Toyota Fortuner vs Kia Stonic

What's the difference?

The Toyota Fortuner is a family friendly wagon and a very capable 4WD, but it’s looking and feeling decidedly old, especially when cross-shopped against the current highly competitive 4WD wagon market in which vehicles are increasingly stylish, sophisticated and packed with driver-assist tech (that isn't clunky) and standard features (that are extensive).

The Fortuner is practical and easy to live with as a daily driver, and in GXL spec it makes a lot of sense as a functional not flashy off-road tourer, but it’s far from the best family 4WD wagon around.

Until a next-generation Fortuner possibly arrives, there are plenty of Toyota fans who’d happily settle for a current Fortuner – if they haven’t already.

Unlike a lot of rivals in this segment, the Stonic's actually quite a bit of fun to drive, and that alone earns it a tick from me.

Yes, it can feel underpowered in places, especially when you're trying to do high-speed overtakes or if you're on a really engaging road and on and off the accelerator. But just cruising around, the little powertrain gives you plenty to get around the city.

And I guess that is the point. This does feel like a very city-friendly vehicle, even if it is undeniably showing its age in places.

Note: CarsGuide attended this event as a guest of the manufacturer with meals provided.

Note: The author, Andrew Chesterton, is a co-owner of Smart As Media, a content agency and media distribution service with a number automotive brands among its clients. When producing content for CarsGuide, he does so in accordance with the CarsGuide Editorial Guidelines and Code of Ethics (https://www.carsguide.com.au/ethics), and the views and opinions expressed in this article are solely those of the author.

The GXL is 4795mm long with a 2745mm wheelbase. It is 1855mm wide, 1835mm high and has a listed kerb weight of 2185kg. It has a 11.6m turning circle.

Not a lot has changed in terms of the Fortuner’s looks over the years and while it stubbornly retains that pleasingly non-offensive exterior of most modern SUVs, it does manage to not be totally bland.

The GXL is a body-on-frame 4WD based the HiLux, so it’s no sports car in appearance whether you gaze at it from the front, side, rear or from a bird’s eye view, but it doesn’t look like a block of rotten wood, so unless you’re looks-obsessed, then you should be okay driving this around.

The Fortuner interior is looking dated and the standard dark grey fabric cloth seats, though well-suited to coping with day-to-day messes and spills, don’t do the cabin any favours either, and – you know what? – I don’t mind any of it. Note our test vehicle on this occasion had black leather-accented seats as part of its GXL Option Pack, but I've spent time in cloth-seat Fortuners.

I'm not gonna spend too much time on the exterior design, because from most angles it largely looks a lot like a Kia Stonic, right? The big exterior change occurred up front, where the old Kia 'face' was retired, and replaced with an LED-trimmed front-end more in keeping with modern Kia models.

It is a tale of good and bad in the cabin of the Stonic. The good is the fact that it all feels very familiar and very Kia, which isn't a bad thing.

Th bad is some of the door materials aren't just cheap and hard plastic, but they feel a bit flimsy in places as well. Same with the centre console plastics. There are some elements where you could definitely lift up the ambience in the interior.

The Fortuner’s cabin has a comfortably familiar feel to it and, thankfully, this interior is all about function not fashion.

It’s a practical space, with standard cloth seats (as mentioned our test vehicle has the Option Pack leather-accented seats, but I’ve spent enough drive time in Fortuners with cloth seats to know how those cope with the mess and dirt of everyday life), carpet floors with rubber mats, and durable plastic surfaces everywhere.

Up front, there’s an 8.0-inch multimedia screen (too small, not clear and bright enough) and that system has USB-connected Apple CarPlay and Android Auto (no wireless anything), and a 4.2-inch colour driver’s display, which is too small, too basic and part of an outdated mix of analogue and not-new-enough digital instrumentation.

There are the usual storage spaces – including a glovebox, a centre console, a tray for your smartphone, pop-out cup-holders on the outboard edges of the dash – and a USB port and a 12V socket for charging purposes.

The Fortuner’s three rows are in a 2-3-2 seat configuration. The 60/40 split-fold second-row seat has a one-touch, tumble feature. The 50/50 third-row seats are able to be stowed away, sort of. When folded to each side they protrude into the load space, reducing the size of what would otherwise be a more useable cargo area.

It’s reasonably comfortable in the second row; I sat behind my driving position and I had adequate head and knee room.

The second row has cup holders in the fold-down armrest, ceiling-mounted controls for the aircon, and two ISOFIX and three top-tether anchor points.

All three rows get aircon – with ceiling-mounted vents – and there are a few storage spaces in the third row, but no cup-holders. 

In terms of comfort, it’s ordinary back here; the seats are flat and unsupportive – and, for anyone other than children, the space is tight. 

Boot space is listed as 200 litres with the third-row seats in use, and in that area there are cargo hooks and a 12V socket.

Stow away the third-row and cargo space increases to 716 litres. But the seats still jut into the cargo area, greatly reducing your actual useable load space, and they also obscure a lot of driver vision to the rear.

With the second and third rows out of the way you have a listed 1080L of cargo area.

In the GT-Line trim, you get the twin screen setup, which looks sharp, and I do like Kia's multi-function control bar, which takes care of things like navigation and media on the one digital screen.

It really is feeling a little bit old school in places. There's no wireless phone mirroring, for example, so you need to plug in. And even then you need to plug in with a USB-A rather than a USB-C, despite having both plugs at your disposal.

The other thing is that the GT-Line is almost $36k before on-road costs. And there are places where it just doesn't feel like that much money.

It's a case of what you see is what you get in the back seat of the Stonic. And what you see is... not that much.

There are two USB-C ports in the more expensive trims. There are bottle holders in each of the doors, but no cup holders, and no pull-down seat divider. It is a fairly sparse back seat experience.

What you do get, however, is the luxury of space. Sitting behind my own 175cm driving position, I had absolutely no problem with knee room and no problem with head room. In fact, even as an almost full-size adult, I reckon I could sit back there pretty comfortably, even on longer road trips.

The big news is the addition of a 48-volt mild hybrid system, and that 48-volt battery is under the boot floor. But because it's hidden under a flat partition, it actually doesn't impact boot space.

Kia is still claiming 352 litres with the rear seats in place and 1155 litres with the rear seats folded flat. You do, however, miss out on some under-boot storage. And there's no spare wheel to speak of, just a tyre repair kit.

You can have your Stonic in three flavours, the S, Sport and GT-Line, with retail pricing stepping from $28,180, to $32,290, to the range-topping $35,740 respectively.

The S is pretty basic in terms of kit, riding on 16-inch alloys, nabbing LED lights and daytime running lights, cloth seats, manual air-con and a six-speaker stereo. Tech comes via an 8.0-inch central screen with wired Apple CarPlay and Android Auto (but make sure you pack a USB-A cable to make it work, which feels very old school), as well as a 4.2-inch driver display and a smart key with push-button start.

The Sport packs in plenty more. Your alloys are now 17 inches, you get LED front fog lights, and your cloth seats now have synthetic leather trim. You also get centre console storage, single-zone climate control, a better feeling steering wheel and shifter, and rain-sensing wipers. You also get a bigger 12.0-inch central screen, extra USB-C ports and access to the Kia Connect app and over-the-air updates.

Finally, the GT-Line rides on a unique 17-inch alloy wheel design, and nabs a sunroof, heated front seats, a heated steering wheel and ambient interior lighting. It gets the full Kia twin-screen treatment, with two 12.3-inch displays handling infotainment and driving data, and you get a wireless charger.

Every Fortuner in the line-up has a 2.8-litre four-cylinder turbo-diesel engine – producing 150kW and 500Nm – and that’s matched to a six-speed automatic transmission.

In terms of performance, the Fortuner is not going to set any hearts a-flutter: it’s sluggish off the mark, it takes a heavy right boot to make it feel like anything other than lacklustre on the move, and the six-speed auto downshifts quite harshly at times, especially when going up or down long, gradual inclines on the highway.

However, the 4WD set-up is effective, with adequate low-range gearing, a quietly efficient (but a tad clunky) off-road traction control system, and a rear diff lock.

All Stonics get the same powertrain. A clever three-cylinder, 1.0-litre turbocharged petrol engine with 48-volt mild hybrid assistance. That means 88kW and 172Nm (up from 74kW). It has a seven-speed dual-clutch transmission.

We don’t have an official zero-to-100km/h time, but I’m estimating in excess of 10 seconds.

The Fortuner has official fuel consumption of 7.6L/100km.

On this test I recorded 9.6L/100km.

Going by my on-test fuel figure, you could reasonably expect a driving range of about 833km from this Fortuner’s full 80-litre tank.

The 48-volt system helps drop both fuel use and C02 emissions, with the Stonic pegged at 5.0L/100kms on the combined cycle and 116g/km for emissions, both of which are lower numbers than the last model.

The Stonic’s 45-litre tank could theoretically deliver a circa-900km driving range.

On-road, the Fortuner offers up a pretty standard driving experience for a ute-based wagon. It’s on the HiLux ladder-frame chassis, and it has a firm ride, bordering on harsh. Having said that, you do get used to it soon enough and the Fortuner's coil-spring suspension set-up takes most of the sting out of surface irregularities, except for the more severe dips and bumps.

The Fortuner’s driving position offers plenty of visibility – although the A-pillars are bulky and the third-row seats block vision to the rear when they’re folded up to the sides of the cabin.

This 4WD wagon is generally quiet, although there’s noticeable wind-rush noise around the wing mirrors and engine noise builds to a diesel shriek when you use a heavy right boot as is regularly required.

Steering – reach- and rake-adjustable – is adequately light and sharp, and the Fortuner, with its 11.6m turning circle, is reasonably nimble in suburban areas.

Acceleration, from a standing-start or for overtaking, is laggy but available power and torque come in handy during general driving, making the Fortuner more agreeable all-round than previous versions.

The six-speed auto is generally right for the job, but it downshifts harshly, especially when going up or down long, gradually sloping highway stretches. That happens enough for it to be on the wrong side of annoying.

Some aspects of the Fortuner’s driver-assist tech is annoying: active cruise control is too abrupt and pre-emptive, consistently miscalculating the space between the Fortuner and the vehicle in front as accurately as most of its rivals. This clunky application of tech to real-world scenarios works against the Fortuner. 

While driving a lightly corrugated and rutted dirt track o the way to our set-piece off-road tests, the Fortuner’s ladder-frame chassis yielded a stiff, firm ride, bashing and bouncing over any and all surface imperfections. Airing down the Yokohama Geolandar ATs (265/65R17) from 38 psi (pounds per square inch) to 26 psi takes some sting out of the ride.

The Fortuner is a very capable 4WD with standard off-road measurements, including ground clearance (216mm), approach angle (29 degrees), departure angle (25 degrees) and rampover angle (23.5 degrees). It has a listed wading depth of 700mm.

The Fortuner’s switchable part-time 4WD system has two-wheel drive (H2), and high- (H4) and low-range (L4) four-wheel drive. There’s ample low-end torque on offer – on tap across a broad rev range – for controlled low-speed 4WDing and the unfussed turbo-diesel engine keeps the Fortuner ticking along, without any hassle. 

Engine braking is good, keeping the Fortuner to a sustained and composed momentum on downhill runs.

The off-road traction control system is an effective set-up, limiting wheel-spin and sending much-needed torque to the tyres with some useable traction, with the aim to keep the vehicle moving along at a safe, controlled pace.

Besides that, the driver always has the option of engaging the rear diff lock for more traction action.

Wheel travel is decent for a wagon like this and if you can get the full suspension flex, and drop any mid-air tyres to the dirt for more traction, chances are you’ll be able to get moving along safely soon enough.

So, the mechanicals are fine – its 4WD set-up is very effective – but the Fortuner doesn’t have a whole lot of ground clearance (a claimed 216mm, standard for a contemporary 4WD wagon) and the side steps are prone to hitting on the edges of steep and deep ruts, but those factors are easily overcome through considered driving and tyres that are better suited to off-roading. 

The standard Yokohama Geolandar AT tyres are somewhat of a flaw in the Fortuner’s off-roading set-up. Sure, they’re technically all-terrains, but I reckon a better bet for you – if you’re planning to drive anything beyond formed trails – is to invest in a set of more aggressive all-terrains with greater sidewall bite. 

If you’re planning to use your Fortuner to tow anything, keep in mind that it has a 750kg unbraked towing capacity and 3100kg braked towing capacity. Remember: to be on the safe side, avoid going loading up to anywhere near those capacity figures.

Payload is 615kg (easily reached when you factor in people, pets, camping gear and more), gross vehicle is (GVM) is 2800kg, and gross combined mass (GCM) is 5900kg.

It is a really interesting drive proposition, this Stonic.

First and foremost, it does feel really well sorted in places. The steering has a nice weight to it. It's nice and direct. The ride is comfortable. It can get a little bit crashy over the harsher bumps, which actually isn't all that common in Kia products – like if you hit a cat's eye at speed, for example, you can definitely feel it in the cabin – but generally it's an engaged and comfortable drive.

Similarly, going around corners, even at speed, there's not a huge amount of body roll. The tires grip up pretty well, and it's really not a bad thing to throw around corners.

Where it gets interesting, though, is in its power delivery. At city speeds, so 50 or 60km/h, it's nice and easy and quiet. If you're gentle with the accelerator, and patient, it accrues speed in quite a calm, considered manner, without feeling overly sluggish.

Where it does start to fall apart a little bit, which is when you're at speed, say on a freeway for example, and you pull out to overtake and really plant your foot, and find there's really not a lot there. It can mean overtaking takes a lot longer than you might think. 

If you're on a really challenging road and you're kind of on the gas, on the brakes, on the gas and on the brakes, it can feel a little bit wheezy and uncertain, too, which is no doubt a byproduct of that relatively tiny powertrain.

We're definitely not talking rocket ship acceleration, and nor is it all that quiet in the cabin when you really start to wring its neck, which you will do occasionally.

But I think I've really stepped away from what this vehicle is supposed to be and what it's supposed to do. If you are easy with the accelerator, it can be a really calm, quiet cabin experience. And if you do find yourself on a twisting road, it actually sits and grips better than you might be thinking as well.

But there is no doubt the Stonic shines brightest in the city.

There’s no immediate plan to crash test the new Stonic, meaning its five-star rating has now expired.

All models get things like lane keeping assist with lane follow assist, and blind spot collision avoidance and front and rear parking sensors. The S also gets auto emergency braking (AEB) with car, pedestrian and cyclist avoidance, but the Sport and GT-Line both add junction turning to the system.

A five-year/unlimited kilometre warranty covers the Fortuner, which is par for the course these days.

If you stick to the relatively short servicing schedule – six months or 10,000km with at authorised dealerships – Toyota says it will cover the engine and driveline for up to seven years. All warranty elements are subject to terms and conditions, so make sure you’re fully aware of those.

Capped-price servicing applies and, for our test vehicle, it was $290 per appointment for the first five, then $377.38, $813.93, $572.55, $478.93 and $377.38.

The Stonic is covered by Kia’s seven-year unlimited-kilometre warranty, with capped-price servicing covering the warranty term.

Servicing is required every 12 months or 10,000kms, and all seven services will set you back $3780 combined.