Ford Transit Custom vs Alfa Romeo Tonale

What's the difference?

The Ford Transit Custom Trail has plenty of appeal as a work van or a camper fit-out candidate. It’s a well-packaged, comfortable and contemporary van that’s nice to drive and as a bonus, with all-wheel drive it’s given the scope of capability to be able to tackle mild off-roading situations with confidence.

It’s built for work and play and though it’s limited to two-up for travels, the Trail offers so much potential as a camper conversion for adventure seekers its few niggles are easily forgotten when you’re busy making memories.

If you’re an ‘Alfa Romeo person’, or even just an ‘Italian car person’, you’ve got this on your short list and there’s little I can say that will change your mind. 

And you wouldn’t be making a bad decision if you did pick up a Tonale.

But if $80,000 sounds like a lot for a small SUV and you still want something that looks stylish and feels special, the mild-hybrid Tonale Veloce should do, if the likes of the X1, Q3, or XC40 don’t scratch that left-of-centre itch.

And a fun small SUV? A Mini Countryman JCW, Audi SQ2 or VW T-Roc R are all different sizes, but all more powerful than the Alfa and all fall below the $70,000 mark.

But, if you’re keen on that plug-in hybrid drivetrain and have a day-to-day lifestyle that’ll allow you to make the most of its electric range (and most major city-dwelling Australians do to some extent), then the outlay might just be worth it to be able to check out the Tonale in your garage or driveway every day.

It looks like a van but with some striking yet low-key flourishes that all kind of work as a whole. Those include a Trail grille and the matt black alloy wheels. The yellow sticker-pack is a neat touch.

The Trail has more presence than a regular Trend with its 30mm-taller raised suspension and overall adventure-ready look with strong front end and chunky wheel arches.

The striking but low-key theme continues inside with a neatly laid-out yet spartan cabin. The two synthetic leather seats are topped with Trail embossing and lined with yellow stitching.

The cabin is separated from the rear cargo area by a bulkhead, which incorporates a small wired window.

If Alfa any traditionalists are hesitant to embrace the Tonale’s hybrid drivetrain, surely the Tonale’s styling has the opposite effect.

Small SUVs can fall victim to trying to look too much like a hatchback, or being plastered with lots of little trim details to break up large areas. The Tonale, on the other hand, looks like an SUV regardless of size, and its styling elements are decidedly restrained.

Most notably, at the front, Alfa Romeo has employed the ‘scudetto’ shield-shaped grille and horizontal lower grilles to form the ‘trefoil’, a face as familiar as BMW’s kidney grille or the Porsche 911’s round headlights.

The aforementioned ‘3+3’ headlights are sleek, and somewhat mirrored by similarly styled tail-lights that flank a light bar across the middle of the boot. Badging is minimal, the ‘Tonale’ on the rear in a cursive ‘Alfa’ typeface and the small ‘Veloce’ lettering found only on the front three-quarter panels.

The 20-inch wheels are so Alfa Romeo in their ‘teledial’ circular design, though all three wheel options for the Tonale fit into this theme. In a car park or on the driveway, they’re certainly eye-catching to those not expecting them - a friend said upon sight of this test car, "Look at the wheels. They’re silly! I love them!".

Inside, the cabin space isn’t too ‘busy’ with visual elements, though some of those that are there - the row of buttons for climate control or the multimedia screen, for example - are possibly a little too simple. The buttons could be from any old car, and the screen looks like a ‘tacked on’ rectangle.

Just about everything else looks suitably restrained but relatively elegant for a small SUV, though, with elements like the steering wheel remaining rather simple and (in modern terms) timeless. The paddles behind it are a bit of visual theatre, too.

Like the exterior, the interior adopts some circular cues like the air vents, door speakers, DNA drive mode dial, and even the cowl over the driver display. 

The second row is a little more spartan, with little in the way of visual ‘wow’ and a disappointingly basic vent (albeit adjustable in two different directions) and USB ports mounted in hard grey plastic.

For the most part, the interior looks quality, and with relatively minimal hard or scratchy plastic, feels it too.

It’s a van so there are two distinct sections to the Trail, the cabin and the load space.

Firstly, the cabin. More a work-friendly than family-friendly interior, this Trail is a two-seater with plenty of durable plastic everywhere – ready for work and life – as well as charging (with USB-A and -C ports) and storage (including a van-favourite dash-top slot for logbooks etc, outboard moulded cupholders and a nifty pop-out cupholder), all amenities enough to cope with most daily van-related duties.

The seats are comfortable, supportive and have a fold-down lock-in-place armrest.

Now for the load space. There are no seats back there and as such it has plenty of potential as a work van or touring vehicle.

Access to the rear load space is via a barn door at the back and this Trail has a sliding door on both sides.

The cargo area is substantial – 3002mm long (to the bulkhead; 3450mm long if load-through hatch is used), 1392mm wide (between wheel arches) and 1425mm high (floor to roof). Easily big enough for work equipment or recreational gear. It can cope with four Euro pallets (each measuring 1200mm x 800mm) and it has a listed maximum load volume (with the bulkhead) of 6.8 cubic metres.

Load height through the rear barn doors is 531-585mm, depending on how much weight is already onboard.

The load space has the aforementioned metal bulkhead (with window and load-through hatch), load area protection kit (full height walls and moulded floor), LED lights and eight tie-down loops.

Otherwise, this is a load area ripe for customisation. Maybe a plethora of shelves for a tradie, or some bedding and extra storage for an adventurous person or couple.

Inside, the Tonale feels relatively spacious for a small SUV, with possibly more places to put things than you might expect from a traditionally enthusiast-focused brand. 

In both front and rear seats, no part of the body or console impedes on passenger space - though the door armrests feel like they're a little far to comfortably rest an elbow on - and nothing gets in the way when reaching controls or the centre console.

Ergonomically, everything falls well to hand and no far reaches are really required, though the cupholders in the centre are a little narrow for some relatively normal-sized cups or bottles, and have rubber grips inside that require a little extra pull to retrieve items from.

Other options for bottles include the door pockets, or for a small bottle even the centre console bin is quite deep (albeit narrow).

Smartphones, even fairly tall ones, will rest securely in the angled - a nice touch - wireless charging bay, though while having the phone in a position it won’t slide out from is a plus, angling a phone screen to be visible to the driver might be too tempting for some. It is, mercifully, a little obscured by the gear shifter.

On controls, the steering-wheel design hasn’t changed for more than half a decade which, honestly, is so, so fine. Really, Alfa’s steering wheel has few buttons including the engine start, a relatively timeless (read: simple) visual style, and a thin rim with moulded thumb rests that encourage 9-and-3 hand positions.

The buttons on the wheel are easy, clear, and feel nice, and controlling the driver display is relatively easy as there aren’t really sub-menus to get lost in.

The main multimedia screen is also relatively well laid out, marking a nice step up from previous Uconnect systems (Jeep and Fiat owners will also know), though the connectivity with wireless phone mirroring, Android Auto in my case, was a little laggy and dropped out occasionally, seemingly in the same spot on the same Melbourne CBD street during my commute each morning.

The downsides are relatively few on the practicality front, but there is another: the boot space in the hybrid suffers due to the battery space needed, so 500 litres for the non-plug-in Tonale variants is down to 385 litres for the PHEV.

That’s still less than an electric Volvo XC40 Recharge (claimed to be 418L), though fortunately it grows to a spacious 1430 with the seats folded down, and is accessible via an automatic electrically opening boot door.

Another important point, while we’re in the boot, is the lack of spare tyre. Instead, a repair kit is provided - something those who enjoy a road trip might lament.

Whether the Alfa Romeo Tonale plug-in hybrid is expensive depends on how you frame it. For a small SUV, it’s fairly pricey, but for a premium PHEV, it’s on the more budget-friendly end of the scale.

At $78,500 before on-road costs for a Tonale Veloce PHEV, the plug-in is nearly $20,000 more expensive than the Veloce ‘mild-hybrid’ (MHEV) at $58,900. The test car (pictured) for this review also has two cost options, the Alfa Red paint being $1990 and the 20-inch grey alloy wheels for $1500.

So, $81,990 is a lot for a small SUV, but it’s still about the same price as a Peugeot 508 PHEV and less than a top-spec Mazda CX-60 PHEV.

Alfa Romeo says the difference in price between the Veloce MHEV and PHEV isn’t as broad as it seems just due to the drivetrain, as the PHEV scores a ‘Lusso pack’ as standard rather than being a $4500 option for the MHEV.

That pack is where a few of the goodies in this Tonale come from, such as the black leather seats adorned with Alfa-badged headrests - eight-way electrically adjustable with heating and cooling in the front - plus a heated steering wheel and a 14-speaker Harmon Kardon sound system.

A couple more features are exclusive to the Veloce PHEV, however, like the sunroof and the chrome finish on its dual-exit exhaust tips.

Standard across the range, however, is the 10.25-inch touchscreen for the multimedia system, running Stellantis’ Uconnect 5 operating system with an Alfa-specific skin, as well as the 12.3-inch ‘Cannochiale’ TFT driver display, plus wireless phone connectivity with Apple CarPlay and Android Auto, plus a wireless device charger.

Other functional standards are the ‘3+3’ LED Matrix headlights, visually inspired by past models like the rare Alfa Romeo SZ coupe, plus adaptive ‘driving beam’ and dynamic indicators.

The Ford Transit Custom Trail has a 2.0-litre four-cylinder turbo-diesel engine producing 125kW at 3500rpm and 390Nm at 1750-2500rpm.

The Trail has a clever eight-speed automatic transmission and an on-demand all-wheel drive system.

It all works rather well, but it’s a van afterall and as such it is less dynamic and more dependably driveable than perhaps a cross-shopped SUV wagon. However, as an AWD van the Trail can be trusted to keep its grip on wet bitumen, soggy grass and loosely-gravelled tracks and that’s a strong part of its appeal over a 2WD van.

Engaging driving is key to an Alfa Romeo justifying being somewhat on the pricier end of the cost spectrum, so numbers like ‘208kW’ for a total system output in a small SUV are welcome to see on paper.

The Tonale’s 1.3-litre turbocharged petrol four-cylinder engine alone makes 132kW and 270Nm, aided by an electric system outputting 90kW and 250Nm. The 208kW is its total useable peak, with Alfa not stating a peak torque figure, but a 0-100km/h claim comes in at a fairly impressive 6.2 seconds.

That’s helped by the Tonale’s all-wheel-drive nature, the front wheels driven by the engine via a six-speed torque converter automatic, and electricity powering the rears.

The Ford Transit Custom Trail has an official combined cycle (urban/extra-urban) fuel consumption figure of 8.5L/100km. On this test I recorded 8.8L/100km.

The Trail has a 70-litre fuel tank so going by my on-test fuel figure you could reasonably expect a driving range of about 795km from a full tank of diesel. However, as with any vehicle, once you’ve loaded the Trail with real-world burdens (e.g kids, dogs, camping gear, etc) you’ll soon see that fuel consumption increase.

A 42.5-litre petrol tank and a 15.5kWh lithium-ion battery combine to provide an electric driving range of 60.5km that’s backed up by the ability to charge or save power for when it’s needed by letting the internal-combustion engine (ICE) kick in.

And while this has the potential to mean essentially no fuel is used in short-run, day-to-day driving, anything resembling a longer trip means you’re unlikely to reach the kind of efficiency figures Alfa Romeo claims.

The official combined fuel consumption figure for the Tonale PHEV is 1.5L/100km, though achieving this would require stopping and recharging the battery every 100km of driving, and the driving would need to be in perfect conditions for battery range - i.e. relatively low speeds.

The Tonale PHEV is efficient, yes, but it’s not ‘1.5L/100km efficient’ in the real world if you need to take a drive longer than a standard work day with maybe an errand or two.

After 23 kilometres of real-world driving, the indicated battery range dropped from 65km (odd given Alfa’s spec sheet provided claims a 60.5km range) to 30km, an indicated drop of 35km.

A 12 km discrepancy between over just 23km of standard driving isn’t ideal, though the trip included some highway driving - not an electric drivetrain’s best stage.

Alfa Romeo says a household-style 3.0kW charger should fill the battery from empty in 5.5 hours, while a ‘fast’ charger at 7.4kW should take 2.5 hours via the Type 2 charging port.

It’s easy to get in and out of the Trail’s driver seat with a wide-opening door and a big step to help you inside.

The seats are comfortable and it’s simple enough to dial-in your driving position via the tilt-and-reach adjustable steering wheel and manually-adjustable seat.

Word of warning: the auto transmission is operated via a stalk mounted on the right-hand side of the steering wheel column, which takes some getting used to.

Once underway, the Trail is punchy enough around town and in the suburbs with its 2.0L 'EcoBlue' turbo-diesel engine offering a more-than-adequate amount of power and torque (125kW and 390Nm) and its clever auto helping out with nifty moves through traffic (for a van, anyway).

Visibility is impressive from the cabin and you’re afforded a convenient vantage point with the Trail standing a bit taller than its regular Transit Custom stablemates as it’s on lifted suspension, but feeling composed on most surfaces.

The Trail has a listed kerb weight of 2046kg and a turning circle of 12.1m, pretty standard for a long wheelbase van, so this is not an insubstantial vehicle and it’s a bit tricky to 'flip a u-ee' if the situation demands it.

It has six drive modes – 'Normal', 'Eco', 'Slippery', 'Tow/Haul', 'Sport', 'Trail' – which each adjust engine torque, throttle response and traction control, among other things, to suit the road surface and conditions.

But we’re all here to see how it goes off-road, aren’t we?

Well, obviously this is no rock-crawling machine and it’s not intended to be. It’s best thought of as having an all-wheel drive system that gives this van mild off-road capabilities, as in it can tackle wet bitumen, soggy grass, lightly corrugated bush tracks and very shallow mud puddles with more confidence than the Transit Custom Trend it's based on.

In a nutshell, the AWD Trail will be able to handle most low-level traction-compromised scenarios. But it does not have enough ground clearance, wheel articulation, grip or underbody protection to tackle any terrain beyond modest off-roading.

Speaking of grip, the Trail as standard rides on Bridgestone Duravis R660 (215/65 R16) rubber, a van/light truck commercial tyre and they are not so well suited to dirt tracks and the like. Grippier all-terrain tyres would help this van perform slightly better off-road than on its showroom rubber.

In its favour, the Trail has a front skid plate and underbody protection in case it cops some knock from the ground during its adventures.

Not in its favour, however, especially as a potential touring vehicle, is the fact it has a space-saver spare wheel and tyre.

If you’re thinking of using your Trail as a tourer, it’s worth knowing payload is listed as 1179kg, maximum braked trailer towing capacity is 2500kg, Gross Vehicle Mass (GVM) is 3225kg and GCM is 5725kg.

This might be the make-or-break topic for a select few Alfa Romeo customers - is the Tonale fun to drive?

Yes, thankfully.

Where the mild-hybrid was sometimes criticised for being slightly underwhelming for a car wearing the snake-adorned badge from Milan, the extra power, all-wheel-drive grip and electric torque delivery make the Tonale feel spirited enough for a sporty-leaning small SUV.

The DNA dial really does come into play plenty, too. 

D, for dynamic, is pretty much reserved for when you’re actually ‘driving’ the Tonale - its stiffened suspension and relatively greedy power draw isn’t for low-speed commuting or daily efficiency.

N, or natural, is best for most long-ish commuting or trip situations, particularly highway driving where relying fully on the battery range isn’t ideal, as mentioned.

A, for advanced efficiency, is the ‘EV mode’ and best suits anyone whose daily commute takes them between urban or suburban areas which can be done under EV driving, though it can be used up to 206km/h.

If you don’t mind the petrol engine kicking in on occasion, leaving ‘natural’ to its own devices will result in some relatively frugal driving - a week of testing, commuting, filming and enjoying the Tonale used less than a tank of fuel, including one round trip of more than 140km.

Commuting in the Tonale proved comfortable enough - the steering is light and the dual-stage valve suspension in its softer mode combined with the electric drivetrain resulted in a calm and controlled feeling.

Its suspension soaks up bumps well, though a consistently uneven road surface can feel a little jittery (though not harsh or crashy) after a while.

Getting more dynamic (yes, the D on the dial), however, brought out some interesting characteristics of the Tonale. That light steering is paired with a quick rack (a 14.8:1 ratio, or two-and-a-half turns lock to lock), meaning the Tonale is easy to turn in hard, and a 53F/47R weight distribution provides enough balance (paired with a low centre of gravity thanks to the battery) to keep on top of the small SUVs movements.

All four wheels being driven under its ‘dynamic’ hybrid mode means grip and acceleration in cornering is plenty useful, though braking coming into the corners via the Tonale’s ‘brake by wire’ system could be a little more feelsome.

The gearbox is very eager under acceleration, too much so for commuting, but if it doesn’t suit your needs even for spirited driving then the manual mode is there.

It’s worth noting that those huge brushed alloy shift paddles come into play here, though being attached to the column steering rather than the wheel presents a key ‘pro’ and ‘con’ each: the paddles are always in the same place, just not always in relation to your hands.

With five stars from ANCAP, the Tonale is off to a good start on the safety front.

Its six airbags isn’t exactly class-leading, there isn’t one at front centre, for example, but the PHEV does have the full active and passive safety suite available on the Tonale as standard.

A series of features make the Tonale ‘level 2 autonomous’ including a front camera, lane-keep assist and traffic jam assist, the relatively standard adaptive cruise control, plus traffic sign recognition, driver behaviour warning, and, of course, AEB.

Blind-spot monitoring, side parking sensors, and a surround-view parking camera are standard on the Veloce, aside from the Ti.

Ford’s five-year/unlimited kilometre warranty applies to the Trail.

Servicing is set down for every 12 months or 30,000km and capped-price servicing is offered. Four scheduled services will set you back $2000 (including a brake fluid change at year three) which isn't over the top for a vehicle of this type.

Ford Australia has about 195 independent Ford dealers in Australia, with many located in metropolitan or suburban areas.

Alfa Romeo has a relatively industry standard five-year/unlimited kilometre warranty for its models, and the Tonale falls under this, with five years of free roadside assistance thrown in, too.

Being a plug-in hybrid, the battery does have its own specific warranty, that being eight years or 160,000km, whichever comes first.

The first five services are priced at a maximum on Alfa Romeo’s website, listed at a top of $500 for the first (15,000km/12 months), $600 for the second (30,000km or 24 months, as the intervals go), while the third is $500, the fourth a whopping $1000 max, and the final capped price back to $500.