BMW 320d vs Toyota HiLux

What's the difference?

Despite BMW's wholehearted embrace of the SUV its 3 Series is still a critically important model for the brand in Australia. And this new version certainly has the spec and tech to take the fight up to Merc's C-Class. And if you're in the happy position of making that choice, it's now a whole lot harder. For our money the 330i marks the sweet spot with extra performance, safety tech and standard features for only a fraction more than $3k over the 320d entry-point.

The Toyota HiLux SR5 now feels nicer and more modern inside and out and it no longer lags behind some other utes – even some of the cheaper ones – in terms of comfort, refinement and all-round driveability.

Toyota has in the past been guilty of sometimes doing the bare minimum when it comes to producing a ‘new’ vehicle – especially LandCruisers or HiLuxes – but this time even though this HiLux is definitely not a new model, the exterior revamp and interior refresh have added more than enough to the HiLux package to keep fans and new buyers happy.

This is the best HiLux so far.

At just over 4.7m nose-to-tail the new 3 Series has crept 76mm in overall length but that dimension is still more than 200mm shy of its next-size-up 5 Series sibling.

Changes to the exterior design are more evolutionary than revolutionary. You're never going to mistake this car for anything other than a BMW 3 Series.

But even if the face is familiar, aerodynamic efficiency is outstanding. BMW admits its claimed Cd of 0.23 was achieved with a base model running on 17-inch wheels (not offered here), but even if bigger rims knock a few fractions off that number it's still an amazing result for a conventional four door sedan.

Big contributors are a full width front spoiler, 'air curtains' managing flow around each corner of the nose, almost complete sealing of the largest areas underneath the car, and a functional rear diffuser section.

The signature kidney grille has grown and is delivered as a single piece, with active shutters incorporated to manage cooling air flow through to the engine. Twin adaptive LED headlights (standard on all models) feature a sharp notch on their lower edge, a big clue for new model spotters.

Broad, carefully managed surfaces characterise the bonnet and flanks of the car, with a distinct character line just above door handle height enhancing its confident stance.

The slightly smoked L-shaped LED tail-lights sit proud of the body, and 18-inch alloys are standard on the 320d, stepping up to 19s on the 330i.

The interior has been redesigned with revised controls and new materials, including slick 'aluminium teragon' finish on the console and dash in the M Sport.

As you can see in our interior images, it's been tidied up and simplified considerably, although it will still be instantly recognised by current BMW drivers.

Highlights are a 12.3-inch configurable digital 'Live Cockpit Professional' instrument display (lifted directly from the X5), a new 10.25-inch media touchscreen and a standard (larger) head-up display.

This HiLux is 5320mm long (with a 3085mm wheelbase), 1885mm wide and 1865mm high. No change there.

It does, however, have a new distinctive front end incorporating a revised design, which includes LED headlights, retro-style ‘Toyota’ brand across the front, and honeycomb-style mesh grille.

Initially I wasn’t keen on the HiLux’s revised front end, but it looks a lot better in the metal than it does in photos and it has grown on me.

This ute’s profile remains the same as before, but the rear end has also been given a sly slap and tickle, giving it a squared-off look.

The interior has also undergone a glow-up – there’s a real 250 Series LandCruiser look and feel to this cabin – and it now has a 12.3-inch touchscreen multimedia system rather than the old 8.0-inch unit.

It still has plenty of hard plastic surfaces but, overall, the HiLux interior doesn’t look or feel anywhere near as old as it used to.

While it remains definitely a HiLux, the new look brings this Toyota ute closer to its rivals, such as the Ford Ranger, in terms of contemporary styling.

A longer wheelbase (+41mm) has helped increase overall cabin space and rear room specifically.

There's plenty of storage provided with a large lidded box between the front seats as well as two large size cupholders in a recessed section in front of the gear shift (which can be closed off with a roll-top style cover).

The glove box is large and there are big bins in the doors with separate holders for full-size bottles.

Rear legroom is generous. At 183cm, sitting behind my own driving position, there was plenty of fresh air between knees and seatback, with lots of foot room to boot.

Headroom was more marginal with a straight back leading to a bonce/roof interface. But there are adjustable rear vents, twin cupholders in a fold-down centre armrest, and big bottle holders in the doors. Multiple USB ports (Type A and Type C) and a 12-volt power outlet are provided front and rear.

The boot space offers up a 480-litre luggage capacity with a 40/20/40 split-folding rear seat increasing cargo flexibility. Local towing capacity is yet to be confirmed, but indicative (European) ratings for both models are 750kg for an unbraked trailer and 1600kg braked.

Standard rubber is run-flat so there's no spare of any description.

The HiLux cabin is very familiar – you know where everything is and how to use it and that’s reassuring – but besides some minor changes and the introduction of an electric park brake the most noticeable change is that aforementioned new 12.3-inch unit.

Apple CarPlay is easy to get working via the multimedia system, and the screen is now big enough and clear enough to operate with ease.

Beyond that, there are plenty of durable hard plastic surfaces, numerous storage spaces, a reasonable number of charging points up front – two USB ports as well as a wireless charging pad and two 12V sockets and a 240V socket inside the centre console.

The driver’s seat is power-adjustable and comfortable without ever being at risk of being described as “plush”.

The rear seat is on the wrong side of squeezy across the shoulders and is best suited to accommodating three children, three jockeys or two adults.

People seated back there have access to two USB-C ports, bottle holders in each door and a dual cupholder in the fold-down centre armrest.

In terms of packability for touring, the SR5’s tub is 1550mm long (1100mm between the wheel arches), 1520mm wide and the load space itself is 490mm deep. Load height is 830mm.

There is nothing extra-special going on in the SR5’s tub – no marine-grade carpet, LED strip lighting, or hidden storage compartments – but it does have four tie-down points.

In terms of practicality, the HiLux, while it does have a barebones approach, still holds its own against the likes of the Ford Ranger.

The SR5 sits in the middle of the HiLux line-up. This version – with a six-speed manual gearbox – has pricing starting at $63,990 before on-road costs. Our test vehicle has Toyota’s premium interior pack ($2500) and premium paint ($675).

Standard features include a 12.3-inch touchscreen multimedia system (with wireless Apple CarPlay and Android Auto plus wireless charging), eight-speaker stereo, dual-zone climate control, and 18-inch alloy wheels.

Other features include high-grade LED headlights, a “comfort-oriented” leaf-spring rear suspension tune, larger front brake discs, power-folding, heated exterior mirrors, an integrated tow-bar, as well as LED tail-lights and LED rear fog lights.

Exterior paint choices include 'Glacier White', 'Frosted White', 'Ash Slate', 'Eclipse Black', Feverish Red' and 'Sunglow'. Some – like 'Stunning Silver' on our test vehicle – cost $675.

The HiLux offers reasonable value for money when cross-shopped against the likes of Ford Ranger, especially the XLT (approx. $64,000) or Sport (approx. $72,000) variants.

The 320d is powered by a 2.0-litre four-cylinder twin-turbo-diesel, featuring common-rail direct-injection and variable inlet timing. It produces 140kW at 4000rpm and 400Nm between 1750-2500rpm.

The turbo's multi-stage design incorporates a small, high-pressure, fixed-vane turbocharger as well as a larger, low-pressure, variable-vane turbo to maximise response, performance and efficiency.

A 2.0-litre single turbo-petrol four-cylinder engine sits under the 330i's bonnet incorporating direct-injection, as well as variable valve and cam timing. Peak outputs are 190kW from 5000-6500rpm and 400Nm between 1550-4400rpm.

Mark the date because this is the first time the BMW 3 Series has been offered in Australia without a manual gearbox option. Both launch models send drive to the rear wheels via an eight-speed automatic (with wheel-mounted shift paddles) only.

This SR5 has a 2.8-litre four-cylinder turbo-diesel engine, producing 150kW at 3400rpm and 420Nm at 1400-3400rpm and a six-speed manual gearbox; the six-speed auto SR5 gets 500Nm at 1600-2800rpm and auto HiLuxes also have the 48-volt mild-hybrid technology onboard.

This is a proven engine-and-gearbox combination, with plenty of lowdown torque, and it’s more than a match for the likes of Ranger and D-Max/BT-50 in terms of overall performance.

This SR5 has part-time four-wheel drive and a rear diff-lock.

Despite each car's performance potential claimed fuel economy for the combined (ADR 81/02 - urban, extra-urban) cycle is commendably low.

BMW says the 320d delivers excellent diesel fuel economy, consuming a miserly 4.5L/100km, emitting 119g/km of CO2 in the process, with the 330i's fuel consumption figure coming in at 6.4L/100km and 147g/km.

You'll need minimum 95 RON premium unleaded in the 330i, with both petrol and diesel requiring 59 litres to fill the tank to full capacity.

Official fuel consumption for the manual is listed as 7.1L/100km on a combined cycle. The auto is 7.4L/100km.

Fuel consumption on this test was 9.1L/100km, which is pretty good because I have done a lot of low-range 4WDing.

The SR5 has a 80-litre fuel tank so, going by that fuel figure, you could reasonably expect a driving range of about 879km out of a full tank

First, the performance figures. BMW claims the 320d will accelerate from 0-100km/h in 6.8sec, which is agreeably quick, while the 330i knocks that down to 5.8sec, which is properly fast.

Both engines deliver the same 400Nm of maximum torque at low rpm; 1750-2500rpm for the 320d, and a broader 1550-4400rpm spread for the 330i. Mid-range acceleration is strong and satisfyingly linear in each, the 330i that bit more urgent at the top end.

The eight-speed auto is velvety smooth, with the wheel-mounted shift paddles on hand for rapid 'manual' changes. Engine noise is muted at low revs but nice and rorty under pressure.

A stated aim in the development of this 3 Series was "dynamic engagement", and the standard strut front, multi-link rear suspension has been tuned to reinforce the driving part of the brand's long-standing 'ultimate driving machine' promise.

The standard suspension includes tricky two-stage dampers front and rear, but with all cars at the local launch fitted with the optional active damper system we'll have to wait to report on its quality (or otherwise).

This car's centre-of-gravity is 10mm lower than the model it replaces, which may not sound like much, but in engineering terms, absolutely is. In concert with a perfect 50:50 front-to-rear weight distribution, and wider tracks front and rear, it helps deliver an overall planted feel and predictable cornering balance.

The electro-mechanically assisted steering is accurate and linear with good road feel, which is not always the case in recent Beamers.

The launch fleet was also rolling on 19-inch rims (standard on 330i, optional on 320d) shod with Bridgestone Turanza run-flat rubber (225/40f - 255/35r) and despite that type of tyre's reputation for harsh characteristics and a moderate level of road noise, ride comfort on the typically coarse rural roads we covered in the Victorian high country was impressive.

Braking on both models is by ventilated disc front and rear, and even in spirited cornering maintained their power and efficiency. The M Sport brake package fitted to the 330i dials things up with four-piston alloy calipers (sourced from Brembo) up front.

The standard sports steering wheel is fat and grippy, the sports front seats combine firm location with long-distance comfort and overall noise levels are low. Overall, this is a super-impressive touring car.

As mentioned, there have been no major mechanical upgrades to the HiLux, but it does now have electric power steering (rather than the hydraulic assistance it’s had in the past). Result? There’s a smoother, more precise feeling to the steering, with a nice weight and balance to it, on sealed and unsealed surfaces.

The HiLux, with a listed kerb weight of 2215kg and a turning circle of 12.6m, is not an insubstantial vehicle but, at the same time, it’s not unwieldy either and manages to feel quite nimble on and off the road.

On sealed surfaces it yields a surprisingly high level of ride and comfort. It’s actually quite compliant, controlled and somewhat refined. That’s largely because this SR5 has multi-purpose suspension on board rather than the heavy-duty suspension, which is on lower-spec, work-focussed HiLux variants for load-carrying duties.

This set-up is intended to offer a softer ride on road – and it does – but off-road it's a different story. Even on minor imperfections (small potholes, minor corrugations and the like) on dirt tracks it tends to thump and bump in and out and it doesn't offer such a comfortable all-round ride as you might be hoping.

I didn’t have much weight onboard – vehicle-recovery gear, a first-aid kit, four Maxtrax and an air compressor – and it will, of course, settle down with more of a load but I was expecting the multi-purpose suspension to be better than it was at soaking up a track’s lumps and bumps – it’s not terrible, but it is noticeable.

However, in terms of pure off-road effectiveness, the HiLux is impressive.

It's never been an underperforming 4WD, it’s simply never been as refined or as comfortably capable as others, such as the Ranger, but it is much more comfortably capable now than it used to be.

There is plenty of power and torque in this HiLux and while this six-speed manual version has 80Nm less than the auto version, it uses what it has really well. The 2.8-litre is a tractable engine and works well as part of an effective powertrain that is well suited to low-range 4WDing. There is a heap of torque at low revs, which is great for low-speed, technical off-roading.

Low-speed throttle response is also impressive, offering nice control when you need it.

I have driven auto HiLuxes in the past and the auto is very clever and it may be your better bet, but I like the manual.

Ground clearance is listed as 224mm and while the HiLux doesn’t have any trouble clearing most jagged rock steps or tree roots you’ll likely encounter on a weekend trip, I didn’t have the opportunity to seriously scrutinise the 700mm wading depth because our testing area was pretty dry. Next time.

Off-road angles – 29-degree approach and 26-degree departure (no rampover is listed) – all check out, even though they are a little shallower than the Rugged or the Rogue variants, they are fine for light-to-moderate 4WDing.

The off-road traction control system in this HiLux is well calibrated and if you do need more dirt-grabbing ability, then this ute does have a rear diff lock.

The only real off-roading weaknesses in the HiLux package are the tyres (Dunlop Grandtrek A/T 31, 265/60R18 110H). They’re not well suited for anything more than light to moderate 4WDing. If you’re planning anything rougher than a well-maintained dirt road in dry weather then consider replacing the showroom tyres with a set of decent all-terrain tires, light-truck construction preferably and away you go.

In terms of towing capacity the SR5 is rated to tow 750kg unbraked, and 3500kg braked.

Payload is a listed 900kg, Gross Vehicle Mass is 3090kg and Gross Combined Mass is 6300kg (a 450kg increase).

While nothing mechanical has changed onboard this vehicle, the combination of 4WD set-up, driver-assist tech, rear diff lock, as well as structural modifications (such as thicker steel in the ladder-frame chassis, a stiffer roll-bar, and reinforced side rails) and suspension tweaks (including retuned dampers and re-rated coil springs at the front, and new dampers and softer spring rates on the live-axle rear) all works well together in this current HiLux package.

The HiLux has now drawn closer to the Ranger in terms of comfortable capability, if not matched it.

The Toyota HiLux SR5 has the maximum five-star ANCAP safety rating, as a result of testing in 2025.

As standard, it has eight airbags (now with a front-centre airbag) and an upgraded suite of driver-assist tech including improved auto emergency braking (AEB), lane-keep assist, adaptive cruise control, and blind-spot monitoring.

BMW offers a three year/unlimited km warranty, which is drifting off the pace now with the majority of mainstream brands stepping up to five-year cover, with some at seven.

On the upside, bodywork is covered for 12 years, the paint for three, and 24-hour roadside assistance is complimentary for three years.

Servicing is condition based, so the car tells you when maintenance is required, and BMW offers a range of service packages in 'Basic' and 'Plus' grades up to 10 years/200,000km.

The HiLux has a five-year/unlimited kilometre warranty.

Service intervals are scheduled for every six months or 10,000km and cost $395 per service.

Toyota Australia has about 300 dealerships across the country.

This type of warranty is pretty standard among the HiLux's rivals so the Toyota ute does remain competitive, in terms of these ownership costs.