Volvo XC40 vs Toyota Corolla Cross

What's the difference?

The Volvo XC40 Recharge Twin Motor is a cute small electric SUV that offers a decent specs list and a sweet urban driving experience. It’s not the nicest ride on a longer journey but it does have a decent range to be able to tackle one, if needed. I didn’t love the interior design but there’s lots the XC40 gets right.

The Corolla Cross is still an incredibly sensible car if you’re needing to buy a car, but you’re not a car person. Everything is intuitive and easy, allowing you to focus on driving.

This update has helped make this car stand out a bit more, but it’s still a bit vanilla. The Hyundai Kona, for example, offers more character. Also the asking price, especially at the top end, is creeping eerily close to RAV4 territory.

The XC40 Recharge sees some design changes from its fuel-based counterparts and that’s mainly seen in the front because you get a body-coloured panel instead of a standard grille. The 20-inch alloys feature a chunkier-looking design but the front still boasts the cool ‘Hammer of Thor’ headlights (which I'm rather fond of).

The interior is where the electric powertrain loses me because the fuel-based equivalent is so much nicer inside with its leather-accented upholstery and trims.

It's lovely that there has been a conscious effort to use recycled materials and non-leather upholstery throughout but I'm left with the strange-feeling that synthetic seats don’t reflect the grade or price level of this car. 

Other than the cool-looking topography inserts on the dash and front doors and the 9.0-inch vertical multimedia system, it’s pleasant but a little basic in the cabin. Which is shame because the exterior is cute as hell.

Toyota has put some effort into jazzing up the Corolla Cross’ exterior design. The pre-update car was arguably one of the more vanilla cars in its segment.

The most noticeable changes are up front. There’s a new grille set-up with hexagonal cutouts, as well as new LED headlights that are connected by a section that illuminates at night. This latter part looks quite tacky and feeds into the current trend of full-width light bars.

Around the side there are new 18-inch alloy wheel designs on this Atmos trim, as well as a revised LED tail-light set-up.

You can still tell this car is clearly a Corolla Cross from the outside thanks to the cladding around the wheel arches, but it no longer looks so boring, especially in top-spec Atmos guise.

Inside the design changes are more minimal. There’s a new centre console set-up that includes a chunkier gear selector, as well as an ambient lighting strip that wraps around the outside.

I prefer this centre console as it looks more substantial than the pre-update car’s, however, the glossy piano black is a big downside. After a week of testing it was already dusty and grimy, plus scratches are inevitable when you wipe it clean.

Beyond this there are no other obvious changes. I wish Toyota would include some differing colours and finishes inside as it’s a bit of a sea of black.

While there are some soft-touch materials on the dashboard and armrests, you don’t need to look far to find harsher, scratchier finishes. I expect better in a car that costs more than $50,000.

Front passengers enjoy the most space and I have plenty of head- and legroom up front. It’s a really easy car to get in and out of and the individual storage is very good for the class. 

Front passengers enjoy a glove box, middle console with a removeable bin, two cupholders, utility tray and skinny drink bottle holders in the storage bins in the doors.

In the rear, passengers get map pockets on the backs of the front seats, two cupholders in the fold-down armrest and small storage bins in each door.

The synthetic leather-trimmed seats look neat and tidy but are very hard in the cushion, which makes them a tad uncomfortable on longer trips. The rear seats are much the same.

Charging options throughout the car are good with the front enjoying a 12-volt port, two USB-C sockets and a wireless charging pad to choose from. The rear also gets two USB-C ports and there's another 12-volt outlet in the boot.

The rest of the technology is easy to use once you spend some time with it. The 9.0-inch touchscreen multimedia system features built-in Google Maps, Assistant and Play Store apps, as well as, YouTube.

The 12.0-inch digital instrument panel isn’t customisable but I like the way it pulls through the satellite navigation screen and directions.  

Because of the dual-motor powertrain, your boot capacity drops to 419L from 452L for the single-motor variant. It is large enough for my grocery shop and random errands and you can fold the floor up to create a deep storage well for additional space. Fold the 60/40 split-folding rear seat and available space expands to 1295 litres.

I don’t like the hardened cargo liner, it feels and looks a little cheap, but I do like the powered tailgate. There’s also handy frunk storage of 31L, which is perfectly sized for any charging cables you will have.

The front seats in this car are deliciously comfortable. The bolsters hug you nicely and there’s plenty of upper back and leg support.

I’m also a fan of the upholstery finish in this Atmos trim. It’s a combination of leather and fabric which is great because the front seats also offer heating and now ventilation.

The steering wheel is a classic Toyota unit that features synthetic leather wrapping and heating function. There are also plenty of clearly labelled physical buttons that are a treat to use.

Behind this there’s a 12.0-inch digital instrument cluster like plenty of other Toyota models now. It features a familiar set-up that allows you to change a number of widgets and save multiple pages of configurations.

Moving across, the 10.5-inch touchscreen multimedia system is high-resolution and has crisp colours. There’s not a heap to do in the native user interface so there’s no excuse to get lost.

Thankfully there’s wireless Apple CarPlay and Android Auto. Connection was immediate with my iPhone 15 Pro Max when starting up the car and it remained rock solid throughout known interference points.

Under the touchscreen I appreciate that Toyota has retained physical climate control buttons and dials. They’re very easy to understand and use, especially on the move.

In fact, there are a lot of physical buttons around the cabin. This is great because you don’t need to dive into touchscreen menus and sub-menus.

In terms of amenities up front there are two cupholders, a wireless charger, USB-C charger, centre console box with a 12V socket, as well as a glovebox.

Moving to the second row there’s a decent amount of space for a small SUV, though if you want to use the seats more, you’ll likely want to opt for something larger, like a RAV4.

At 182cm tall I have minimal legroom behind my own driving position, though toeroom is excellent. Headroom is fine though it is impeded due to the panoramic glass sunroof, which notably doesn’t open despite the thick crossbar.

You can easily get two adults in the back of the Corolla Cross, though pushing it to three would make things squishy. It doesn’t help that there’s a central hump in the floor.

Amenities include rear air vents, two USB-C ports, bottle holders on the doors, plus a fold-down armrest with cupholders.

Around the back there’s a hands-free power tailgate that’s handy if you’ve got your hands full. In classic Toyota fashion, it opens and closes with plenty of beeps, which may attract attention.

There’s 380L of boot space with the rear seats upright, expanding to 2000L with them folded. This is fine for the segment, but doesn’t stand out. Front-wheel drive trims get a touch more boot space as they don’t have the rear electric motor.

In the boot area there’s a light, some hooks and a load cover. Unfortunately all-wheel-drive trims don’t come with a spare wheel whatsoever. Instead they only get a tyre repair kit.

It’s worth noting two-wheel-drive trims get a space-saver spare wheel. This is important if you frequently do long-distance drives away from tyre repair shops.

The 2026 Toyota Corolla Cross line-up now starts from $37,440 before on-roads for the GX Hybrid trim, however, on test here is the flagship Atmos Hybrid AWD trim at $50,990 before on-roads. That’s a fair chunk of change for a small SUV.

For context, you can get a mid-spec RAV4 Cruiser Hybrid for around the same price as this Corolla Cross. Ultimately it comes down to whether you want a bigger car or more equipment.

Speaking of the latter, this top-spec Corolla Cross is stacked with equipment.

Highlights include new 18-inch alloy wheels, LED headlights, a panoramic glass sunroof, 12.0-inch digital instrument cluster, 10.5-inch touchscreen multimedia system with wireless Apple CarPlay and Android Auto, a nine-speaker JBL premium sound system, heated and ventilated front seats, as well as premium leather-accented upholstery.

One of the few things this car is missing over its rivals is the availability of a head-up display.

The XC40 Recharge Twin Motor features two electric motors which are powered by a large 82kWh lithium-ion battery and produce a combined power output of 300kW and 670Nm of torque.

Which is downright fun because it can do a 0-100km/h sprint in just 4.8-seconds!

Like last year, all Corolla Cross trims now come with a hybrid powertrain. It’s unchanged with this facelift.

There’s a 2.0-litre four-cylinder petrol engine with either one or two electric motors, depending on whether you opt for a front- or all-wheel drive version. Our tester is the latter so it has two electric motors.

Total system output is 146kW with drive sent through an electronic continuously variable transmission (e-CVT). Top speed is 180km/h.

It’s worth pointing out there is no power difference between the front- and all-wheel drive trims. Uniquely, the latter picks up a ‘Snow’ drive mode.

The official energy consumption figure is 19kWh/100km and I averaged 19.2kWh over a fair mix of urban and open-road driving. The energy consumption isn't bad but some rivals do sit closer to that 16.5kWh mark.

The official driving range is up to 485km for this model but I only ever saw a top range of 410km. That's not terribly surprising given I wasn't shy with the power use but there was a little bit of range anxiety on longer trips.

The XC40 Recharge Twin Motor has a Type 2 CCS charging port which means you can benefit from faster charging speeds. On an 11kW AC charger you can go from 0-100 per cent in eight hours but on a standard three-pin house plug socket expect that wait time to go up significantly.

On a DC fast charger expect to go from 10-80 per cent in as little as 33-minutes.

Toyota claims the Corolla Cross Atmos Hybrid AWD consumes an average of 4.4L/100km on the combined cycle. This is 0.2L/100km higher than front-wheel-drive trims.

During my week of testing I saw an average of 5.0L/100km, according to the trip computer. This is fine, but I’ve experienced better in other hybrid SUVs.

However, during one trip into the office with heavy traffic I achieved an average of 3.7L/100km. Now that’s frugal!

All-wheel-drive trims get a larger 43L fuel tank compared to the 36L unit front-wheel-drive versions have.

Using my as-tested fuel consumption, this car has a theoretical range of 860km.

All Corolla Cross variants require a minimum of 91 RON regular unleaded petrol.

Like the Polestar 2 there’s no ignition button on the XC40. You shift into drive to ‘turn on’ and after you park, you simply get out to turn it off. It takes a little while to get used to but it’s a cool feature. 

The twin motors deliver a hefty kick and you never worry about not having ‘enough power’. In the city it’s zippy but on the open-road you also feel comfortable getting up to speed or overtaking because the power distribution is so well-balanced because it’s an AWD.

I customised my steering wheel ‘feel’ to firm and it makes the handling crisp and direct. You feel like you’re in total control whenever you have to tackle be it tight streets or small car parks.

The blind-spot visibility is compromised by how wide the B and C-pillars are and I find that I'm relying a lot more on the blind-spot monitoring system to compensate.

The XC40 loses a few points for me in terms of ride comfort. As mentioned, the seats aren't terribly comfortable but the suspension is hard enough that you notice every bump, as well.

Road noise is also quite pronounced and it doesn’t sound refined when you drive at higher speeds, which is a shame. The flip-side, though, is that you don’t notice those things as much on short, urban trips.

The standard regen braking isn’t customisable and you don’t notice it until you switch over to a 'one-pedal' function. I found this function uncomfortable to use as it’s very aggressive and creates a jerky driving experience. 

Because of its 4440mm length and tiny 11m turning circle, you won’t struggle in a car park! The 360-degree view camera system and front and rear parking sensors make it easy to navigate a tight spot.

This is a joy to park. It’s so easy.

When you first start up the car it usually defaults to EV mode unless the petrol engine is bone cold. If this is the case it’ll fire it up to get the fluids warmed up.

Once the engine reaches operating temperature it typically switches off again, allowing you to cruise around exclusively on electric power. This never stops being fun and it’s almost a game to try and eke out as much electric juice as possible before the engine fires up again.

This is inevitable however once the battery charge gets low enough, or you press the accelerator that little bit harder. There’s no noticeable switch from electric to petrol that can be felt, but you do hear the petrol engine whirring away under the bonnet.

Despite this hybrid powertrain producing a total system output of 146kW, it doesn’t really feel like it from behind the wheel. Once you push the accelerator, the petrol engine tends to sound strained. It’s not a nice sound as it’s amplified by the fact there’s an e-CVT that doesn’t require gear shifts.

There’s great regenerative braking as standard which helps recuperate kinetic energy from slowing down back into the battery. This is helpful as it acts like engine braking down hills without actually using the brakes.

When you come to a complete stop the transition from the regen brakes to the traditional friction brakes can be a little grabby. You need to be prepared to alter the pressure you’re applying to the brake pedal.

The suspension in this car is a major highlight. It balances comfort and composure perfectly, allowing for an effortless driving experience. It soaks up virtually all road imperfections with ease, including harsher speed bumps.

This flows on to the steering which does err on the firmer side, but feels direct and a touch sporty. Overall this makes the Corolla Cross a fun vehicle to pilot even on the most dull roads.

On the parking front there are front and rear parking sensors, as well as a surround-view camera with great resolution. Even though this car is easy to park, there’s also a semi-autonomous park assist that can be handy if you’re not great at parallel parking.

Out on the open road the petrol engine does stay on more consistently. It’ll quickly flare the revs if you need to accelerate harder which makes me grit my teeth every time because it’s not the most refined sound.

Despite this there were moments when I was travelling at 80km/h and the petrol engine turned off, allowing the car to drive exclusively on EV power. This primarily only happens on flat roads as the moment there’s even a whiff of a hill, the engine kicks back in again.

There’s a fair bit of road noise that enters the cabin at higher speeds, which isn’t uncommon for small SUVs. However, there’s also noticeable wind noise that sounds like it comes from the sunroof or the side mirrors.

The Corolla Cross was awarded a five-star ANCAP safety rating in 2022 based on testing conducted by Euro NCAP. The two safety authorities have harmonised testing protocols.

Standard equipment includes eight airbags, autonomous emergency braking (AEB), blind-spot monitoring, rear cross-traffic alert, lane-keep assist, lane centring, adaptive cruise control, front and rear parking sensors, as well as a reversing camera.

The AEB system activates from 5km/h and lane-trace assist (lane centring) can be activated from 0km/h.

Also standard is one year of complimentary access to Toyota’s connected services. This allows for SOS emergency calling, as well as a range of remote features via a smartphone app.

Stepping up to the GXL brings a surround-view camera, as well as vehicle detection for the low-speed front and rear AEB.

All three rear seats have top-tether points and the two outboard rear seats have ISOFIX child seat anchorage points.

It’s all fairly standard on this front.

The ongoing costs are pretty solid with the XC40 coming with a usual five-year/ unlimited warranty term but the drive battery is covered for eight years/160,000km.

You can pre-purchase a five-year/150,000km servicing program for a flat $3000 or an average of $600 per service, which is a bit expensive for the class. Servicing intervals are great at every two-years or 30,000km, whichever occurs first.

You get complimentary roadside assistance for five-years through Assist Australia and if you meet certain criteria, you can extend that by a further three years, which is handy.

Like all Toyotas, there’s a five-year, unlimited-kilometre vehicle warranty. However, if you service at Toyota dealers you get two additional years of engine coverage, bringing the total to seven years.

The high-voltage battery coverage can also be extended up to 10 years if you service at Toyota dealers.

Roadside assistance is available to purchase from $99 annually.

Logbook servicing is required every 12 months or 15,000km, whichever comes first. The first five services are capped at $255 each, which is incredibly affordable. It’s only beaten by the likes of Honda.

Toyota has one, if not the, most prolific dealer networks in Australia. There are around 260 dealers and they span metro, regional and rural areas.