Toyota Corolla Cross vs Hyundai Kona

What's the difference?

The Corolla Cross is still an incredibly sensible car if you’re needing to buy a car, but you’re not a car person. Everything is intuitive and easy, allowing you to focus on driving.

This update has helped make this car stand out a bit more, but it’s still a bit vanilla. The Hyundai Kona, for example, offers more character. Also the asking price, especially at the top end, is creeping eerily close to RAV4 territory.

It’s easy to see why the Hyundai Kona leads the Aussie small SUV category, with this hybrid version enhancing the car’s abilities in key areas. Sharply priced and well-specified, comfortable and practical with a hugely efficient powertrain as well as refined dynamic performance. It’s a compelling package. 

Toyota has put some effort into jazzing up the Corolla Cross’ exterior design. The pre-update car was arguably one of the more vanilla cars in its segment.

The most noticeable changes are up front. There’s a new grille set-up with hexagonal cutouts, as well as new LED headlights that are connected by a section that illuminates at night. This latter part looks quite tacky and feeds into the current trend of full-width light bars.

Around the side there are new 18-inch alloy wheel designs on this Atmos trim, as well as a revised LED tail-light set-up.

You can still tell this car is clearly a Corolla Cross from the outside thanks to the cladding around the wheel arches, but it no longer looks so boring, especially in top-spec Atmos guise.

Inside the design changes are more minimal. There’s a new centre console set-up that includes a chunkier gear selector, as well as an ambient lighting strip that wraps around the outside.

I prefer this centre console as it looks more substantial than the pre-update car’s, however, the glossy piano black is a big downside. After a week of testing it was already dusty and grimy, plus scratches are inevitable when you wipe it clean.

Beyond this there are no other obvious changes. I wish Toyota would include some differing colours and finishes inside as it’s a bit of a sea of black.

While there are some soft-touch materials on the dashboard and armrests, you don’t need to look far to find harsher, scratchier finishes. I expect better in a car that costs more than $50,000.

The Kona’s exterior mixes smooth curves across its softly rounded nose and swollen haunches with sharp lines and geometric shapes in the lower grille, wheel arches and rear bumper.

And when the current, second-generation version arrived in mid-2023 it swapped out its predecessor’s already slimline LED daytime running lights for an even thinner strip running the width of the car, in similar fashion to the Hyundai Sonata sedan and Staria people mover.

The single line light signature is repeated with the tail-lights, a brake, reversing and indicator cluster confined to the outer rear edges.

Throw in a conspicuous diagonal character line across the doors, and bright metallic accents making a visual connection between the top of the tailgate and the lower edge of the side glass and there’s a lot going on. 

Always a subjective call, but I don’t mind the Kona’s design, although our test car’s ‘Mirage Green’ paint finish leaves me (and my significant other) cold.

Inside, the colour palette is uniformly grey which contributes to a restrained, relatively low-key feel, although light trim for the headliner and pillar covers brightens the mood somewhat.

The dash treatment is cool and contemporary, comprising a wide wrap-around instrument and media screen panel next to a narrow tray on the passenger side.

Fit and finish is impressive and details like perforated centre panels on the leather-faced seats dial up the premium feel.

The front seats in this car are deliciously comfortable. The bolsters hug you nicely and there’s plenty of upper back and leg support.

I’m also a fan of the upholstery finish in this Atmos trim. It’s a combination of leather and fabric which is great because the front seats also offer heating and now ventilation.

The steering wheel is a classic Toyota unit that features synthetic leather wrapping and heating function. There are also plenty of clearly labelled physical buttons that are a treat to use.

Behind this there’s a 12.0-inch digital instrument cluster like plenty of other Toyota models now. It features a familiar set-up that allows you to change a number of widgets and save multiple pages of configurations.

Moving across, the 10.5-inch touchscreen multimedia system is high-resolution and has crisp colours. There’s not a heap to do in the native user interface so there’s no excuse to get lost.

Thankfully there’s wireless Apple CarPlay and Android Auto. Connection was immediate with my iPhone 15 Pro Max when starting up the car and it remained rock solid throughout known interference points.

Under the touchscreen I appreciate that Toyota has retained physical climate control buttons and dials. They’re very easy to understand and use, especially on the move.

In fact, there are a lot of physical buttons around the cabin. This is great because you don’t need to dive into touchscreen menus and sub-menus.

In terms of amenities up front there are two cupholders, a wireless charger, USB-C charger, centre console box with a 12V socket, as well as a glovebox.

Moving to the second row there’s a decent amount of space for a small SUV, though if you want to use the seats more, you’ll likely want to opt for something larger, like a RAV4.

At 182cm tall I have minimal legroom behind my own driving position, though toeroom is excellent. Headroom is fine though it is impeded due to the panoramic glass sunroof, which notably doesn’t open despite the thick crossbar.

You can easily get two adults in the back of the Corolla Cross, though pushing it to three would make things squishy. It doesn’t help that there’s a central hump in the floor.

Amenities include rear air vents, two USB-C ports, bottle holders on the doors, plus a fold-down armrest with cupholders.

Around the back there’s a hands-free power tailgate that’s handy if you’ve got your hands full. In classic Toyota fashion, it opens and closes with plenty of beeps, which may attract attention.

There’s 380L of boot space with the rear seats upright, expanding to 2000L with them folded. This is fine for the segment, but doesn’t stand out. Front-wheel drive trims get a touch more boot space as they don’t have the rear electric motor.

In the boot area there’s a light, some hooks and a load cover. Unfortunately all-wheel-drive trims don’t come with a spare wheel whatsoever. Instead they only get a tyre repair kit.

It’s worth noting two-wheel-drive trims get a space-saver spare wheel. This is important if you frequently do long-distance drives away from tyre repair shops.

Even though the Kona measures a relatively modest 4350mm end-to-end, it offers up copious amounts of interior space. Dr Who would be proud.

Lots of breathing room up front, with the ‘shift-by-wire’ auto transmission shifter’s location on the steering column freeing up extra space in the centre console.

There’s a lidded bin between the seats (the padded top of which doubles as a centre armrest) with an open tray the size of a shoebox in front of it (which includes a pair of swivel-out bottle or cupholders) as well as a wireless phone charging bay ahead of that.

Generous bins in the doors include a recess for large bottles, plus there’s a decent glove box on the passenger side and a handy open tray above it. Plenty of room to keep the bits and pieces of everyday life under control.

Power and connectivity for the driver and passenger runs to two USB-C sockets and a (180W) 12-volt outlet.

Switching to the back is where the Tardis factor steps up a notch, the Kona offering space more in line with a next-size-up medium SUV.

Sitting behind the driver’s seat set to my 183cm position there’s loads of leg and headroom and even enough shoulder room for three adults to get to know one another on shorter journeys. A close to flat floor also helps with foot room in the centre position. Worth noting the rear seat backrests recline slightly for extra comfort options.

No door bins as such but, again, there are recesses for bottles. Netted map pockets on the front seat backs are helpful as is a fold-down centre armrest, which includes a pair of cupholders.

Individual air vents for back-seaters (in the rear of the front centre console) is always a welcome inclusion, and there’s a small oddments tray underneath them. Another pair of USB-C sockets will keep devices charged.

Boot capacity is healthy at a class-competitive 407 litres (VDA), expanding to 1241L with the 60/40 split-folding second row seat folded.

There are storage wells behind the rear wheel tubs, multiple bag hooks and four tie-down anchors to help keep loads secure.

There’s a temporary space-saver spare under the boot floor, which gets a tick over the increasingly common repair kit option and you’ll be able to tow a 1.3-tonne braked trailer (600kg unbraked).

When you’re sitting on top of the sales pyramid, everyone wants a piece of you and it feels like Hyundai has priced and specified the Kona to match the market with some special touches thrown in here and there.

At $39,950, before on-road costs ($44,738, drive-away), the Hybrid Elite’s standard equipment list is generous.

Aside from the safety and performance tech covered further down, big ticket items include leather-appointed seats and steering wheel, heated and power-adjustable front seats (10-way driver / eight-way passenger), 18-inch alloy wheels, LED headlights, tail-lights and DRLs, keyless entry and start, adaptive cruise control and auto rain-sensing wipers.

There’s also dual-zone climate control, digital radio, wireless Android Auto and Apple CarPlay, six-speaker audio, a 12.3-inch multimedia screen and 4.2-inch instrument cluster, rear privacy glass and more. 

A sneaky power tailgate and/or ventilated front seats would be nice at this price-point, but they’re by no means mandatory for the class. 

Similarly priced hybrid rivals like the Haval Jolion Ultra Hybrid ($38,990, drive-away), Honda HR-V e:HEV L ($42,900, drive-away), Subaru Crosstrek Hybrid L ($39,590, before on-road costs) and Toyota Corolla Cross GXL Hybrid ($41,190, before on-road costs) are broadly aligned with the above features list but none of them put the Kona Hybrid Elite in the shade.

Like last year, all Corolla Cross trims now come with a hybrid powertrain. It’s unchanged with this facelift.

There’s a 2.0-litre four-cylinder petrol engine with either one or two electric motors, depending on whether you opt for a front- or all-wheel drive version. Our tester is the latter so it has two electric motors.

Total system output is 146kW with drive sent through an electronic continuously variable transmission (e-CVT). Top speed is 180km/h.

It’s worth pointing out there is no power difference between the front- and all-wheel drive trims. Uniquely, the latter picks up a ‘Snow’ drive mode.

The Kona Hybrid is powered by a naturally aspirated 1.6-litre, four-cylinder petrol engine working in concert with a single electric motor, both driving the front wheels through a six-speed dual-clutch automatic transmission.

The all-alloy engine features dual variable valve timing and direct-injection to produce 77kW at 5700rpm and 144Nm at 4000rpm, the permanent magnet synchronous motor chipping in with 32kW/170Nm for a total combined outputs of 104kW/265Nm.

That power output is in the middle of the small hybrid SUV pack and torque is at the higher end. 

Kerb weight is a fraction over 1.5 tonnes and you can expect 0-100km/h acceleration in the high 10-second range with a top speed around 170km/h.

Toyota claims the Corolla Cross Atmos Hybrid AWD consumes an average of 4.4L/100km on the combined cycle. This is 0.2L/100km higher than front-wheel-drive trims.

During my week of testing I saw an average of 5.0L/100km, according to the trip computer. This is fine, but I’ve experienced better in other hybrid SUVs.

However, during one trip into the office with heavy traffic I achieved an average of 3.7L/100km. Now that’s frugal!

All-wheel-drive trims get a larger 43L fuel tank compared to the 36L unit front-wheel-drive versions have.

Using my as-tested fuel consumption, this car has a theoretical range of 860km.

All Corolla Cross variants require a minimum of 91 RON regular unleaded petrol.

Hyundai’s official fuel consumption figure for the Kona Hybrid Elite, on the combined (urban/extra-urban) cycle is a miserly 3.9L/100km, the 1.6L engine emitting 89g/km of CO2 in the process.

Minimum fuel requirement is 91 RON ‘standard’ unleaded and with a 38-litre tank theoretical range is around 975km.

On test, over several hundred kays taking in city, suburban and freeway running, we saw an average of around 4.4L/100km, which is impressive and a big contributor to the car’s appeal.

Using our real-world test number, the range figure comes in at a still handy 860-plus km.

When you first start up the car it usually defaults to EV mode unless the petrol engine is bone cold. If this is the case it’ll fire it up to get the fluids warmed up.

Once the engine reaches operating temperature it typically switches off again, allowing you to cruise around exclusively on electric power. This never stops being fun and it’s almost a game to try and eke out as much electric juice as possible before the engine fires up again.

This is inevitable however once the battery charge gets low enough, or you press the accelerator that little bit harder. There’s no noticeable switch from electric to petrol that can be felt, but you do hear the petrol engine whirring away under the bonnet.

Despite this hybrid powertrain producing a total system output of 146kW, it doesn’t really feel like it from behind the wheel. Once you push the accelerator, the petrol engine tends to sound strained. It’s not a nice sound as it’s amplified by the fact there’s an e-CVT that doesn’t require gear shifts.

There’s great regenerative braking as standard which helps recuperate kinetic energy from slowing down back into the battery. This is helpful as it acts like engine braking down hills without actually using the brakes.

When you come to a complete stop the transition from the regen brakes to the traditional friction brakes can be a little grabby. You need to be prepared to alter the pressure you’re applying to the brake pedal.

The suspension in this car is a major highlight. It balances comfort and composure perfectly, allowing for an effortless driving experience. It soaks up virtually all road imperfections with ease, including harsher speed bumps.

This flows on to the steering which does err on the firmer side, but feels direct and a touch sporty. Overall this makes the Corolla Cross a fun vehicle to pilot even on the most dull roads.

On the parking front there are front and rear parking sensors, as well as a surround-view camera with great resolution. Even though this car is easy to park, there’s also a semi-autonomous park assist that can be handy if you’re not great at parallel parking.

Out on the open road the petrol engine does stay on more consistently. It’ll quickly flare the revs if you need to accelerate harder which makes me grit my teeth every time because it’s not the most refined sound.

Despite this there were moments when I was travelling at 80km/h and the petrol engine turned off, allowing the car to drive exclusively on EV power. This primarily only happens on flat roads as the moment there’s even a whiff of a hill, the engine kicks back in again.

There’s a fair bit of road noise that enters the cabin at higher speeds, which isn’t uncommon for small SUVs. However, there’s also noticeable wind noise that sounds like it comes from the sunroof or the side mirrors.

The first things that come to mind when it comes to driving the Kona Hybrid are comfort, quietness and lack of stress.

From an ergonomic point of view the dash and cabin layout make life easy. There are physical controls for key functions like heating and ventilation, as well as audio and drive modes. Not a fan of the hard driver’s door armrest, though.

The engine is quiet and the transition between combustion and electric power is seamless. It’s fun to watch the (available) graphic screen in the driver’s display illustrating where drive is coming from at any given moment. Without it you’d be hard-pressed to know.

Acceleration is more than adequate and the powertrain’s bias towards electric propulsion means take-offs are ultra-smooth. 

Suspension is by MacPherson-type struts at the front with a multi-link rear set-up and ride quality is outstanding. Despite the Kona Hybrid’s relatively large 18-inch rims, bumps and ruts don’t cause major disruption and the Kumho Ecsta PS71 tyres (215/55) are exceptionally quiet.

Steering accuracy and road feel are both good and drive mode switches between ‘Normal’, ‘Eco’ and ‘Sport’ are noticeable, the latter dialling up urgency and dynamic response.

That said, we found ourselves in Eco most of the time, without any penalty in terms of throttle response or cruising ability.

Torque vectoring helps keep everything buttoned down if you decide to press on through your favourite set of corners, the front seats remain comfy on longer drives while keeping you securely located and the ‘shift-by-wire’ electronic gearshift is slick.

Physical brakes are ventilated discs at the front with solid rotors at the rear and they operate with reassuring smoothness. An active hydraulic booster controls regenerative braking, adjustable through three levels. Warning: the most aggressive setting makes the car annoyingly ‘shunty’ at slower speeds.  

Driver-assist safety tech makes its presence felt occasionally, but never to a disturbing degree… with one exception.

Despite the ability to program a steering wheel button to short-cut directly to the appropriate screen, the need to cancel an incessant and sometimes inaccurate overspeed warning every time you start the car is a pain.

A tidy 10.6m turning circle helps in slow-speed manoeuvres as do front, side and rear parking distance warnings and a high-quality reversing camera.

The Kona Hybrid is as good or better than anything in the class when it comes to the drive experience.

The Kona scored four from a possible five ANCAP stars in 2023, with particularly strong results in Adult Occupant Protection (80 per cent) and Child Occupant Protection (84 per cent).

It features a full portfolio of crash-avoidance tech, including AEB with forward collision warning as well as cyclist, pedestrian and motorcycle detection, plus car-to-car junction, crossing and head-on detection. Phew!  

On top of that, there’s lane-keeping and lane-following assist, blind-spot monitoring, driver-attention warning, rear cross-traffic alert and collision avoidance, ‘Remote Smart Parking Assist’, ‘Safe Exit Warning’, driver fatigue detection, tyre pressure monitoring and more.

If, despite all that, a crash is unavoidable there are seven airbags fitted, including a front centre bag to minimise head clash injuries between driver and co-pilot in a side collision. 

There’s also multi-collision brake (to reduce the chances of subsequent impacts after an initial crash), auto collision notification and an emergency call (SOS) function.

For baby capsules or child seats there are three top-tether points for child seats across the second row with ISOFIX anchors on the two outer positions.

All in all, a comprehensive safety offer that matches or betters the Kona’s class competitors.

Like all Toyotas, there’s a five-year, unlimited-kilometre vehicle warranty. However, if you service at Toyota dealers you get two additional years of engine coverage, bringing the total to seven years.

The high-voltage battery coverage can also be extended up to 10 years if you service at Toyota dealers.

Roadside assistance is available to purchase from $99 annually.

Logbook servicing is required every 12 months or 15,000km, whichever comes first. The first five services are capped at $255 each, which is incredibly affordable. It’s only beaten by the likes of Honda.

Toyota has one, if not the, most prolific dealer networks in Australia. There are around 260 dealers and they span metro, regional and rural areas.

The Kona is covered by Hyundai’s seven-year/unlimited-km warranty (upgraded from five years mid-last year), which is ahead of the mainstream five-year warranty pack.

Roadside assistance is complimentary for the first year, with the deal extended for another 12 months every time the car is serviced at an authorised Hyundai dealer. 

Speaking of which, scheduled servicing is recommended every 12 months/10,000km, which is a little lower than the (15,000km) norm for the category. After a complimentary check up at six weeks/1500km, the first seven services (in line with Hyundai’s ‘Lifetime Service Plan Pricing’) come in at $3782, for an average of $540 per workshop visit.

That’s on the high side considering an equivalent Toyota Corolla Cross (in line with ‘Toyota Service Advantage’ pricing) will set you back an average of $354 per service over the same period.

Hyundai has a network of 185 dealers covering every Australian capital, state and territory.