Chevrolet Corvette vs McLaren 540C

What's the difference?

The Chevrolet Corvette Z06 is truly a supercar offering outstanding dynamics for a lot less money being asked by European rivals - just make sure it's not your only car for those times when you're in a hurry.

The 540C is desirable on so many levels. Its dynamic ability, blistering performance, and stunning design make the cost of entry a value-for-money ticket. And the refreshing thing is, choosing a McLaren, with its focus on function and pure engineering, sidesteps the wankery that so often goes with ownership of an 'established' exotic brand. We absolutely love it.

We’re talking about the closest thing to a real-life Hot Wheels car here. See, while Ferraris look elegant to me like expensive jewellery, Lambourghinis like cheese graters and McLaren’s look like slippery alien spacecraft, the Corvette Z06 looks exactly like an American supercar should - an unapologetic, ludicrous beast. And I love that. 

Dialing up the wild is that enormous carbon wing and front splitter with dive planes thanks to the Z07 package. Just a word of warning, though, the front splitter and dive planes stick out not just visually, but in the sense that I walked into them often and my ankles still have the scars.

I can’t recall the last time I drove a car with carbon-fibre wheels either - these are the biggest rims fitted to a Corvette and they’re wrapped in Michelin Pilot Sport Cup 2R ultra performance tyres (275/30ZR20 front and 345/25ZR21 rear) that they look like oil drums on their sides.

The best angle? The rear - straight on. Those headlights. 

Wait, no, it’s from above - so you can see the V8 through the glass hatch.

Or it could be front-on looking like a giant shovel.. 

OK, there are no bad angles.. 

The Corvette Z06 is long at 4734mm end-to-end, broad at 2024mm wide and its height is a both a sitting-on-the-road-low and numerically pleasing 1234mm.

The plainness of the cabin might be a let down to some people after all the exterior wildness. Ferraris and Lambourghis offer extravagant and exotic interiors, but the Corvette’s innards are almost completely void of flare. 

The media screen is small (8.0 inches), switches and controls for windows and air vents are basic, and the huge dividing ‘wall’ between the pilot and passenger might be a bit much for some.

That ‘wall’ is dotted with buttons and while it may look very 'fighter jet cockpit', they’re just climate control switches. Sitting in the passenger seat is a lonely place with no screen visibility nor easy access to controls - I'd actually call this out as a bit of a fail compared to the interiors from Porsche, Audi and Lamborghini with their screen-filled cabins offering co-pilots something to do.

Yes, it feels a bit premium with the Nappa leather and the sports seats, but it could feel more special.

All of this plainness, however, is saved from boredom by the glass window behind the seats allowing you to peer into the engine bay at the V8 like at a reptile enclosure at the zoo.

In 2010 the recent rise (and rise) of McLaren Automotive really began, when its design director, the hugely respected Frank Stephenson, started to send things in a compelling direction.

He says McLarens are 'designed by air' and that intricately sculpted, wind-tunnel-driven approach to supercar beauty is clear in the 540C's shape.

It's aimed at so-called everyday supercars like the Audi R8, and Porsche 911 Turbo, yet it incorporates all the subtle aero tricks that define the brand's dynamic personality.

A serious front spoiler and a mix of large intakes low in the nose create a delicate balance between downforce and corridors for cooling air.

The dihedral design doors swinging up to their fully open position is a camera phone attracting, jaw dropping, traffic-stopper.

Broad strakes down the side, standing proud of the main bodywork, are reminiscent of a formula one car's turbulence reducing barge boards, and giant intake ducts channel air through to the radiators in the cleanest, most efficient way possible.

And the look is suitably spectacular. You could hang the dramatically carved doors in a contemporary art museum.

Barely noticeable flying buttresses extending from the rear of the main roofline make a big contribution to downforce, cooling and stability with a minimal drag penalty.

There's a delicate lip spoiler on the trailing edge of the main deck, and a giant multi-channel diffuser proves air flow under the car is just as carefully managed as that going over it.

But the 540C doesn't lack traditional supercar drama. The dihedral design doors swinging up to their fully open position is a camera phone attracting, jaw dropping, traffic-stopper.

The interior is simple, striking and single-mindedly driver-focused. The chunky wheel is completely unadorned, the digital instruments are crystal clear, and the seats are the perfect combination of support and comfort.

The vertical 7.0-inch 'IRIS' touchscreen is cool to the point of minimalism, managing everything from audio and nav, to media streaming and air-con, with low-key efficiency.

Supercars don’t tend to be built with practicality as a priority but this two-door, two-seat beastie is spacious enough even for me at 185cm tall with plenty of room in the footwell and loads of elbow-, knee-, and headroom. 

Cabin storage is limited to a glove box, door pockets, two cupholders, and a wireless phone charger on the bulkhead behind the seats.

As you can see from the images there’s a boot at the rear which will fit smaller bags and a small boot in the front.

I did the school run in the Corvette a few times (I know, lucky kid) and I can tell you a bass guitar in its case and a school bag, plus my own large handbag make for a cramped cabin. A Kia Carnival the Corvette ain’t, but it’s not trying to be one and compared to its rivals it does well for practicality.

There are some cursory concessions to practicality… like a glovebox, a single cupholder under the dash at the leading edge of the centre console, a small bin between the seats, housing multiple USB outlets, and other storage options here and there.

The latter includes a shelf at the top of the bulkhead behind the seats, marked with a specific label saying (words to the effect of) 'don't put stuff here', but that's more about objects flying forward in a high-G deceleration, which in this car is more likely to be the result of hitting the brakes, rather than a crash.

But the 'big' surprise is the 144-litre boot in the nose, complete with light and 12 volt power outlet. It easily swallowed the CarsGuide medium sized, 68-litre hard shell suitcase.

In terms of getting in and out, make sure you've done you warm-ups because frankly it's an athletic challenge to maintain composure and get the job done either way. Despite best efforts, I hit my head a couple of times, and aside from the pain it's worth pointing out that being a follicularly-challenged person I'm forced to display abrasions in full public view.

At $331,500, we reckon the McLaren 540C is a supercar bargain. For just on $140k less than a Ferrari 488 GTB it delivers equivalent visual drama, and isn't far behind on speed and dynamic ability.

Standard kit runs to climate control air con, an alarm system, cruise control, remote central locking, LED headlights, tail-lights and DRLs, keyless entry and drive, a limited-slip differential, leather steering wheel, power folding mirrors, four-speaker audio, and a multi-function trip computer.

'Our' car featured close to $30,000 worth of options; headline items being the 'Elite - McLaren Orange' paint finish ($3620), a 'Sport Exhaust' system ($8500), and the 'Security Pack' ($10,520) which includes front and rear parking sensors, a reversing camera, alarm upgrade and a vehicle lifter that raises the front of the car an extra 40mm at the push of a column stalk. Very handy.

And the signature orange shade follows through with orange brake calipers peeking out through the standard 'Club Cast' alloy rims, and similarly coloured seatbelts inside.

The 5.5-litre naturally aspirated V8 in the Z06 makes 475kW and 595Nm. That’s a lot more power than the Corvette Stingray’s V8, which produces 369kW. The GT3 racecar version of the Z06 uses a derived version of the 5.5-litre V8, and actually it shares 70 per cent of the engineering components. 

Revving to a high 8600rpm the Z06’s V8 lets out a high-pitched scream when pushed hard, much like a Ferrari because like many Ferraris the Z06 has a flatplane crank V8 - actually it’s one of the largest flatplane V8s to go into a production car.  

Corvettes are now mid-engined cars and the Z06 has an eight-speed dual-clutch transmission that changes gears quicker than I can blink, sending all that mumbo straight to the rear wheels.

Acceleration comes hard, fast and loud with the Z06 able to boot itself from 0-100km/h in 2.9 seconds. That beautifully linear acceleration with no turbos will pull you all the way towards its top speed of 313km/h.

Aside from you and a passenger, the most important thing sitting between the 540C's axles is the 3.8-litre (M838TE) twin-turbo V8.

Developed in collaboration with British high-tech engineering specialist, Ricardo, McLaren's used it in various states of tune across different models, including the P1, and even in this 'entry-level' spec it produces enough power to light up a small town.

In 540C trim, the all-alloy unit delivers 397kW (540 metric horsepower, hence the model designation) at 7500rpm, and 540Nm from 3500-6500rpm. It uses race-derived dry sump lubrication, and a compact flat plane crank design, favoured by Ferrari and others in high-performance engines.

While vibration damping can be an issue with this configuration, it allows a much higher rev ceiling relative to the more common cross plane arrangement, and this engine screams up to 8500rpm, a stratospheric number for a road-going turbo.

The seven-speed 'Seamless-Shift' dual-clutch transmission sends drive exclusively to the rear wheels and comes from Italian gearbox gurus Oerlikon Graziano. It's been progressively refined and upgraded since its first appearance in the MP4-12C in 2011.

As with practicality, fuel efficiency isn’t the Corvette’s priority and after driving it daily for a week in the suburbs, city and a few dashes out to more open country roads the Z06 was using an average of 23.8L/100km, according to the trip computer.

Luckily the fuel tank is pretty big at 70 litres and with an official combined fuel consumption of just under 16L/100km you have a range of 438km… in theory.

McLaren claims 10.7L/100km for the combined (urban/extra urban) fuel economy cycle, emitting 249g/km of CO2 at the same time.

For the record, that's six per cent better than the Ferrari 488 GTB (11.4L/100km – 260g/km), and if you take it easy on a constant freeway cruise, you can lower it even further.

But most of the time, we, ahem, didn't do better than that, averaging 14.5L/100km via the trip computer in just over 300km of city, suburban and freeway running.

What the Corvette Z06 is like to drive really depends where you drive it. Our suburb has a ridiculous number of speed humps, which are like the Corvette Z06’s Kryptonite thanks to its very limited ground clearance and a carbon front splitter that almost skims the road at the best of times.

This made the Z06 one of the slowest fast cars I’ve ever piloted. My son would beg me to drive him to school in it, but the journey would take twice as long as we slowly eased over each hump while holding our breath. A lift system does raise the front of the vehicle but even then, don't breathe out.

The width and poor visibility made inching down narrow streets of parked cars a stressful exercise, too.

The Corvette Z06 is almost too much of a racecar to live with and then you let it free on an open country road and its purpose is clear - it runs like you wouldn’t believe and screams in delight all the way, while clamping itself to the road with sticky tyres, perfectly set up suspension and proper downforce.

Steering feels mainlined though to your nervous system, the pedals under your feel like your actual feet, and it all feels like a dream until you wake up again when you reach the city limits and round abouts, and traffic and yes, speed humps.

The Corvette Z06 clearly is a car that needs to be joined by other cars in your driveway, ones that don’t even notice speed humps.

The best word to describe driving this McLaren is orchestration. The 540C's dynamic elements flow seamlessly together to transform its operator into a conductor guiding a well-honed mechanical orchestra through an energetic concerto.

And slipping (carefully) over the carpeted bulkhead into the driver's seat is like dropping into an ergonomic masterclass. It feels like you're putting the car on, rather than getting into it.

Like all other current McLarens, the 540C is constructed around a one-piece, carbon-fibre tub, which it calls MonoCell II. It's super stiff, and just as importantly, light.

McLaren quotes a dry weight (no fuel, lubricants, or coolant) for the 540C of 1311kg, with the kerb weight a stated 1525kg (including a 75kg passenger). Not featherweight, but with this kind of power sitting a few centimetres behind your head, it's not a lot.

The engine sounds brilliantly guttural, with lots of exhaust roar managing to find a way past the turbos.

A sophisticated launch control system means zero to licence loss is achieved in a flash (0-100km/h – 3.5sec), with jail time lurking if you ever decide to explore the 540C's 320km/h maximum velocity. And in case you're wondering, it'll blast from 0-200km/h, in just 10.5sec.

The engine sounds brilliantly guttural, with lots of exhaust roar managing to find a way past the turbos. Maximum torque is available across a flat plateau from 3500-6500rpm, and mid-range punch is strong. However, the 540C is anything but a one-trick pony, or is that 540 ponies?

The double wishbone suspension, complete with the adaptive 'Active Dynamics Control' system lets you channel all that forward thrust into huge cornering speed.

The switch from Normal, through Sport to Track progressively buttons everything down harder, and an ideal weight distribution (42f/58r) delivers fantastic agility.

Feel from the electro-hydraulic steering is amazing, the fat Pirelli P Zero rubber (225/35 x 19 front / 285/35 x 20 rear), developed specifically for this car, grips like a Mr T handshake, and the standard 'Brake Steer' torque vectoring system, which applies braking force to optimise drive and minimise understeer, is undetectable in the best possible way.

A console switchable 'Powertrain Control System' also offers three settings, and in the upper modes, shifts from the seven speed dual clutch 'box are eye-blink rapid.

The steering wheel paddles come in the form of a genuine rocker, so you're able to change up and down ratios on either side of the wheel, or one-handed.

You'll love catching a glimpse of the heat haze shimmering up off the engine in the rear-view mirror at the lights.

Hammer towards a quick corner and the reassuringly progressive steel rotor brakes bleed off speed with complete authority. Flick down a couple of gears, then turn in and the front end sweeps towards the apex without a hint of drama. Squeeze in the power and the fat rear rubber keeps the car planted, and perfectly neutral mid-corner. Then pin the throttle and the 540C rockets towards the next bend… which can't come quickly enough. Repeat, and enjoy.

But slotting everything into 'Normal' mode transforms this dramatic wedge into a compliant daily driver. Smooth throttle response, surprisingly good vision and excellent ride comfort make the McLaren a pleasure to steer around town.

You'll love catching a glimpse of the heat haze shimmering up off the engine in the rear-view mirror at the lights, and the (optional) nose-lift system makes traversing awkward driveways and speed bumps manageable.

In terms of active safety, the car's dynamic ability is one giant safeguard against a collision, and that's backed up by tech features including ABS and brake assist (no AEB, though), as well as stability and traction controls.

But if a crunching-type incident is unavoidable, the carbon-composite chassis offers exceptional crash protection with dual front airbags in support (no side or curtain airbags).

Not a huge surprise that ANCAP (or Euro NCAP, for that matter) hasn't assessed this particular vehicle.

GMSV covers the Corvette with a three-year/100,000km warranty which is short by current standards where carmakers typically offer a duration of five years/unlimited kilometres.

One of the appealing sides to the Corvette is that it’s made by a down-to-Earth American car company and a longer warranty offering peace of mind would seem more appropriate.

Service intervals are every 12 months or 12,000km, with capped-price servicing sadly unavailable.

McLaren offers a three year/unlimited km warranty on the 540C, and servicing is recommended every 15,000 km or two years, whichever comes first. No capped price servicing program is offered.

That's a lot of kays for a premium exotic like this, and some may not see 15,000km on the odometer… ever.