Toyota Corolla Cross vs Toyota HiLux

What's the difference?

The Corolla Cross is still an incredibly sensible car if you’re needing to buy a car, but you’re not a car person. Everything is intuitive and easy, allowing you to focus on driving.

This update has helped make this car stand out a bit more, but it’s still a bit vanilla. The Hyundai Kona, for example, offers more character. Also the asking price, especially at the top end, is creeping eerily close to RAV4 territory.

The Toyota HiLux SR5 now feels nicer and more modern inside and out and it no longer lags behind some other utes – even some of the cheaper ones – in terms of comfort, refinement and all-round driveability.

Toyota has in the past been guilty of sometimes doing the bare minimum when it comes to producing a ‘new’ vehicle – especially LandCruisers or HiLuxes – but this time even though this HiLux is definitely not a new model, the exterior revamp and interior refresh have added more than enough to the HiLux package to keep fans and new buyers happy.

This is the best HiLux so far.

Toyota has put some effort into jazzing up the Corolla Cross’ exterior design. The pre-update car was arguably one of the more vanilla cars in its segment.

The most noticeable changes are up front. There’s a new grille set-up with hexagonal cutouts, as well as new LED headlights that are connected by a section that illuminates at night. This latter part looks quite tacky and feeds into the current trend of full-width light bars.

Around the side there are new 18-inch alloy wheel designs on this Atmos trim, as well as a revised LED tail-light set-up.

You can still tell this car is clearly a Corolla Cross from the outside thanks to the cladding around the wheel arches, but it no longer looks so boring, especially in top-spec Atmos guise.

Inside the design changes are more minimal. There’s a new centre console set-up that includes a chunkier gear selector, as well as an ambient lighting strip that wraps around the outside.

I prefer this centre console as it looks more substantial than the pre-update car’s, however, the glossy piano black is a big downside. After a week of testing it was already dusty and grimy, plus scratches are inevitable when you wipe it clean.

Beyond this there are no other obvious changes. I wish Toyota would include some differing colours and finishes inside as it’s a bit of a sea of black.

While there are some soft-touch materials on the dashboard and armrests, you don’t need to look far to find harsher, scratchier finishes. I expect better in a car that costs more than $50,000.

This HiLux is 5320mm long (with a 3085mm wheelbase), 1885mm wide and 1865mm high. No change there.

It does, however, have a new distinctive front end incorporating a revised design, which includes LED headlights, retro-style ‘Toyota’ brand across the front, and honeycomb-style mesh grille.

Initially I wasn’t keen on the HiLux’s revised front end, but it looks a lot better in the metal than it does in photos and it has grown on me.

This ute’s profile remains the same as before, but the rear end has also been given a sly slap and tickle, giving it a squared-off look.

The interior has also undergone a glow-up – there’s a real 250 Series LandCruiser look and feel to this cabin – and it now has a 12.3-inch touchscreen multimedia system rather than the old 8.0-inch unit.

It still has plenty of hard plastic surfaces but, overall, the HiLux interior doesn’t look or feel anywhere near as old as it used to.

While it remains definitely a HiLux, the new look brings this Toyota ute closer to its rivals, such as the Ford Ranger, in terms of contemporary styling.

The front seats in this car are deliciously comfortable. The bolsters hug you nicely and there’s plenty of upper back and leg support.

I’m also a fan of the upholstery finish in this Atmos trim. It’s a combination of leather and fabric which is great because the front seats also offer heating and now ventilation.

The steering wheel is a classic Toyota unit that features synthetic leather wrapping and heating function. There are also plenty of clearly labelled physical buttons that are a treat to use.

Behind this there’s a 12.0-inch digital instrument cluster like plenty of other Toyota models now. It features a familiar set-up that allows you to change a number of widgets and save multiple pages of configurations.

Moving across, the 10.5-inch touchscreen multimedia system is high-resolution and has crisp colours. There’s not a heap to do in the native user interface so there’s no excuse to get lost.

Thankfully there’s wireless Apple CarPlay and Android Auto. Connection was immediate with my iPhone 15 Pro Max when starting up the car and it remained rock solid throughout known interference points.

Under the touchscreen I appreciate that Toyota has retained physical climate control buttons and dials. They’re very easy to understand and use, especially on the move.

In fact, there are a lot of physical buttons around the cabin. This is great because you don’t need to dive into touchscreen menus and sub-menus.

In terms of amenities up front there are two cupholders, a wireless charger, USB-C charger, centre console box with a 12V socket, as well as a glovebox.

Moving to the second row there’s a decent amount of space for a small SUV, though if you want to use the seats more, you’ll likely want to opt for something larger, like a RAV4.

At 182cm tall I have minimal legroom behind my own driving position, though toeroom is excellent. Headroom is fine though it is impeded due to the panoramic glass sunroof, which notably doesn’t open despite the thick crossbar.

You can easily get two adults in the back of the Corolla Cross, though pushing it to three would make things squishy. It doesn’t help that there’s a central hump in the floor.

Amenities include rear air vents, two USB-C ports, bottle holders on the doors, plus a fold-down armrest with cupholders.

Around the back there’s a hands-free power tailgate that’s handy if you’ve got your hands full. In classic Toyota fashion, it opens and closes with plenty of beeps, which may attract attention.

There’s 380L of boot space with the rear seats upright, expanding to 2000L with them folded. This is fine for the segment, but doesn’t stand out. Front-wheel drive trims get a touch more boot space as they don’t have the rear electric motor.

In the boot area there’s a light, some hooks and a load cover. Unfortunately all-wheel-drive trims don’t come with a spare wheel whatsoever. Instead they only get a tyre repair kit.

It’s worth noting two-wheel-drive trims get a space-saver spare wheel. This is important if you frequently do long-distance drives away from tyre repair shops.

The HiLux cabin is very familiar – you know where everything is and how to use it and that’s reassuring – but besides some minor changes and the introduction of an electric park brake the most noticeable change is that aforementioned new 12.3-inch unit.

Apple CarPlay is easy to get working via the multimedia system, and the screen is now big enough and clear enough to operate with ease.

Beyond that, there are plenty of durable hard plastic surfaces, numerous storage spaces, a reasonable number of charging points up front – two USB ports as well as a wireless charging pad and two 12V sockets and a 240V socket inside the centre console.

The driver’s seat is power-adjustable and comfortable without ever being at risk of being described as “plush”.

The rear seat is on the wrong side of squeezy across the shoulders and is best suited to accommodating three children, three jockeys or two adults.

People seated back there have access to two USB-C ports, bottle holders in each door and a dual cupholder in the fold-down centre armrest.

In terms of packability for touring, the SR5’s tub is 1550mm long (1100mm between the wheel arches), 1520mm wide and the load space itself is 490mm deep. Load height is 830mm.

There is nothing extra-special going on in the SR5’s tub – no marine-grade carpet, LED strip lighting, or hidden storage compartments – but it does have four tie-down points.

In terms of practicality, the HiLux, while it does have a barebones approach, still holds its own against the likes of the Ford Ranger.

The SR5 sits in the middle of the HiLux line-up. This version – with a six-speed manual gearbox – has pricing starting at $63,990 before on-road costs. Our test vehicle has Toyota’s premium interior pack ($2500) and premium paint ($675).

Standard features include a 12.3-inch touchscreen multimedia system (with wireless Apple CarPlay and Android Auto plus wireless charging), eight-speaker stereo, dual-zone climate control, and 18-inch alloy wheels.

Other features include high-grade LED headlights, a “comfort-oriented” leaf-spring rear suspension tune, larger front brake discs, power-folding, heated exterior mirrors, an integrated tow-bar, as well as LED tail-lights and LED rear fog lights.

Exterior paint choices include 'Glacier White', 'Frosted White', 'Ash Slate', 'Eclipse Black', Feverish Red' and 'Sunglow'. Some – like 'Stunning Silver' on our test vehicle – cost $675.

The HiLux offers reasonable value for money when cross-shopped against the likes of Ford Ranger, especially the XLT (approx. $64,000) or Sport (approx. $72,000) variants.

Like last year, all Corolla Cross trims now come with a hybrid powertrain. It’s unchanged with this facelift.

There’s a 2.0-litre four-cylinder petrol engine with either one or two electric motors, depending on whether you opt for a front- or all-wheel drive version. Our tester is the latter so it has two electric motors.

Total system output is 146kW with drive sent through an electronic continuously variable transmission (e-CVT). Top speed is 180km/h.

It’s worth pointing out there is no power difference between the front- and all-wheel drive trims. Uniquely, the latter picks up a ‘Snow’ drive mode.

This SR5 has a 2.8-litre four-cylinder turbo-diesel engine, producing 150kW at 3400rpm and 420Nm at 1400-3400rpm and a six-speed manual gearbox; the six-speed auto SR5 gets 500Nm at 1600-2800rpm and auto HiLuxes also have the 48-volt mild-hybrid technology onboard.

This is a proven engine-and-gearbox combination, with plenty of lowdown torque, and it’s more than a match for the likes of Ranger and D-Max/BT-50 in terms of overall performance.

This SR5 has part-time four-wheel drive and a rear diff-lock.

Toyota claims the Corolla Cross Atmos Hybrid AWD consumes an average of 4.4L/100km on the combined cycle. This is 0.2L/100km higher than front-wheel-drive trims.

During my week of testing I saw an average of 5.0L/100km, according to the trip computer. This is fine, but I’ve experienced better in other hybrid SUVs.

However, during one trip into the office with heavy traffic I achieved an average of 3.7L/100km. Now that’s frugal!

All-wheel-drive trims get a larger 43L fuel tank compared to the 36L unit front-wheel-drive versions have.

Using my as-tested fuel consumption, this car has a theoretical range of 860km.

All Corolla Cross variants require a minimum of 91 RON regular unleaded petrol.

Official fuel consumption for the manual is listed as 7.1L/100km on a combined cycle. The auto is 7.4L/100km.

Fuel consumption on this test was 9.1L/100km, which is pretty good because I have done a lot of low-range 4WDing.

The SR5 has a 80-litre fuel tank so, going by that fuel figure, you could reasonably expect a driving range of about 879km out of a full tank

When you first start up the car it usually defaults to EV mode unless the petrol engine is bone cold. If this is the case it’ll fire it up to get the fluids warmed up.

Once the engine reaches operating temperature it typically switches off again, allowing you to cruise around exclusively on electric power. This never stops being fun and it’s almost a game to try and eke out as much electric juice as possible before the engine fires up again.

This is inevitable however once the battery charge gets low enough, or you press the accelerator that little bit harder. There’s no noticeable switch from electric to petrol that can be felt, but you do hear the petrol engine whirring away under the bonnet.

Despite this hybrid powertrain producing a total system output of 146kW, it doesn’t really feel like it from behind the wheel. Once you push the accelerator, the petrol engine tends to sound strained. It’s not a nice sound as it’s amplified by the fact there’s an e-CVT that doesn’t require gear shifts.

There’s great regenerative braking as standard which helps recuperate kinetic energy from slowing down back into the battery. This is helpful as it acts like engine braking down hills without actually using the brakes.

When you come to a complete stop the transition from the regen brakes to the traditional friction brakes can be a little grabby. You need to be prepared to alter the pressure you’re applying to the brake pedal.

The suspension in this car is a major highlight. It balances comfort and composure perfectly, allowing for an effortless driving experience. It soaks up virtually all road imperfections with ease, including harsher speed bumps.

This flows on to the steering which does err on the firmer side, but feels direct and a touch sporty. Overall this makes the Corolla Cross a fun vehicle to pilot even on the most dull roads.

On the parking front there are front and rear parking sensors, as well as a surround-view camera with great resolution. Even though this car is easy to park, there’s also a semi-autonomous park assist that can be handy if you’re not great at parallel parking.

Out on the open road the petrol engine does stay on more consistently. It’ll quickly flare the revs if you need to accelerate harder which makes me grit my teeth every time because it’s not the most refined sound.

Despite this there were moments when I was travelling at 80km/h and the petrol engine turned off, allowing the car to drive exclusively on EV power. This primarily only happens on flat roads as the moment there’s even a whiff of a hill, the engine kicks back in again.

There’s a fair bit of road noise that enters the cabin at higher speeds, which isn’t uncommon for small SUVs. However, there’s also noticeable wind noise that sounds like it comes from the sunroof or the side mirrors.

As mentioned, there have been no major mechanical upgrades to the HiLux, but it does now have electric power steering (rather than the hydraulic assistance it’s had in the past). Result? There’s a smoother, more precise feeling to the steering, with a nice weight and balance to it, on sealed and unsealed surfaces.

The HiLux, with a listed kerb weight of 2215kg and a turning circle of 12.6m, is not an insubstantial vehicle but, at the same time, it’s not unwieldy either and manages to feel quite nimble on and off the road.

On sealed surfaces it yields a surprisingly high level of ride and comfort. It’s actually quite compliant, controlled and somewhat refined. That’s largely because this SR5 has multi-purpose suspension on board rather than the heavy-duty suspension, which is on lower-spec, work-focussed HiLux variants for load-carrying duties.

This set-up is intended to offer a softer ride on road – and it does – but off-road it's a different story. Even on minor imperfections (small potholes, minor corrugations and the like) on dirt tracks it tends to thump and bump in and out and it doesn't offer such a comfortable all-round ride as you might be hoping.

I didn’t have much weight onboard – vehicle-recovery gear, a first-aid kit, four Maxtrax and an air compressor – and it will, of course, settle down with more of a load but I was expecting the multi-purpose suspension to be better than it was at soaking up a track’s lumps and bumps – it’s not terrible, but it is noticeable.

However, in terms of pure off-road effectiveness, the HiLux is impressive.

It's never been an underperforming 4WD, it’s simply never been as refined or as comfortably capable as others, such as the Ranger, but it is much more comfortably capable now than it used to be.

There is plenty of power and torque in this HiLux and while this six-speed manual version has 80Nm less than the auto version, it uses what it has really well. The 2.8-litre is a tractable engine and works well as part of an effective powertrain that is well suited to low-range 4WDing. There is a heap of torque at low revs, which is great for low-speed, technical off-roading.

Low-speed throttle response is also impressive, offering nice control when you need it.

I have driven auto HiLuxes in the past and the auto is very clever and it may be your better bet, but I like the manual.

Ground clearance is listed as 224mm and while the HiLux doesn’t have any trouble clearing most jagged rock steps or tree roots you’ll likely encounter on a weekend trip, I didn’t have the opportunity to seriously scrutinise the 700mm wading depth because our testing area was pretty dry. Next time.

Off-road angles – 29-degree approach and 26-degree departure (no rampover is listed) – all check out, even though they are a little shallower than the Rugged or the Rogue variants, they are fine for light-to-moderate 4WDing.

The off-road traction control system in this HiLux is well calibrated and if you do need more dirt-grabbing ability, then this ute does have a rear diff lock.

The only real off-roading weaknesses in the HiLux package are the tyres (Dunlop Grandtrek A/T 31, 265/60R18 110H). They’re not well suited for anything more than light to moderate 4WDing. If you’re planning anything rougher than a well-maintained dirt road in dry weather then consider replacing the showroom tyres with a set of decent all-terrain tires, light-truck construction preferably and away you go.

In terms of towing capacity the SR5 is rated to tow 750kg unbraked, and 3500kg braked.

Payload is a listed 900kg, Gross Vehicle Mass is 3090kg and Gross Combined Mass is 6300kg (a 450kg increase).

While nothing mechanical has changed onboard this vehicle, the combination of 4WD set-up, driver-assist tech, rear diff lock, as well as structural modifications (such as thicker steel in the ladder-frame chassis, a stiffer roll-bar, and reinforced side rails) and suspension tweaks (including retuned dampers and re-rated coil springs at the front, and new dampers and softer spring rates on the live-axle rear) all works well together in this current HiLux package.

The HiLux has now drawn closer to the Ranger in terms of comfortable capability, if not matched it.

The Toyota HiLux SR5 has the maximum five-star ANCAP safety rating, as a result of testing in 2025.

As standard, it has eight airbags (now with a front-centre airbag) and an upgraded suite of driver-assist tech including improved auto emergency braking (AEB), lane-keep assist, adaptive cruise control, and blind-spot monitoring.

Like all Toyotas, there’s a five-year, unlimited-kilometre vehicle warranty. However, if you service at Toyota dealers you get two additional years of engine coverage, bringing the total to seven years.

The high-voltage battery coverage can also be extended up to 10 years if you service at Toyota dealers.

Roadside assistance is available to purchase from $99 annually.

Logbook servicing is required every 12 months or 15,000km, whichever comes first. The first five services are capped at $255 each, which is incredibly affordable. It’s only beaten by the likes of Honda.

Toyota has one, if not the, most prolific dealer networks in Australia. There are around 260 dealers and they span metro, regional and rural areas.

The HiLux has a five-year/unlimited kilometre warranty.

Service intervals are scheduled for every six months or 10,000km and cost $395 per service.

Toyota Australia has about 300 dealerships across the country.

This type of warranty is pretty standard among the HiLux's rivals so the Toyota ute does remain competitive, in terms of these ownership costs.