GWM UTE vs Volkswagen Transporter

What's the difference?

In a very competitive ute market, the GWM Cannon XSR represents plenty of bang for your buck, but it’s just not as refined as you’d hope. 

It should be better at this price-point, especially when it’ll be unfavourably cross-shopped with lower-spec variants in the Ford Ranger, Isuzu D-Max and Toyota HiLux line-ups.

It’s a nice enough vehicle on-road, and the XSR is an effective 4WD on the dirt without ever being truly exceptional – but that’s fine for those who want to save big bucks and still drive away in a well-equipped twin-locked off-road vehicle.

The Transporter boasts a level of mechanical refinement, engine performance, ride quality, heavy load-carrying ability and general driver comfort that sets a high benchmark in this category. If not for its lack of an ANCAP rating and unacceptably high internal noise levels at highway speeds, it would be hard to fault.

The XSR is 5439mm long (with a 3230mm wheelbase), 1958mm wide, and 1918mm high. It has a listed kerb weight of 1965kg.

It looks like the mongrel child of a HiLux, Ranger and D-Max – in a good way.

The wider-than-standard wheel track, as well as the snorkel, sports bar, substantial bash plates, tyres and even red brake calipers add to this ute’s presence.

Our test vehicle’s 3400mm wheelbase is 400mm longer than the standard model, resulting in a corresponding increase in overall vehicle length to 5304mm and a 300mm increase in turning circle to 13.2 metres.

Its 1904mm width is an easy fit in most loading zones and the standard roof’s 1990mm height means it can access most underground and multi-storey carparks which typically cap vehicle heights under 2.2 metres. It comes standard with a kerbside cargo bay sliding door and single-lift tailgate.

The well-developed front wheel-drive chassis is simple and robust with MacPherson strut front suspension and semi-trailing arm coil-spring rear suspension, the latter equipped with stout rubber cones inside the spring coils to provide a second stage of support under heavy loads. Optional heavy-duty and rough road suspension packages are also available. Brakes are four-wheel discs.

You can always pick a van designed for hard work by the amount of black plastic in body areas prone to high wear and/or scrapes, chips and dents and the Transporter has most of those covered, including the front and rear bumpers, lower rear pillars, hubcaps, door handles and mirrors.

The cabin has a back-to-basics look and feel as highlighted by numerous plastic caps blanking dashboard slots where switches are fitted to higher-equipped models. However, it has most of what you need and none of what you don’t for this working role. Even so, the lack of fold-down inboard armrests and a driver’s left footrest are notable omissions and both would be welcome for long stints behind the wheel.

The XSR’s five-seat interior is a neat and roomy space but, in line with most utes at this price-point, if you scrutinise it in a critical way you soon discover that some parts feel a bit cheap and flimsy, such as some buttons, dials and switches.

Up front there are two USB ports, a wireless charging pad, a 12V plug and a capacious centre console.

A pair of cupholders can be concealed under a sliding cover and the storage bin is on the right side of big.

The driver gets a six-way power-adjustable seat; the front-seat passenger gets four-way power adjustment. Both seats are comfortable without being too plush.

Second-row passengers get a firm but comfortable seat and amenities include a USB port, a 220V plug, and a fold-down centre armrest.

The second-row seat base can be folded up and out of the way to make room for more gear if only two people are travelling.

Build quality is generally okay, part from the aforementioned flimsy-feeling buttons.

The XSR’s business end, the tub, has a durable-looking tub liner, tie-down points and a handy pop-out step hidden in the top of the tailgate.

But it's worth noting this ute’s tailgate can’t be locked.

With its 1865kg tare weight and 3000kg GVM, our test vehicle has a genuine one-tonne-plus payload rating of 1135kg and up to150kg of that can be carried on the roof. It’s also rated to tow up to 2500kg of braked trailer but that would require a sizeable 583kg reduction in payload to avoid exceeding the 4917kg GCM or Gross Combination Mass, which is how much it can legally carry and tow at the same time. Or you could keep the full payload and reduce the towing limit instead, from 2500kg to 1917kg, which may be a more useful compromise depending on work requirements.

The cargo bay, which offers 5.0 cubic metres of load volume, is 2975mm long, 1700mm wide and 1410mm high with 1244mm between the rear wheel housings. That means it can carry two 1165mm-square standard Aussie pallets, or up to three 1200 x 800mm Euro pallets, secured by a choice of eight load-anchorage points. However, the single-lift tailgate could make rear forklift access tricky, depending on forklift design and reach. The sliding door has a generous 1017mm opening for kerbside loading.

Although the load floor is bare and there’s no standard cargo protection for driver and passenger (optional rubber load floor mats and cargo barriers are available), the cargo bay walls and doors are lined to mid-height and the roof is also lined, with two roof lights providing ample illumination.

Cabin storage includes a large-bottle holder and huge storage bin in each front door, with a narrower second-tier storage shelf above which is ideal for holding smaller items like wallets, keys etc.

The dash provides another small-items cubby to the right of the steering wheel and the top dash-pad has small-bottle/cup holders at each end plus a steeply-angled open tray on the driver’s side which is ideal for storing clipboards, paperwork etc.

There’s no overhead sun-glasses holder but the passenger side of the dash offers two tiers of open storage and a large glovebox, plus another small-bottle/cup holder to the left of the gearshift console. An overhead storage shelf would be handy, given that there’s no centre console.

Our test vehicle is the long wheelbase variant with standard roof height, TDI340 turbo-diesel engine and seven-speed dual-clutch automatic transmission for RRP $47,990. This compares to higher-selling mid-sized turbo-diesel rivals like the Ford Transit Custom LWB 340L with six-speed auto ($47,590), Hyundai iLoad with six-speed auto ($42,710) and segment-leading Toyota HiAce LWB with six-speed auto ($45,240).

It's basic and work-focused as you’d expect, from its 16-inch steel wheels and 205/65R 16C tyres with full-size spare to its cloth seats and tough rubber floor covering in the cabin. However, that doesn’t mean you miss out on some useful and welcome creature comforts, like a leather-covered steering wheel with height/reach adjustment and infotainment controls, driver’s seat adjustable lumbar support, halogen daytime running lights (DRL), rain-sensing wipers, heated tailgate window with washer/wiper, multi-function driver’s display, four-speaker infotainment system with 6.5-inch touchscreen and multiple connectivity including Apple CarPlay/Android Auto plus lots of standard safety tech.

There’s also heaps of factory options available to help tailor a Transporter to suit an owner’s specific requirements including different cargo bay door and window configurations (including twin rear barn-doors), front passenger bench seat with under-seat storage, higher-spec infotainment systems and lots more.

The XSR has the Cannon’s 2.0-litre four-cylinder turbo-diesel engine that produces 120kW at 3600rpm and 400Nm from 1500rpm to 2500rpm. 

It has an eight-speed automatic transmission. 

As mentioned, the XSR has part-time 4WD – with 2WD high-range, 4WD high-range and 4WD low-range – rather than the full-time 4WD set-up that’s in standard Cannons.

This engine and transmission combination is the jewel in the Transporter crown with its energetic, flexible and efficient performance. The 2.0 litre, four-cylinder, direct-injection TDI340 turbo-diesel meets Euro 6 emissions using AdBlue and produces 110kW between 3250-3750rpm and 340Nm of torque across a 1500rpm-wide torque band between 1500-3000rpm.

The closely-spaced ratios in the seven-speed dual-clutch automatic are tailored to get the most out of this willing engine, with crisp and virtually seamless shifting. It also offers the choice of manual sequential-shifting, when hauling heavy loads in hilly terrain or simply for those wanting a more ‘sporting’ driving experience, but the seven-speeder usually does its best work when left to its own devices.

The Cannon XSR has a listed fuel consumption of 9.4L/100km on a combined cycle.

Actual fuel consumption on this test, from pump to pump, was 11.2L/100km but, as is the nature of my testing, I did a lot of low-range four-wheel driving.

The Cannon XSR has an 78-litre tank so, going by that fuel figure above, you could reasonably expect a driving range of about 696km from a full tank.

Note: Drop 30km to 50km from any vehicle’s total calculated fuel-range figure for a better idea of that vehicle’s safe touring range – so, following that advice, the above driving range figure (696km) would become 666km after a 30km safe-distance buffer has been subtracted.

Also, remember that numerous other factors affect your fuel consumption and so impact your driving range, including how much extra weight you have onboard (passengers, camping gear, etc), whether your vehicle is fitted with any aftermarket equipment (bullbar, spare-wheel carrier, etc), whether you are towing (a camper-trailer, caravan, or boat, etc), your vehicle's tyre pressures, and the conditions.

We covered 283km (with auto start/stop disabled) which included about one third of that distance with a maximum payload. The dash display was claiming an average combined consumption of 8.1L/100km when we stopped to top-up the 80-litre tank. Our own figure calculated from fuel bowser and tripmeter readings came in even lower at 7.7 and both undercut VW’s official combined figure of 8.3L/100km. Needless to say, that’s outstanding real-world economy, which based on our figures should deliver a huge driving range of 900-1000km from its sizeable 80-litre tank. Possibly even further with auto start/stop enabled.

If you’re not expecting a dynamic, sporty driving experience from the Cannon XSR, then you won’t be disappointed.

I’m enjoying the fact that off-road vehicles from China and India are improving all the time but there are significant trade-offs when opting for a much cheaper version of the ute you actually want.

The XSR is not an insubstantial ute, but that doesn’t excuse its less-than-ideal steering (which feels too loose) or its stiff ride on upgraded suspension which, even though it increases wheel travel (for 4WDing – more about that later), seemingly hasn’t been tuned to suit the XSR’s bigger tyres, wider wheel track and greater bulk than its lower-spec stablemates.

Also, this ute has an unwieldy turning circle of 13.7m, which makes it an interesting vehicle to manoeuvre along busy urban streets or through a bustling car park.

This is a well priced ute if compared to similarly equipped, much more expensive utes, but that doesn’t excuse its touchy throttle and thrashy transmission.

However, its engine, which can feel underdone when challenged, has a relaxed feel about it when open-road cruising and if you aren’t putting too much pressure on it you likely won’t think it’s much of a let-down.

Overall, the XSR does okay on sealed surfaces, without ever getting anywhere near great – it’s simply not as refined or compliant as it could – or should – be.

On the dirt track leading to our 4WD test track, the XSR was very skippy over corrugations and tended to thump through potholes.

This ute does go well off-road though when it comes time for low-range 4WDing but, equipped with front and rear diff locks, that’s to be expected.

Off-road traction control and other systems including hill descent control, are adequate without being as seamlessly smooth as the equivalent systems in more expensive vehicles.

It also has 'Crawl Mode' (allows for no-pedal, low-speed driving) and 'Turn Assist' (which brakes the XSR’s inside rear wheel to reduce the ute’s turning circle on traction-compromised surfaces).

The over-sensitive throttle is far from ideal during low-speed low-range 4WDing when you need absolute control for safe driving, but I did become used to it – or at least I put up with it.

As mentioned earlier, the upgraded suspension has boosted wheel travel, which means you’re more than likely able in the XSR to stretch a tyre to the dirt for better traction and controlled forward progress.

The XSR’s Cooper Discoverer AT3 all-terrain tyres help, especially when the dirt becomes sticky mud that would gum up a lesser tyre, and we had no strife getting up and over one of our more severe set-piece hill climbs on that rubber.

All in all, the XSR is a capable twin-locked 4WD without ever being exceptional – and that’s fine.

The Cannon XSR has towing capacities of 750kg (unbraked) and 3000kg (braked).

Four-coil suspension provides a noticeably supple unladen ride quality, which is impressive for a commercial vehicle with a one-tonne payload rating. It also feels sure-footed and well planted on the road, particular on the many wet roads we encountered during a rain-affected week of testing.

With its upright steering wheel angle and nicely-weighted steering feel, it offers a comfortable almost car-like driving experience. The driver’s seat has height, backrest rake and lumbar adjustment; there’s no rake adjustment for the base cushion but it doesn’t really need it. There are also clear eyelines to all mirrors, a nicely-positioned gearshift and an uncluttered dashboard/instrument layout that’s easy to read and operate.

The 2.0 litre turbo-diesel has energetic response in its peak torque band between 1500-3000rpm, where most city and suburban driving occurs. Snappy, seamless up-shifting occurs between 1500-2000rpm, providing brisk acceleration with excellent fuel economy. At highway speeds, good gearing ensures the engine needs only 1800rpm to maintain 100km/h and 1900rpm at 110km/h.

We only have two criticisms. One is the size and limited wide-angle effect of the left-side mirror, given the huge blind-spot that a solid-walled long wheelbase van like this creates over the driver’s left shoulder. Although the Transporter is (thankfully) equipped with blind-spot monitoring, a larger kerbside mirror with a more convex shape to increase its angle of view would be welcome.

The other is high internal noise levels at highway speeds emanating from the rear wheel housings. On some grades of coarse bitumen it can sound like the roar of a jet engine, which is too loud for sustained periods and could be a deal-breaker if you do a lot of highway work. We have recently tested rival vans without cabin bulkheads which have appreciably lower cargo bay noise levels at similar speeds (most notably a Chinese brand), so it can be done.

There's no ANCAP rating but the Transporter 6.1 adds to an already extensive list of active and passive safety with the following features now standard: front assist with city emergency braking (aka low-speed AEB), crosswind assist, side-assist including blind-spot monitoring/rear cross-traffic alert and multi-collision brake. There’s also driver and passenger front and side curtain airbags plus lots more.

The XSR is covered by a seven year/unlimited km warranty.

The first service is scheduled at the six-month/5000km mark (and costs $260), then every 12 months or 10,000km, with each service costing $360 a pop.

Five years/unlimited km warranty with 12 months complimentary roadside assist. Scheduled servicing every 12 months/15,000km whichever occurs first. Capped-price servicing for first five scheduled services up to five years/75,000km of $3082.