Ford Transit Custom vs Kia Ev4

What's the difference?

The Ford Transit Custom Trail has plenty of appeal as a work van or a camper fit-out candidate. It’s a well-packaged, comfortable and contemporary van that’s nice to drive and as a bonus, with all-wheel drive it’s given the scope of capability to be able to tackle mild off-roading situations with confidence.

It’s built for work and play and though it’s limited to two-up for travels, the Trail offers so much potential as a camper conversion for adventure seekers its few niggles are easily forgotten when you’re busy making memories.

An electric sedan is really shrinking the buyer pool, which is why Kia has such gentle expectations for the EV4 in Australia. But it's a lovely driving EV with plenty of perks, and the design alone will brighten up Australia's roadways. For my money, I'd either be going for the cheapest one that's sharp value with plenty of kit, or the flagship GT-Line that gets the big battery and the works in terms of equipment. The Earth for me sits in no-man's land.

Note: CarsGuide attended this event as a guest of the manufacturer, with travel, accommodation and meals provided.

Note: The author, Andrew Chesterton, is a co-owner of Smart As Media, a content agency and media distribution service with a number of automotive brands among its clients. When producing content for CarsGuide, he does so in accordance with the CarsGuide Editorial Guidelines and Code of Ethics, and the views and opinions expressed in this article are solely those of the author.

It looks like a van but with some striking yet low-key flourishes that all kind of work as a whole. Those include a Trail grille and the matt black alloy wheels. The yellow sticker-pack is a neat touch.

The Trail has more presence than a regular Trend with its 30mm-taller raised suspension and overall adventure-ready look with strong front end and chunky wheel arches.

The striking but low-key theme continues inside with a neatly laid-out yet spartan cabin. The two synthetic leather seats are topped with Trail embossing and lined with yellow stitching.

The cabin is separated from the rear cargo area by a bulkhead, which incorporates a small wired window.

The slippery-looking unit that adorns this page is the EV4 sedan. There’s also a hatch, but it comes out of Europe, while this one comes out of Korea, and that would likely make the hatch far more expensive than this bad boy. It's under study, apparently, but yet to be confirmed.

Anyway, to steal a hackneyed football analogy, for mine this is a game of two halves. I actually really like the front end. It looks sleek and slippery and there’s a real presence from the swollen arches.

I am, however, a little less sold on this rear end, which looks sharp and blocky and almost like it has been bolted on. Also annoying is the fact that it looks like it should be a liftback, with the boot hinged up above the rear windscreen. But nope, it's hinged below it, so you still get a dinky little opening to squeeze your stuff through.

Kia's international designers are pushing the boat out at the moment, and they deserve credit for making things different. Whether it sinks or swims with the general public, though, will be the real test.

Inside, it's all pretty traditional Kia, with all three models sharing the twin 12.3-inch digital displays, along with the little climate panel in the middle. Kudos to Kia for keeping some physical buttons, too. I'm less sold on the use of some cheap, hard plastics, even in the top-spec cars.

It’s a van so there are two distinct sections to the Trail, the cabin and the load space.

Firstly, the cabin. More a work-friendly than family-friendly interior, this Trail is a two-seater with plenty of durable plastic everywhere – ready for work and life – as well as charging (with USB-A and -C ports) and storage (including a van-favourite dash-top slot for logbooks etc, outboard moulded cupholders and a nifty pop-out cupholder), all amenities enough to cope with most daily van-related duties.

The seats are comfortable, supportive and have a fold-down lock-in-place armrest.

Now for the load space. There are no seats back there and as such it has plenty of potential as a work van or touring vehicle.

Access to the rear load space is via a barn door at the back and this Trail has a sliding door on both sides.

The cargo area is substantial – 3002mm long (to the bulkhead; 3450mm long if load-through hatch is used), 1392mm wide (between wheel arches) and 1425mm high (floor to roof). Easily big enough for work equipment or recreational gear. It can cope with four Euro pallets (each measuring 1200mm x 800mm) and it has a listed maximum load volume (with the bulkhead) of 6.8 cubic metres.

Load height through the rear barn doors is 531-585mm, depending on how much weight is already onboard.

The load space has the aforementioned metal bulkhead (with window and load-through hatch), load area protection kit (full height walls and moulded floor), LED lights and eight tie-down loops.

Otherwise, this is a load area ripe for customisation. Maybe a plethora of shelves for a tradie, or some bedding and extra storage for an adventurous person or couple.

At 4730mm long, 1860mm wide and 1480mm tall, the EV4 sits between the Model 3 and the Seal in terms of its outright dimensions. Kia says the EV4's wheelbase and interior packaging has been designed to maximise backseat space, which I must admit, there is plenty of.

Sitting behind my own 175cm driving position, I had miles and miles of leg room, and enough head room, though there is some kind of optical illusion that occurs in the backseat of the EV4 – even though you definitely have enough space, the dark materials of the GT-Line still leaving me feeling a little claustrophobic somehow.

Something else not to be sneezed at is the inclusion of the household-style power plug in the back. My laptop died while I was taking notes on my test, and I plugged it straight in and powered it up. Super handy.

At the back, there is 490 litres of boot space, which is about middle ground. The Seal is more like 400 litres, but the Model 3 offers more.

Sadly the EV4 is yet another EV that does not have a spare wheel of any kind. Instead you have to make do with a tyre repair kit.

In modern Kia EV style, the EV4 arrives in three trim levels — the Air, Earth and GT-Line — and then in Standard Range or Long Range battery sizes.

The range opens with the Air, which is a pretty sharp-feeling $49,990 before all of your on-road costs. Kia says drive-away pricing is coming, but how much it will be is still to be figured out.

That money buys you the Standard Range battery, which we will come back to in a moment, along with 17-inch alloys, flush-finishing door handles, LED lighting, rain-sensing wipers and heated wing mirrors.

Inside, there are two-tone cloth seats, an artificial-leather steering wheel and dual-zone climate with rear vents, while tech is handled by Kia’s loveable dual 12.3-inch screens (one for your entertainment, and another for your diving info), with a smaller 5.0-inch screen between them that handles climate settings. There’s wireless Apple CarPlay and Android Auto, a six-speaker stereo and four USB-C connections, too.

All EV4 model grades get two vehicle-to-load (V2L) connections (so you can plug things in with a normal household plug), with one in the backseat and the other as part of the exterior charger – though the latter is an accessory on the Air. All also get access to the Kia Connect app and over-the-air updates, too.

Stepping up to the Earth ups the spend to $59,190, which is a gigantic financial leap, but you’re mostly paying for the bigger battery and longer driving range, as well as 19-inch alloys, cloth-and-synthetic-leather seats, a powered seat for the driver, and Kia’s very cool and comfortable mesh headrests.

Finally, the GT-Line tops the range, and is yours for $64,690. It gets a more polished look, courtesy of the exterior plastics being swapped out for gloss-black detailing, and it rides on its own 19-inch alloy design. It also gets a sunroof, a powered boot, dynamic welcome lights and projection headlights.

Inside, there’s a heated steering wheel, full synthetic-leather seats, relaxation seats to get comfy when charging, and ambient interior lighting. You also get ventilated front seats, a better eight-speaker Harman Kardon stereo and wireless device charging.

That is a big, broad pricing spectrum, and something tells me Kia has worked very, very hard to get that entry-level model below $50k, where it can compete with the likes of the BYD Seal ($46,990) and Tesla Model 3 ($54,900).

The Ford Transit Custom Trail has a 2.0-litre four-cylinder turbo-diesel engine producing 125kW at 3500rpm and 390Nm at 1750-2500rpm.

The Trail has a clever eight-speed automatic transmission and an on-demand all-wheel drive system.

It all works rather well, but it’s a van afterall and as such it is less dynamic and more dependably driveable than perhaps a cross-shopped SUV wagon. However, as an AWD van the Trail can be trusted to keep its grip on wet bitumen, soggy grass and loosely-gravelled tracks and that’s a strong part of its appeal over a 2WD van.

All EV4 models are front-wheel drive, with a single front-mounted motor producing 150kW and 283Nm, fed through a single-speed gearbox. That’s enough, Kia says, to knock off the sprint to 100km/h in around 7.5 seconds. The Air is the fastest, at 7.4s, while the heavier Earth and GT-Line claim 7.8s. Top speed is a claimed 170km/h.

The Ford Transit Custom Trail has an official combined cycle (urban/extra-urban) fuel consumption figure of 8.5L/100km. On this test I recorded 8.8L/100km.

The Trail has a 70-litre fuel tank so going by my on-test fuel figure you could reasonably expect a driving range of about 795km from a full tank of diesel. However, as with any vehicle, once you’ve loaded the Trail with real-world burdens (e.g kids, dogs, camping gear, etc) you’ll soon see that fuel consumption increase.

Let’s talk about range for a moment, because it's bloody impressive. Not quite the best out there, but the furthest any electric Kia has ever travelled between charges.

There are two battery options, a 58.3kWh NCM battery in the Standard Range, and a 81.4kWh unit in Long Range models. The Standard will deliver 456kms in driving range, but the Long Range ups that to 612kms, both on the WLTP cycle. 

The EV4’s 400-volt architecture does slow down charging a little, though, with DC fast charging capped at 128kW. That means going from 10 to 80 per cent in around 30 mins when using the fastest chargers. If you’re using a 50kW charger, it’s up to almost an hour and 20 minutes for the bigger battery, which is a long coffee stop.

Plugged in at home, provided you have an 11kW wallbox, it’ll take just under five and a half hours, or just over seven hours, to go from 10 per cent to fully charged, so an overnight charge no matter the battery size.

It’s easy to get in and out of the Trail’s driver seat with a wide-opening door and a big step to help you inside.

The seats are comfortable and it’s simple enough to dial-in your driving position via the tilt-and-reach adjustable steering wheel and manually-adjustable seat.

Word of warning: the auto transmission is operated via a stalk mounted on the right-hand side of the steering wheel column, which takes some getting used to.

Once underway, the Trail is punchy enough around town and in the suburbs with its 2.0L 'EcoBlue' turbo-diesel engine offering a more-than-adequate amount of power and torque (125kW and 390Nm) and its clever auto helping out with nifty moves through traffic (for a van, anyway).

Visibility is impressive from the cabin and you’re afforded a convenient vantage point with the Trail standing a bit taller than its regular Transit Custom stablemates as it’s on lifted suspension, but feeling composed on most surfaces.

The Trail has a listed kerb weight of 2046kg and a turning circle of 12.1m, pretty standard for a long wheelbase van, so this is not an insubstantial vehicle and it’s a bit tricky to 'flip a u-ee' if the situation demands it.

It has six drive modes – 'Normal', 'Eco', 'Slippery', 'Tow/Haul', 'Sport', 'Trail' – which each adjust engine torque, throttle response and traction control, among other things, to suit the road surface and conditions.

But we’re all here to see how it goes off-road, aren’t we?

Well, obviously this is no rock-crawling machine and it’s not intended to be. It’s best thought of as having an all-wheel drive system that gives this van mild off-road capabilities, as in it can tackle wet bitumen, soggy grass, lightly corrugated bush tracks and very shallow mud puddles with more confidence than the Transit Custom Trend it's based on.

In a nutshell, the AWD Trail will be able to handle most low-level traction-compromised scenarios. But it does not have enough ground clearance, wheel articulation, grip or underbody protection to tackle any terrain beyond modest off-roading.

Speaking of grip, the Trail as standard rides on Bridgestone Duravis R660 (215/65 R16) rubber, a van/light truck commercial tyre and they are not so well suited to dirt tracks and the like. Grippier all-terrain tyres would help this van perform slightly better off-road than on its showroom rubber.

In its favour, the Trail has a front skid plate and underbody protection in case it cops some knock from the ground during its adventures.

Not in its favour, however, especially as a potential touring vehicle, is the fact it has a space-saver spare wheel and tyre.

If you’re thinking of using your Trail as a tourer, it’s worth knowing payload is listed as 1179kg, maximum braked trailer towing capacity is 2500kg, Gross Vehicle Mass (GVM) is 3225kg and GCM is 5725kg.

I learned something new and exciting (well, to me, at least. You might be very bored) from Kia's ride and handling guru on this launch. And that is that the tuning frequency for common city road imperfections, like bridge expanders, is actually the same as for the bigger, bouncier undulations you get on country roads. And so you can tune to prioritise one or the other, not both.

In real terms, it means a car that feels custom-built for the city, gliding over urban roads with mega comfort (which is exactly what the EV4 does), feels slightly less at home out of town, where there is more obvious movement in the cabin.

Bored yet? Ok, the point is that, while never uncomfortable, the EV4 feels right at home in the city, which is where it's expected to spend most of its time, but weirdly firmer on longer adventures. 

This really is easy, city EV motoring, done well. There's no alienating floatiness to the ride, no lifeless lightness to the steering, it's comfortable, quiet and – despite no headline-grabbing power figures – more than potent enough to get you up and moving.

There's nice weight to the steering, and though the front tyres gave up their grip a couple of times when pushed with some steering lock on, there isn't much in the way of aggressive body roll, and it all feels pretty confidence inspiring. 

The power is most effective from around 10km/h to 80km/h, before the urgency starts to fall away – it's slower to respond at freeway speeds – but that too just leans into its city credentials.

There's really not much to complain about here. It feels well sorted, and quite fun to drive. There is nothing that really stands out as spectacular about the drive experience, but nor is there anything to complain about. It's just really solid motoring, which isn't always guaranteed these days.

There’s no ANCAP rating on the EV4 yet, but the brand says it's confident it will adopt the five-star scores issued in Europe. All models get seven airbags, like active cruise control, AEB autonomous emergency braking (meaning it will anchor up if it senses an accident), front and rear parking sensors, an active blind spot monitor that will take evasive action if it senses a collision, and lots, lots more.

Only the GT-Line switches up the standard safety kit offered on the other two grades, adding a surround-view monitor, a camera that shows what’s happening in your blind spot, powered child locks and a reverse parking aid that will brake for you if it thinks you're going to hit something.

Ford’s five-year/unlimited kilometre warranty applies to the Trail.

Servicing is set down for every 12 months or 30,000km and capped-price servicing is offered. Four scheduled services will set you back $2000 (including a brake fluid change at year three) which isn't over the top for a vehicle of this type.

Ford Australia has about 195 independent Ford dealers in Australia, with many located in metropolitan or suburban areas.

Kia ownership proposition is simple, and pretty strong. You get a seven-year warranty no matter how far you travel, an eight-year warranty for the high-voltage systems, again no matter how far you travel, and capped-price servicing. Pre-paying your service costs will set you back $688 for three years, just over $1300 for five years, or just under $2000 for seven years.