dealer in line with the official service schedule.

The ongoing costs are pretty solid with the XC40 coming with a usual five-year/ unlimited warranty term but the drive battery is covered for eight years/160,000km.

You can pre-purchase a five-year/150,000km servicing program for a flat $3000 or an average of $600 per service, which is a bit expensive for the class. Servicing intervals are great at every two-years or 30,000km, whichever occurs first.

You get complimentary roadside assistance for five-years through Assist Australia and if you meet certain criteria, you can extend that by a further three years, which is handy.