Ford Tourneo Custom vs MG MGS5 EV

What's the difference?

There’s absolutely no doubt that the van-based people-mover has some distinct advantages over a three-row SUV. The rear seat is bigger, access to it is far better and there’s more luggage space even when all eight seats are occupied. But the Tourneo goes a step or two further with the sliding, swivelling seats that make it one of the most practical and flexible interiors on the market.

True, the driving experience is a bit alien at first, but it’s a case of different, rather than worse. Meantime, the ride is excellent and the performance and economy from the turbo-diesel driveline are both absolutely spot on for this vehicle’s intended purpose.

And perhaps that’s the metaphor for the whole thing: By not trying to be something it’s not, and concentrating on what it needs to do, the Tourneo emerges as a bit of a quiet achiever.

As we said earlier, this type of vehicle concept is never a sure-fire proposition. Parcel vans converted to passenger duties haven’t always worked out. This time, though, it’s different.

Benchmark is a big word. But I’ve been testing cars long enough to know when and where to use it, and if my motoring instincts are correct the MG S5 EV could be the new benchmark for budget small electric SUVs.

Still we’ve only driven one grade - the Essence with the bigger 62kWh battery. We need to get the other grades into the garage to test them too, but on first impressions the MG S5 is outstanding for price, practicality, styling, ownership, and the way it drives.

Perhaps the biggest revision of the successful Transit Custom formula needed to make the leap from FedEx to Brady Bunch has been to the rear suspension. Where the Transit uses a leaf-sprung arrangement, the Tourneo has switched to coil rear springs. These technically offer much greater ride comfort at the expense of some load-carrying ability. Which is fine, even if your kids are the bigger variety.

The move to powered sliding side doors is a welcome one, but I found out the hard way that the doors will still open a fraction if you push the button while still travelling at low speed. Not sure why that would be, but at least the buttons in question are up front in Adult-Land, not within reach of you-know-who.

The reality is, too, that the Tourneo is destined to run with the air-con on any time you have bodes in the back. That’s because – like a lot of van conversions – there’s no opening side windows beyond the tiny, hinged windows that open an equally tiny amount. This has more to do with the Transit’s basic structure than any desire to oxygen-deprive the young `uns, but as any parent knows, a supply of fresh air on the move is sometimes the only thing between a happy day out and a clean up in Aisle five.

The MG S5 EV is a completely new car. Unlike the ZS EV which was a combustion car that was later turned into an EV, the S5 EV was designed from the start and built as an electric vehicle and that’s super important for everything from space to how it drives.

The S5 EV is a bigger car than the ZS EV. It’s 153mm longer and 40mm wider and it shares the same underpinnings as the excellent MG4 hatch.

The S5 EV looks a bit like the MG4 but an SUV version and I think the styling is a massive improvement over the ZS EV. This thing looks snatched with its sleeker shape and a smooth modern face, the blade-like LED running lights sitting atop the headlights and I really like the treatment to the tail-lights as well and the way the boot lid flicks up into a little integrated spoiler.

It's a far more refined, mature and prestigious look to the ZS EV. And while we're being completely subjective here I also think it's better looking and more refined than the BYD Atto 3 and Chery E5.

That same refinement and modernity is everywhere in the superb cabin from the clean dash design and door trims, to the steering wheel and floating centre console.

Here’s where a vehicle like this stands or falls. Because if something like a Tourneo can’t cope with lots of people and their luggage in a single bound, then there’s really not much point to it, is there? I mean you’re not going to buy it for its sporty looks or supercar dynamics, so unless it works brilliantly as family transport, it’s kind of dead in the water. Fortunately Ford seems to have got it right. Mostly, anyway.

That starts up front where the two front seats feel like they’re metres apart. In reality, this huge gap forms a walk-through function for getting access to anything or anyone misbehaving in the second or third row of chairs. But you can’t help wondering what if… What if Ford had ditched the stubby centre console and added a third front-row seat? Wouldn’t a nine-seater be better than eight?

But the seats themselves are comfy and the high-and-mighty driving position gives plenty of vision in every direction. With one exception. And that is when you’re pulling out of a side street on to a main road and need to see what’s coming from the left. Depending on the angle you’re on, the fat frame of the pop-out side window (in the sliding door) becomes a blind spot, especially for taller drivers.

There’s nothing irretrievably wrong with the way the controls are laid out, but they will take some acclimatisation. That goes for the menu system on the touchscreen as well as the column-mounted shifter wand which is about the same size and shape (and in the same place) as a conventional indicator stalk. Tip the lever accidentally and you’ll wind up in neutral, wondering what just happened. The manual-shift mode is also fiddly to use and paddle sifters would be vastly better. Most won’t bother anyway.

The front cabin is home to a shallow lidded bin in the centre console, a deeper bin below that and a couple of charge points. There are also cup-holders in great spots up high in the corner of the dashboard, a shelf across the top of the dashboard and no less than two gloveboxes (the top one is pretty shallow) thanks to moving the passenger’s airbag into the roof lining. Both front doors also feature bins and storage nooks but there’s a fair bit of hard plastic on show, surely a legacy of the Tourneo’s parcel-van DNA.

The Tourneo’s party trick is the way both the second and third rows of seats can be slid to almost any point on a pair of tracks in the floor. The move is simply accomplished via a lever at the front or a rip-cord in the back of the seats, and all three centre-row seats can be moved individually (the third row is split 60:40). The upshot is that you can have all three rows bunched together for a large luggage space, or the rear row pushed right back to form a rear row with huge legroom. Don’t need all eight seats? How about a second row with the two outside chairs in place and the centre one folded forward to expose a work-surface with built-in cupholders.

But it gets even better, because individual seats can be removed to suit the weirdest of loads and the second-row seats even swivel 180-degrees to form a loungeroom on wheels. The kids will be begging you to take them for a drive in this thing.

The seats fold forward, but they don’t tumble. They don’t need to really, and they don’t fold into a bed either. But if you fancy camping in the Tourneo, you can remove both rows of rear seats for a huge flat floor.

The second row is home to storage bins in each sliding door (yes, a door on each side) a pop-put window that opens only about 40mm, temperature controls, air vents and reading lights. The third row, meantime, is not only easily accessed provided the second row isn’t slid all the way back (at which point you wouldn’t be using the third row anyway) but the good news is that the rearmost seat itself is basically three bucket seats with the same comfort levels (high) as the second row. There are also reading lights and a pair of phone pockets and cup-holders in the last row, too. Only the way the track system works and the shape of the seat base means that foot-room is limited to an extent.

With all three rows in place, but pushed as far forward as they can go, there’s a long load area of up to 725mm. But you can also push the second and third rows all the way back and have a cargo area 2622mm long behind the front seats. Maybe the van DNA is a good thing after all.

With all eight seats in place, there’s a minimum of 673 litres of luggage space which can be expanded all the way to a monster 4683 litres with the second and third rows removed.

There’s also a 12-volt power socket and a lighting system in the back, too, although while the side doors are automatic, the tailgate is manual. And you’ll need plenty of real estate to open it, too. Even tall folk will hit the button to open the tailgate, start the strut-assisted opening and then take a step or two back to allow the huge tailgate to rise without clobbering them. An automatic tailgate where you hit the button and run away to a safe distance would be much nicer.

The MG S5 EV’s practicality is also outstanding and while it’s early days, it could be the new benchmark for the class. It's a spacious cabin with superb ergonomics and excellent storage.

Even as a taller person (I’m 189cm) there was plenty of elbow, shoulder and legroom for me as a driver and also to sit behind my driving position in the second row.

Storage is excellent with giant bottle holders in all the doors, stowage under the floating centre console, four cupholders and a flat space for your phone which also is a wireless charger on the Essence.

It’s such an ergonomic and practical cabin even the buttons are practical. There’s a volume dial, and physical buttons and switches for the climate control switch, not screen buttons.

And then there’s the boot, at 453 litres it’s about 10 litres bigger than the ZS EV’s cargo capacity. It's also 10L larger than the Atto 3 and a lot bigger than the Chery E5’s boot.

There are two grades in the MG S5 EV line-up. The Excite is the entry grade and the Essence is the top-of-the-range grade. Both come with a choice of two batteries - there's the smaller 49kWh battery and a bigger 62kWh battery. Now that you know this, the pricing will make more sense.

The MG S5 EV line-up starts at $40,490 with the entry grade Excite with the 49kWh battery, then steps up to $42,990 for the Essence also with the 49kWh battery. That increases to $44,990 for the Excite with the 62kWh battery and tops out at $47,990 for the Essence with this unit. All prices are drive-away.

Standard features on both the Excite and Essence include LED headlights, LED running lights and LED tail-lights, also standard are alloy wheels - 18-inch ones on the Essence and 17s on the Excite.

Both grades have proximity unlocking single-zone climate control, a 12.8 inch media display digital radio, a four-speaker stereo on the Excite and a six-speaker sound system on the Essence, while both have wireless Apple CarPlay and Android Auto, sat nav and a 10.25-inch instrument cluster.

The Essence has a few extra items the Excite doesn’t get like rear privacy glass, a panoramic glass roof, wireless phone charging, heated front seats and a power driver’s seat.

Because the platform is (mostly) borrowed from the Transit Custom, you get the same driveline. That starts with a 2.0-litre turbo diesel, good for 125kW of power and a useful 390Nm of torque. It drives through a conventional eight-speed automatic transmission and then to the front wheels as a means of keeping the load floor as flat and low as possible.

Ford claims a 2500kg towing capacity with a braked trailer, but on a wet road or damp boat ramp, that’s really going to test the limits of the front wheel’s grip which can be overcome even in the dry if you’re too hasty with the throttle.

The biggest engineering change in the move from Transit Custom to Tourneo has been the switch from leaf springs on the former to coil springs and an independent suspension on the latter. This is all in the name of ride quality and recognises the fact that the Transit will often be called on to cart heavier loads than eight humans.

The MG S5 EV has one electric motor driving the rear wheels and it has an output of 125kW and 250Nm. That’s plenty of grunt to move this electric car quickly and instantly in a way that feels controllable and smooth. 

While front-wheel-drive cars are absolutely fine, rear-wheel drive tends to offer more engagement and feel, and that's an added bonus for the S5 EV.

Ford quotes an official combined fuel consumption figure of 7.4 litres for the Tourneo. Over a few days of running in a pretty broad mix of urban and country work, we saw an average of 8.6 litres per 100km which is still pretty good for a vehicle of this size.

With the standard 70-litre fuel tank, that gives the Tourneo a theoretical combined range of around 900km between fills, but the real-world number says closer to 800km is more realistic.

Don’t forget, either, that running costs will be a little higher than some diesels, as the Tourneo requires AdBlue at regular intervals, in line with its Euro 6 emissions levels.

The MG S5 EV’s energy consumption varies depending on the grade and battery size.

The most efficient in the range is the entry grade Excite with the 49kWh battery with MG saying on a combination of open and urban roads it should use 16.6kWh/100km (WLPT). The biggest energy user in the range is the Essence grade with the 62kWh battery with 17.1kWh/100km.

As for the range, this varies from 335km in the 49kWh Essence to 430km in the 62kWh Excite.

If you haven’t driven a one-box van for a decade or more, you’re in for a treat. Just like the Transit Custom on which this car is based, the Tourneo represents a different experience to that of a conventional car or SUV, but one that is not without merit.

For a start, you sit very high which means a great view out across the traffic. And while the driving position is a little less laid-back than a modern car, once you get used to the almost square steering wheel, neither is it the dreaded sit-up-and-beg of older van designs.

The four-cylinder engine doesn’t make the Tourneo a fast vehicle, but it does give it lots of flexibility thanks to all that turbo-torque being available from just off idle. The eight-speed transmission helps, too, but the real surprise is just how quiet the Tourneo is when on a cruising setting. In fact, it’s almost uncanny how such a big, empty metal box could be so silent, but beyond a little tyre noise on coarse surfaces, the Ford pulls it off. As a result, it’s very relaxed and effortless feeling at freeway speeds.

The other surprise is how good the ride quality is. By swapping the cargo van’s leaf rear springs for coils, the Tourneo suddenly displays a very good match between the front and rear axles in terms of how they work to absorb bumps. You do still get some of the front-seat sensation that you’re sitting over the front axle, but it’s not terrible and the reality is that you simply sitting closer to the axle, not right over it.

For many drivers perhaps the over-riding impression will be of the vehicle’s external size. And, yes, it’s a long and wide piece of equipment, but at least the boxy shape means the corners are easy to place and the huge glass area and driver aids like parking sensors and blind-spot warnings help a lot in the daily cut and thrust.

Things are also improved by the fabulously small turning circle of 10.9m kerb-to-kerb (courtesy of the Transit’s role as an inner-city delivery van) that gives an agility the looks don’t suggest. But there’s a sense that the Tourneo is a little wider in the rear track than the front, as you’ll sometimes find the inside rear tyre finding the lips of roundabouts and suburban gutters.

The MG S5 EV is outstanding to drive for an electric vehicle at this affordable price point. Again, I’m going to put it out there and suggest it could be the new benchmark for the more affordable end of the small electric SUV segment. Kia's EV3 is also a winner on the road, but it's quite a bit pricier than the MG.

I was never a fan of the way the ZS EV drove, from its seating position to ride and handling. But the MG S5 EV is completely different to pilot. It’s excellent.

This car feels so composed on the road, the body control is excellent, the steering is well weighted and direct, the visibility is excellent and the pedal feel under my feet is solid, too. And all of that is combined with an electric motor that makes the perfect amount of power.

Add to all this the rear-wheel-drive component and the MG S5 EV is not just easy to drive but engaging as well.

The MG S5 EV has the maximum five-star ANCAP rating and that’s from 2025 so it is super fresh. That means it has the lot so there’s auto emergency braking (AEB), front cross-traffic alert, rear cross-traffic alert with braking, lane keeping assistance and blind spot warning, adaptive cruise control, intelligent speed limit assist and more.

There's also a driver and front passenger airbag, two side airbags, two curtain airbags and a far side airbag.

For child seats there are two ISOFIX points and three top tether anchor points.

Ford offers its standard five-year/unlimited kilometre warranty on the Tourneo. Five years is fair enough, but can’t match the seven years or even more that some of the competition offer. It‘s worth noting, however, that the warranty does match many of the makes and models that will be the Ford’s natural enemies.

Service intervals are 12 months or a very long 30,000km, but it’s unlikely many families will clock up 30,000km in a 12-month period, anyway. There’s no word on capped-price servicing yet, but the mechanically similar Transit Custom has a service plan that limits the cost of each of the first four services to around $500.

The biggest additional running cost for the Tourneo will be the AdBlue additive to control emissions. How frequently you need to top up will be determined by what type of driving you do.

The MG S5 EV is covered by MG’s 10-year 250,000 kilometre warranty. And that includes the battery. Regular families though do about 10,000km a year or 20,000km maximum, so this warranty offers excellent coverage for them.