Ford Everest vs Toyota HiLux

What's the difference?

The standard Ford Everest – powered by a 2.0-litre twin-turbo or a V6 – is a nicely refined, comfortable and capable 4WD with plenty of potential as a touring vehicle.

The Tremor treatment doesn’t turn the Everest into a Raptor-esque Everest but it does offer low-key substantial off-road improvements to what was already an impressive 4WD wagon.

This sensible package of upgrades – more ground clearance, off-road-suited suspension, and decent all-terrain tyres – gives this Everest a mild 4WD boost.

The HiLux’s age-defying sales and resale values confirm it’s still one of the top two 4x4 dual cabs on the market. However, its new V-Active technology feels underdone, as it adds weight (we reckon about 40kg) and complexity without gains in performance you can feel or economy you can meaningfully measure. Hopefully, Toyota’s next crack at a 'hybrid' HiLux will be more convincing.

Lift any vehicle a few millimetres and throw decent all-terrain tyres on it and that one-two combination instantly gives the vehicle more track-cred. 

And so it goes for the Everest Tremor.

But there’s more going on here than simply increased height and a swap-out of rubber over standard Everests.

As mentioned, it gets Bilstein dampers, new springs, and tough all-terrain tyres which combine to give the Tremor a solid presence.

The new honeycomb-pattern grille with auxiliary LED lights, quite visible steel bash plate, pronounced heavy-duty side steps and orange Tremor branding add to the package.

And inside it gets those Tremor-specific touches, such as the leather-accented seats embossed with Tremor branding, ebony-coloured interior accents and all-weather floor mats.

The HiLux’s enduring appeal is the ‘unbreakable’ feel when you step aboard. Even though its curvaceous styling is increasingly dated, we can’t fault the build quality as it displays a peerless standard of fit and finish which never wavers.

Our only major gripe (since its launch in 2015) is the cramped rear seating. It’s particularly tight for tall people, giving that I’m 186cm and when sitting in the rear seat with the driver’s seat in my position, my knees are pressed into its backrest and my head rubs on the roof lining.

Shoulder room for three large adults is equally challenging and tolerable only for short trips. We reckon the Ranger’s more accommodating rear stalls are significant in its sales leadership.

The Tremor cabin is a comfortably familiar interior – it’s functional and roomy and so scores well in terms of overall practicality.

Driver and front passenger have easy access to storage options, such as the centre console, cupholders, door pockets and a shelf for your everyday-carry stuff as well as charging points (wireless charger, USB and USB-C sockets).

There’s plenty of space for the driver and all passengers (front, second and third row), and the seats are supportive and comfortable, even in the third row.

While that pew is a straight-up-and-down set-up it still manages not to be a complete punishment for those passengers.

Those in the second row get a fold-down centre armrest, door pockets and map pockets as well as air con vents and controls.

The rear cargo area has standard Everest features – with cargo tie-down points and a 12-volt outlet.

A niggle, and one I’ve found in other new-generation Fords, is the multimedia system. It's a decent size with clear and crisp colours and is easy to operate, but I needed to repeatedly stab a finger onto the screen in order to work my way through menus and sub-menus to figure it all out.

My advice is get your head around all of the multimedia system’s functionality while the vehicle is stationary because, to me, some of the screen workings are counter-intuitive and it’s easier and safer to learn all of that while the vehicle is not moving.

Also, the fact some controls are on-screen and some are off it creates more than a little confusion.

With its 2150kg kerb weight and 3050kg GVM, the SR5 V-Active has a 900kg payload rating. It can also tow up to 3500kg of braked trailer but with its 5850kg GCM (or how much it can legally carry and tow at the same time) that would require a substantial 700kg reduction in payload to only 200kg, which could be used up by a driver and passenger alone. 

Alternatively, you could lower the trailer weight limit by the same 700kg to 2800kg (which is still a sizeable trailer) and retain the SR5’s maximum payload. We reckon most owners would do this anyway, given few (if any) would need to tow 3500kg.

The load tub is 1570mm long, 1645mm wide and 495mm deep with 1105mm between the wheel housings. Therefore, it can’t carry a standard Aussie pallet but will take a Euro-sized one. There are four load-anchorage points and we welcome the new lower/raise assistance for the hefty tailgate.

Cabin storage includes a large-bottle holder and bin in each front door, plus pop-out cupholders on either side of the dash, upper and lower glove boxes (with the upper having access to air-con) and an overhead glasses holder.

The latest centre console layout has a wireless phone-charging pad and vertical phone-storage slot, small-bottle/cupholder, a bin for small items and a box with padded lid that doubles as an elbow rest.

Rear passengers get a bottle-holder and bin in each door, pockets on each front seat backrest and a fold-down centre armrest with two more cupholders.

Only the narrower driver’s side of the 60/40-split rear seat base-cushion can swing up and be stored vertically as the passenger-side is now fixed, given the V-Active’s 48V battery resides beneath it and is ventilated by a louvered air intake in the passenger footwell.

The new electrically-assisted drivetrain is available only in SR/SR5 4x4 dual cabs and the Rogue, paired with the HiLux’s ubiquitous 2.8-litre four-cylinder turbo-diesel and six-speed automatic.

Our SR5 V-Active 48V test vehicle has a list price of $63,260. It’s also equipped with the optional premium interior package, which for an additional $2500 adds black leather-accented seats and door trims, heated front seats and an eight-way power-adjustable driver’s seat. Its eye-catching 'Nebula Blue' premium paint option adds another $675.

Latest MY24 updates feature a redesigned front fascia with black ‘honeycomb’ grille, plus wireless phone charging, two USB-C ports in the centre console for rear seat passengers to use and a tailgate equipped with gas-struts to ease opening/closing effort.

 Otherwise, it’s the same SR5 with which we’ve grown very familiar. Standard equipment includes 18-inch alloys and 265/60R18 tyres with a full-size alloy spare, along with LED lighting, side-steps, sports bar, privacy glass and more, even though Toyota still won’t throw in a tub-liner.

Inside is remote keyless entry/start, dual-zone climate, an air-conditioned cooler box, multiple USB ports/12-volt sockets and a 220-volt outlet, premium-grade steering wheel and shifter-knob, driver’s 4.2-inch colour multi-info display, a 360-degree camera view and more.

 The 8.0-inch touchscreen for the multimedia system, including six-speaker audio, appears to shrink as each year passes, but is easy to use and offers multiple connectivity including Apple CarPlay/Android Auto and digital radio. It also projects imagery for the various camera views.

As mentioned right at the start, the Everest Tremor has a 3.0-litre V6 turbo-diesel engine – producing 184kW at 3250rpm and 600Nm at 1750-2250rpm – and that’s matched to a 10-speed automatic transmission.

It also gets the line-up’s full-time 4WD system. This system has selectable two-wheel drive (2H), four-wheel drive high-range (4H), four-wheel drive low-range (4L) and four-wheel drive automatic (4A = 4Auto) that sends drive to the front and rear axles as needed, and which can be safely used on high-traction surfaces, such as bitumen.

The venerable (1GD-FTV) 2.8 litre four-cylinder turbo-diesel with V-Active produces the same 150kW and 500Nm as the standard engine, driving through a six-speed torque converter automatic.

However, Toyota claims fuel economy gains of up to 9.5 per cent when this drivetrain is combined with the new hybrid technology, which comprises a 48-volt electric motor-generator, 48-volt lithium-ion battery and idle-stop system.

The turbo-diesel engine uses a silent-belt to drive the motor-generator, which charges the battery under the rear seat. This battery, which Toyota claims weighs less than eight kilograms with 4.3Ah capacity, also supplies electricity to the vehicle’s 12-volt system through a DC/DC converter.

This system can send up to 8.4kW of power and 65Nm of torque through the motor-generator to assist the engine. Toyota claims this delivers smoother and quieter yet more responsive performance and reduces engine load under acceleration. It also results in a small reduction in idle speed from 720rpm to 600rpm.

Deceleration and braking energy are also recovered, converted into electricity and stored in the 48V battery for later use.  Toyota claims “hydraulic braking combined with regenerative braking creates a more effective and natural deceleration feel and supports downhill manoeuvring.”

The idle-stop system does not use the starter motor like conventional set-ups. Instead, the electric motor-generator, which is permanently connected to the engine via its belt-drive, delivers this function with greater smoothness and quietness.

Idle-stop duration can also be extended by the driver and, when restarting the engine on inclines, the idle-stop system retains brake pressure until enough drive force is generated to ensure smooth acceleration.

In another first for HiLux, its part-time, dual-range 4x4 system (with switchable rear diff-lock) in V-Active variants is paired with 'Multi-Terrain Select' to enhance off-road ability.

The driver can switch between six traction control settings tailored to suit a variety of terrain including 'Auto', 'Sand' and 'Mud' (high- and low-range), 'Deep Snow' and 'Dirt' (high-range) and Rock (low-range).

The Tremor has the highest listed fuel consumption of the Everest line-up: 9.5L/100km on a combined (urban/extra-urban) cycle.

I recorded an average of 11.2L/100km on this test.

The Tremor has an 80-litre fuel tank so, going by my on-test fuel-consumption figure, you could reasonably expect a driving range of about 714km from a full tank.

Worth noting the Tremor requires AdBlue diesel-exhaust fluid.

We completed a total distance of 580km, which comprised a mix of city and suburban driving with an empty load tub and up to four adults on board, plus some freeway/highway running with a near-maximum payload.

When we stopped to refuel at the end of our test, the dash display was claiming average combined consumption of 9.5L/100km, which was lineball with our own 9.4 figure calculated from fuel bowser and tripmeter readings.

Both are higher than Toyota’s official 7.2L/100km figure but within the usual 2.0-3.0L/100km discrepancy between OEM ratings and real-world figures.

Interestingly, the last time we tested a 4x4 SR5 auto dual cab ute (without V-Active) in 2023, using similar routes and payloads, we achieved 9.6L/100km. So, the V-Active’s drop in consumption was only about 2.0 per cent, compared to Toyota’s claim of up to 9.5 per cent.

So, based on our real-world figure, you could expect a useful driving range of around 870km from its 80-litre tank.

Overall, the Tremor is nice to drive on road. It’s quiet, refined and comfortable and the engine and transmission make a cluey, unstressed pairing.

However, the Tremor’s suspension – engineered to improve the vehicle’s off-road capability – is firm through sections of back-country bitumen and even mildly corrugated bush tracks. 

Also, this Everest’s all-terrain tyres don’t help ride quality or noise levels on sealed surfaces. But that’s no surprise and a very minor trade-off when the Tremor's potential as a touring vehicle is so high.

On the open highway at cruising speed, the Tremor exhibits all of the smooth-driving characteristics the Everest line-up is well known for.

It sits nicely on the road, that wide wheel track (a 30mm increase in width to 1650mm) gives it a solid stance and this V6 ute simply rumbles along.

So, how does it perform in 4WD territory? Well, it’s based on the Everest Sport, which is no off-road loser, so you’d assume the Tremor would do okay.

However, we all know if you assume, it makes an 'ass' out of 'u' and 'me'… but the Tremor has been engineered to outperform the standard Everest in the dirty stuff. Unsurprising spoiler alert, it does, but only marginally.

The Everest Tremor is 4914mm long (without the towbar hitch receiver; 4978mm with), 2015mm wide (mirrors in; 2207mm, mirrors out) and 1904mm high.

It has a 2900mm wheelbase and a listed kerb weight of 2550kg, the latter making it the heaviest Everest in the line-up. 

This is not a diminutive wagon but it has the smallest turning circle (11.65m) in the Everest range and its dimensions don’t hamper it in the bush.

As mentioned earlier, when you add running ground clearance to any off-roader its off-road performance will be improved. The Tremor has more ground clearance (255mm) than its stablemates but, as with any measurements provided by vehicle manufacturers (ground clearance, wading depth, towing capacities, etc), always regard those figures with a healthy degree of scepticism.

Wading depth is listed as 800mm and its off-road angles are in line with market rivals: for your reference, approach, departure and ramp-over angles are listed as 32, 26.8 and 23.9 degrees, respectively.

This wagon’s 3.0-litre turbo-diesel V6 offers plenty of torque across a broad rev range, the 10-speed auto is clever – no flip-flopping between ratios here – and you can use the manual shifter if you get the urge.

Low-range gearing is adequate and the Tremor has an electronic rear diff lock.

The Tremor has a variety of selectable on- and off-road drive modes, including 'Normal', 'Eco', 'Tow/Haul', 'Slippery', 'Mud/Ruts', 'Sand and Rock' and the Tremor-specific 'Rock Crawl' plus a locking rear diff.

These off-road driving modes are no substitute for track-worthy 4WD mechanicals but they help by adjusting engine, throttle, transmission, braking, traction and stability controls to suit the driving conditions. 

Off-road traction control is effective without being spectacular. There’s a bit too much wheelspin for my liking.

Off-road applications are displayed on screen – with driveline/diff lock indicators, steering, pitch and roll angles depicted. Hill descent control held the Tremor to a steady 3.0-4.0km/h as I crawled down a difficult slope.

The power steering, light and sporty in all scenarios, has been tweaked with a heavy-duty tune and it retains a confident feel in difficult conditions.

Heavy-duty off-road engineering has bolstered the suspension set-up with new springs and Bilstein dampers with external reservoirs.

Wheel travel – how far the axle can move up and down vertically wheel-to-wheel relative to the chassis – is slightly better than a standard Everest’s, with this wagon’s tyres stretching a little further than the regular version’s.

Again, as I mentioned earlier, by replacing an off-roader’s standard road-biased rubber with a set of decent all-terrain tyres its off-road capability will be improved. And that’s exactly what Ford has done.

The Tremor's General Grabber all-terrain tyres feature light-truck construction. They are grippy and very effective in dirt, loose gravel, slippery clay and the like.

There are a few niggles, though.

I’ve previously expressed annoyance at the auto transmission shifter – a kind of joystick on a light cycle of steroids and just as touchy. It’s especially finicky on bumpy terrain but it’s another Everest-based characteristic to which I’ve become somewhat accustomed.

The operation of some off-road driver-assist tech can be confusing as it’s divided between the rotary dial (to select drive modes) and the screen (to engage the rear diff lock etc). Not a deal-breaker, but it takes some getting used to.

The brake pedal is spongy – taking some time between initial foot pressure to ‘biting', but then the brakes – discs all around – do clamp into action.

As for packability, there is a listed 259 litres (VDA) of space in the rear-most cargo area (with all three rows of seats in use), 898L (VDA) when the third row is stowed away and 1823L (VDA) when the second and third rows are lowered.

The Everest Tremor has a listed payload of 690kg, and towing capacities of 750kg (unbraked) and 3500kg (braked).

It has a listed GVM (Gross Vehicle Mass) of 3240kg and a GCM (Gross Combined Mass) of 6350kg. Remember: any onboard loads – such as people, pets, camping gear or aftermarket equipment (bullbar, roof rack etc) – must figure in your payload and GVM equations.

If you’re expecting a tangible difference in performance with the V-Active system, you’ll probably be disappointed. Fact is, after almost 600km of testing, on a variety of roads with a variety of loads, we could not detect any noticeable gain in acceleration, braking or smoothness compared to a standard SR5.

That’s not to say the V-Active system is not delivering up to 8.4kW of power and 65Nm of torque, as Toyota claims. It’s just that these gains are modest and delivered so discreetly that they are undetectable in real-world driving.

This was perhaps best demonstrated when we loaded 650kg into the load tub, which when combined with our two-man crew was a total payload of 830kg. That was only 70kg shy of the payload limit.

It made light work of our 13 per cent gradient 2.0km set climb at 60km/h by self-shifting down to fourth gear at 2250rpm, where it tapped maximum torque to easily haul this payload to the summit.

However, in our previous test of a standard SR5, on the same incline with 100kg more payload, the gear selection and engine rpm were the same as the V-Active. The same applied to engine-braking on the way down.

The HiLux achieved a maximum five-star ANCAP rating in 2019, so its six-year validity will expire next year. Even so, there are seven airbags plus AEB with pedestrian and daytime cyclist detection, blind-spot monitoring, rear cross-traffic alert, lane keeping, active cruise control, speed-sign recognition, panoramic view/reversing camera and more.

The rear seat offers ISOFIX child-seat mounts on the two outer seating positions plus top-tether restraints on all three seating positions.

The Tremor is covered by Ford’s five year/unlimited kilometre warranty, which is the standard for this part of the market.

Roadside assistance is complimentary for 12 months after each service, extended for up to seven years as long as the Tremor’s owner has it serviced at an authorised Ford dealership.

Service intervals are scheduled for every 12 months or 15,000km and a capped-price servicing plan applies to the first five years/75,000km with a $2550 cost attached ($510 per service).

For reference a comparable Toyota LandCruiser Prado will set you back $390 per workshop visit, but that car's service interval is more frequent at six months/10,000km.

Toyota covers the HiLux with a five-year/unlimited km warranty which is par for the course in the mainstream market.

Service intervals are relatively short at six months/10,000km whichever occurs first. Capped-price servicing for the first five years/100,000km totals $3889 or an average of $779 per year.