Ford Tourneo vs Ford Mustang Mach-E

What's the difference?

There’s absolutely no doubt that the van-based people-mover has some distinct advantages over a three-row SUV. The rear seat is bigger, access to it is far better and there’s more luggage space even when all eight seats are occupied. But the Tourneo goes a step or two further with the sliding, swivelling seats that make it one of the most practical and flexible interiors on the market.

True, the driving experience is a bit alien at first, but it’s a case of different, rather than worse. Meantime, the ride is excellent and the performance and economy from the turbo-diesel driveline are both absolutely spot on for this vehicle’s intended purpose.

And perhaps that’s the metaphor for the whole thing: By not trying to be something it’s not, and concentrating on what it needs to do, the Tourneo emerges as a bit of a quiet achiever.

As we said earlier, this type of vehicle concept is never a sure-fire proposition. Parcel vans converted to passenger duties haven’t always worked out. This time, though, it’s different.

The Mustang Mach-E is fantastic to drive and very competitive on the range and equipment front, allowing it to outpace some of its well established rivals in Australia.

In fact, it's almost a shame about the Mustang name, because it will distract from what is, at its core, a compelling first step for Ford into the fully electric space.

So, don’t expect a ‘Mustang’, at least not in the traditional sense. But this is certainly something. A new future for a new Ford.

Note: CarsGuide attended this event as a guest of the manufacturer, with travel, accommodation and meals provided.

Perhaps the biggest revision of the successful Transit Custom formula needed to make the leap from FedEx to Brady Bunch has been to the rear suspension. Where the Transit uses a leaf-sprung arrangement, the Tourneo has switched to coil rear springs. These technically offer much greater ride comfort at the expense of some load-carrying ability. Which is fine, even if your kids are the bigger variety.

The move to powered sliding side doors is a welcome one, but I found out the hard way that the doors will still open a fraction if you push the button while still travelling at low speed. Not sure why that would be, but at least the buttons in question are up front in Adult-Land, not within reach of you-know-who.

The reality is, too, that the Tourneo is destined to run with the air-con on any time you have bodes in the back. That’s because – like a lot of van conversions – there’s no opening side windows beyond the tiny, hinged windows that open an equally tiny amount. This has more to do with the Transit’s basic structure than any desire to oxygen-deprive the young `uns, but as any parent knows, a supply of fresh air on the move is sometimes the only thing between a happy day out and a clean up in Aisle five.

The Mach-E looks good, but nothing like the designs you have come to expect from Ford.

Sure, there are plenty of notes, references and hints, to its Mustang namesake, some more hidden than others, but fans will have to accept this is a new interpretation of the badge for a new era, and at the end of the day, it’s an electric mid-size SUV.

The overall visage is a little more sleek than your average RAV4, though, with a long wheelbase, coupe-like rear, and a curvy shape which no doubt helps it cut through the air as efficiently as its shape will allow.

Mustang hints are found, obviously, in the big pony badge on the front, but also the frowny-face headlight profile, and iconic three-bar pattern for the rear lights, too.

There are even hidden things, like pony imprints on the underbody protection, and ‘electric ponies live here’ branded onto the motor unit, where few buyers will likely ever see it. In a move which should keep all Mach-E owners happy, every grade looks great, each having its own character.

The base car looks all aero with its wheel covers and more humble plastic cladding pieces, while the Select adds contrast piano black bits and more traditional alloy wheels.

The GT goes harder still with a 3D-effect grille and much more Mustang-like 20-inch wheels.

I’m not sure what I was expecting when it came to the Mach-E’s interior, but it looks a bit more ordinary in pictures than it does when you’re in the car.

What appears from a distance to be a hodgepodge of bits from Ford America and Ford Europe with the same dull grayscale theme is more nuanced and textured once you’re in the driver’s seat.

I especially like the tiered dash with the speaker-bar look for the Bang & Olufsen system which integrates across the front, and the 15.5-inch screen which looks like it will dominate the space is actually at a perfect distance from the driver.

An appreciated amount of soft-touch surfaces and synthetic leather finishes round out the space. There is even a grade-specific textured detail piece running across the dash. Nice touch.

It’s also a lot to take in, but somehow it works. One thing is for sure though, it’s not traditional ‘Mustang’. This has jumped from the big, brash, old-world (and often maligned for quality issues) interior, to something cleaner, more open and futuristic.

Here’s where a vehicle like this stands or falls. Because if something like a Tourneo can’t cope with lots of people and their luggage in a single bound, then there’s really not much point to it, is there? I mean you’re not going to buy it for its sporty looks or supercar dynamics, so unless it works brilliantly as family transport, it’s kind of dead in the water. Fortunately Ford seems to have got it right. Mostly, anyway.

That starts up front where the two front seats feel like they’re metres apart. In reality, this huge gap forms a walk-through function for getting access to anything or anyone misbehaving in the second or third row of chairs. But you can’t help wondering what if… What if Ford had ditched the stubby centre console and added a third front-row seat? Wouldn’t a nine-seater be better than eight?

But the seats themselves are comfy and the high-and-mighty driving position gives plenty of vision in every direction. With one exception. And that is when you’re pulling out of a side street on to a main road and need to see what’s coming from the left. Depending on the angle you’re on, the fat frame of the pop-out side window (in the sliding door) becomes a blind spot, especially for taller drivers.

There’s nothing irretrievably wrong with the way the controls are laid out, but they will take some acclimatisation. That goes for the menu system on the touchscreen as well as the column-mounted shifter wand which is about the same size and shape (and in the same place) as a conventional indicator stalk. Tip the lever accidentally and you’ll wind up in neutral, wondering what just happened. The manual-shift mode is also fiddly to use and paddle sifters would be vastly better. Most won’t bother anyway.

The front cabin is home to a shallow lidded bin in the centre console, a deeper bin below that and a couple of charge points. There are also cup-holders in great spots up high in the corner of the dashboard, a shelf across the top of the dashboard and no less than two gloveboxes (the top one is pretty shallow) thanks to moving the passenger’s airbag into the roof lining. Both front doors also feature bins and storage nooks but there’s a fair bit of hard plastic on show, surely a legacy of the Tourneo’s parcel-van DNA.

The Tourneo’s party trick is the way both the second and third rows of seats can be slid to almost any point on a pair of tracks in the floor. The move is simply accomplished via a lever at the front or a rip-cord in the back of the seats, and all three centre-row seats can be moved individually (the third row is split 60:40). The upshot is that you can have all three rows bunched together for a large luggage space, or the rear row pushed right back to form a rear row with huge legroom. Don’t need all eight seats? How about a second row with the two outside chairs in place and the centre one folded forward to expose a work-surface with built-in cupholders.

But it gets even better, because individual seats can be removed to suit the weirdest of loads and the second-row seats even swivel 180-degrees to form a loungeroom on wheels. The kids will be begging you to take them for a drive in this thing.

The seats fold forward, but they don’t tumble. They don’t need to really, and they don’t fold into a bed either. But if you fancy camping in the Tourneo, you can remove both rows of rear seats for a huge flat floor.

The second row is home to storage bins in each sliding door (yes, a door on each side) a pop-put window that opens only about 40mm, temperature controls, air vents and reading lights. The third row, meantime, is not only easily accessed provided the second row isn’t slid all the way back (at which point you wouldn’t be using the third row anyway) but the good news is that the rearmost seat itself is basically three bucket seats with the same comfort levels (high) as the second row. There are also reading lights and a pair of phone pockets and cup-holders in the last row, too. Only the way the track system works and the shape of the seat base means that foot-room is limited to an extent.

With all three rows in place, but pushed as far forward as they can go, there’s a long load area of up to 725mm. But you can also push the second and third rows all the way back and have a cargo area 2622mm long behind the front seats. Maybe the van DNA is a good thing after all.

With all eight seats in place, there’s a minimum of 673 litres of luggage space which can be expanded all the way to a monster 4683 litres with the second and third rows removed.

There’s also a 12-volt power socket and a lighting system in the back, too, although while the side doors are automatic, the tailgate is manual. And you’ll need plenty of real estate to open it, too. Even tall folk will hit the button to open the tailgate, start the strut-assisted opening and then take a step or two back to allow the huge tailgate to rise without clobbering them. An automatic tailgate where you hit the button and run away to a safe distance would be much nicer.

This is especially true when it comes to the usability of the cabin. I was surprised to be greeted by a high seating position, a wide cabin, and an abundance of storage with plenty of neat features.

For a start, the centre console is a nice piece of design. It features a floating bridge section with a wireless charging bay, rubberised storage tray, dual bottle holders with variable edges, and a floating armrest piece with a large console box below.

In front, and below the wireless chargers, there’s a big cutaway for additional storage, and a decent sized glove box on the passenger side.

The all-dominating touchscreen, as mentioned, is at a nice distance from the driver, isn’t as obstructive as it looks and unlike the Tesla Model Y or Model 3, the Mach-E scores a little digital instrument panel to provide the driver with conveniently-located core information.

I only have two gripes about these systems. Unfortunately, you have to adjust the climate functions through the touchscreen.

There’s a nice central volume dial, but it would be nice to have physical adjustment dials for temperature and fan speed, too.

As it is, the touch areas are quite small, and require a bit of concentration to jab at.

The instrument panel has a nice clean design, but isn’t customisable, the limited information it shows is all you get. Better than not having one, I suppose.

The rear seat is also excellent, offering me, at 182cm tall, plenty of airspace for my knees, and sufficient width for my arms. Headroom is its most limited dimension, although I fit without my head touching the roof.

The seats are brilliant, clad in a decent synthetic leather material and padded with an excellent amount of foam material for a comfortable ride no matter where you’re seated. The centre seat even seems usable for adults, thanks to the Mach-E’s flat floor.

Rear passengers are treated to bottle holders in the doors, two more in the centre drop-down armrest, USB ports on the back of the centre console, pockets on the backs of the front seats, and a pair of adjustable air vents.

Annoyingly, the huge panoramic sunroof doesn’t have a retractable shade, nor is there a flexible shade accessory on the options list.

Sure, it looks great, but it could be a nuisance, baking the interior during hot Australian summers.

For some reason this particular trait is common in more and more EVs with the Tesla Model Y and Polestar 2 sharing the same issue.

Boot space is 402 litres (VDA) which is not particularly large for a mid-size SUV. I would expect 450 litres or more in this category, but the Mach-E is compromised a little by its aggressively-shaped rear.

It also doesn’t get a spare wheel of any kind, making do with a repair kit under the floor.

Ford also throws in a Type 2 to Type 2 public AC charging cable, but if you plan on charging from a wall socket at home you’ll have to delve into the accessories list.

One of my favourite Mach-E features is the 134 litre frunk. I’ve said before I don’t think this particular EV fad is super useful.

It’s often an inconvenience to have to pop the front from the inside, and I’ve found in my long-term loans of EVs I rarely use them, but the Mach-E’s frunk is special because it’s watertight and drainable.

This opens up some neat opportunities, like the ability to throw dirty hiking, diving, or work equipment in there and hosing it out later, or even filling it up with ice and chucking a case of drinks of your choice in there for an old-fashioned American block party. It even has integrated cupholders for this express purpose.

Price is key to any new electric car, and the Mach-E doesn’t do anything unexpected. It’s not here to be a new, more affordable mid-sized electric option in Australia, instead leaning on its performance credentials to slice out its own niche amongst its competitors.

Three Mach-E grades arrive in Australia with prices ranging from $79,990 for the most affordable rear-wheel drive Select version, stepping up to $91,665 for the also rear-drive Premium and stretching to $107,665 for the all-wheel drive GT.

Before you start adding on-road costs or state-based discounts then, the Mach-E competes with mid-grade or higher-end versions of the Hyundai Ioniq 5, Kia EV6, Tesla Model Y - and maybe the more sedan-like Polestar 2.

Range is, of course, key to the price equation for any EV, and this is where the main differences lie between the variants, which are remarkably similar when it comes to standard equipment. The base Select gets a smaller, more affordable 71kWh battery pack. It grants the entry-point car a driving range of 470km on a single charge. Not bad at all.

Next up, the Premium grade remains rear-wheel drive, but swaps up to a larger 91kWh battery unit, delivering one of the longest ranges of any EV on the Australian market, at 600km.

Finally, the top-spec GT moves to all-wheel drive, almost doubling its power outputs, but maintains the same 91kWh battery, for a reduced but still respectable range of 490km between charges.

Standard equipment is impressive, too. Even the base Select scores items usually reserved for high-spec cars, like synthetic leather interior trim with heated and power adjust front seats, a panoramic sunroof, and a Bang & Olufsen 10-speaker premium audio system.

Other standard equipment includes the impressive 15.5-inch portrait-oriented multimedia touchscreen with wireless Apple CarPlay and Android Auto connectivity, a matching wireless phone charging bay, a 10.2-inch digital instrument cluster, 19-inch alloy wheels (with aero panels), a 360-degree parking camera, LED headlights, and the full safety suite.

The Premium grade scores higher-spec LED headlights, contrasting piano black exterior trim, black headliner and red stitching for the interior, as well as metal scuff plates and pedal trims.

The top-spec GT has the most noticeable bump in equipment, with the addition of adaptive suspension, 20-inch alloy wheels, a Brembo brake package, GT styling touches inside and out, ambient interior lighting, and sporty front seats with additional bolstering.

The issue the Mach-E faces, then, is not range or standard equipment. It is simply not offered in a form which is as competitive with price-leading versions of its core rivals.

Of course, most anticipated vehicles like this are picked up primarily in high-grade forms to begin with, Ford telling us nearly 40 per cent of pre-orders have been for the GT, but it’s notable there’s no circa-$70,000 entry-point variant as there is for the EV6, Ioniq 5, and Model Y.

Because the platform is (mostly) borrowed from the Transit Custom, you get the same driveline. That starts with a 2.0-litre turbo diesel, good for 125kW of power and a useful 390Nm of torque. It drives through a conventional eight-speed automatic transmission and then to the front wheels as a means of keeping the load floor as flat and low as possible.

Ford claims a 2500kg towing capacity with a braked trailer, but on a wet road or damp boat ramp, that’s really going to test the limits of the front wheel’s grip which can be overcome even in the dry if you’re too hasty with the throttle.

The biggest engineering change in the move from Transit Custom to Tourneo has been the switch from leaf springs on the former to coil springs and an independent suspension on the latter. This is all in the name of ride quality and recognises the fact that the Transit will often be called on to cart heavier loads than eight humans.

The Mach-E might not look like a traditional Mustang, but don’t be fooled, it’s no ordinary mid-size SUV on the performance front.

Even in its most basic trim level, the Mach-E puts out 198kW/430Nm, and yes, it’s rear-wheel drive.

The mid-grade version boosts power even further to 216kW/430Nm, while the top-spec GT nearly doubles outputs to 358kW/860Nm thanks to its dual-motor, all-wheel drive system.

Sprint times are a hot-hatch baiting 6.6 seconds for the base Select, 6.2 seconds for the Premium and an impressive 3.7 seconds for the GT.

The GT scores other enhancements, too, like the 'MagneRide' suspension also seen in the internal-combustion Mustang, and upgraded software unlocking the sportiest ‘Untame Plus’ drive mode which Ford says is ‘for track use only’ (and it is, because it basically turns traction control down to a minimum). 

Ford quotes an official combined fuel consumption figure of 7.4 litres for the Tourneo. Over a few days of running in a pretty broad mix of urban and country work, we saw an average of 8.6 litres per 100km which is still pretty good for a vehicle of this size.

With the standard 70-litre fuel tank, that gives the Tourneo a theoretical combined range of around 900km between fills, but the real-world number says closer to 800km is more realistic.

Don’t forget, either, that running costs will be a little higher than some diesels, as the Tourneo requires AdBlue at regular intervals, in line with its Euro 6 emissions levels.

As mentioned, the three Mach-E variants have distinctly different range offerings. The base Select travels a respectable 470km between charges, the mid-grade Premium covers 600km (one of the longest ranges on offer from any EV currently in the Australian market) and the top-spec GT travels 490km between charges.

Interestingly, the base car is offered with the more affordable LFP (lithium-iron phosphate) battery chemistry for its 71kWh unit which uses less rare materials, sourced from China’s CATL, while the larger 91kWh batteries are sourced from Korea’s LG Chem using the higher output but more expensive NMC (nickel-manganese cobalt) chemistry.

On the efficiency front the Mach-E isn’t bad considering its performance, and size. The base Select is rated at 17.8kWh/100km on the combined cycle, while the number is lower for the Premium at 17.3kWh/100km, but hops up to a less-than-impressive 21.2kWh/100km for the all-wheel drive GT.

For reference, these official consumption figures are about on-par with the Ioniq 5 and a little lower than the EV6. It will be interesting to test this car’s range and efficiency figures at a later date, on a longer test.

If you haven’t driven a one-box van for a decade or more, you’re in for a treat. Just like the Transit Custom on which this car is based, the Tourneo represents a different experience to that of a conventional car or SUV, but one that is not without merit.

For a start, you sit very high which means a great view out across the traffic. And while the driving position is a little less laid-back than a modern car, once you get used to the almost square steering wheel, neither is it the dreaded sit-up-and-beg of older van designs.

The four-cylinder engine doesn’t make the Tourneo a fast vehicle, but it does give it lots of flexibility thanks to all that turbo-torque being available from just off idle. The eight-speed transmission helps, too, but the real surprise is just how quiet the Tourneo is when on a cruising setting. In fact, it’s almost uncanny how such a big, empty metal box could be so silent, but beyond a little tyre noise on coarse surfaces, the Ford pulls it off. As a result, it’s very relaxed and effortless feeling at freeway speeds.

The other surprise is how good the ride quality is. By swapping the cargo van’s leaf rear springs for coils, the Tourneo suddenly displays a very good match between the front and rear axles in terms of how they work to absorb bumps. You do still get some of the front-seat sensation that you’re sitting over the front axle, but it’s not terrible and the reality is that you simply sitting closer to the axle, not right over it.

For many drivers perhaps the over-riding impression will be of the vehicle’s external size. And, yes, it’s a long and wide piece of equipment, but at least the boxy shape means the corners are easy to place and the huge glass area and driver aids like parking sensors and blind-spot warnings help a lot in the daily cut and thrust.

Things are also improved by the fabulously small turning circle of 10.9m kerb-to-kerb (courtesy of the Transit’s role as an inner-city delivery van) that gives an agility the looks don’t suggest. But there’s a sense that the Tourneo is a little wider in the rear track than the front, as you’ll sometimes find the inside rear tyre finding the lips of roundabouts and suburban gutters.

Let’s make one thing clear. The Mach-E does not drive like a Mustang. A Mustang, of course, being characterized primarily by its brash V8 roar, gratuitous cabin and grand touring dynamics.

No, the Mach-E immediately reminds me of a Ford Europe SUV. Sounds like an insult doesn’t it? But it isn’t.

The Escape and Puma are remarkably sharp to drive, and I consider them deeply underrated options in the SUV space, and more suited to drivers than they first appear. 

The Mach-E takes the best elements of these two and dials it up to 11, adding the smoothness of an electric powertrain and inherent rear-wheel drive performance characteristics as it does.

While it saddles you with a tall SUV-like seating position, it’s no simple SUV once you get it on a few curves, the urgent performance from the rear-mounted motor, even in the base car, is excellent, feeling as though it punches above many of its rivals, while the sharp, accurate steering makes it feel surprisingly agile and responsive considering its dimensions and weight.

The regenerative braking is well-calibrated, too, offered in either a one-pedal or more moderate tune, but perhaps the most surprising aspect of this car is its well balanced ride.

Reviews from my colleagues overseas pointed to an overly hard ride, which I was expecting, but I was greeted with a car that deals with bumps, undulations, and corrugations with a remarkable amount of poise.

Ford says what it calls the “Irish tune” was selected as it offered the best ride for our roads, and it seems the Blue Oval engineers weren’t wrong.

It’s a firmer ride than the boaty Hyundai Ioniq 5, but not as firmly sprung as the Polestar 2 or Tesla Model Y.

In other words, it’s firm enough to make it fun to drive, but not hard enough to ruin it in your day-to-day commute.

It was also interesting to find the MangeRide adaptive suspension in the GT grade didn’t make as big a difference as expected, firming things up a little on some surfaces, but offering a slight edge to the amount of chassis control on offer as a result.

The three drive modes also make a significant difference to the experience. The ‘Whisper’ mode dials back accelerator response and artificial noise, serving as a kind of ‘eco’ setting which is said to also be more suited to low-traction scenarios, where the instant torque of the electric motors can easily spin the wheels.

The standard mode is far more balanced, while the 'Untame' mode makes the motors respond in haste, and dials up the artificial rumbling noise, but not to an unpleasant level.

The fourth, ‘Untame Plus’ mode, only available on the top-spec GT, allows the car to, for example, break into a drift when grip is low enough by dialling back the traction control.

It’s designed to allow a little more play and maximise acceleration response for track use. Still, it doesn’t feel as tail-happy as its namesake combustion coupe.

While it appears to be yet another mid-size electric EV, then, there’s something a little more on offer here, and something which sets itself apart from the electric pack by being fun to drive in a way something like a Tesla Model Y isn’t.

The best part is, these unusually engaging dynamics extend beyond the top-spec GT, all the way to the base Select.

The only thing is, it’s still very tidy. It’s organised, the traction control is clever, the chassis is sharp, the steering is brilliant and the electric motors are… inorganic.

In some ways, this car is too good to be a Mustang, certainly missing some of the edge-of-your seat chaos a V8 rear-driven coupe can bring.

So, long as you understand this, there’s a very compelling sporty electric SUV to be found here.

All Mach-E variants get the same set of modern active safety equipment including auto emergency braking at freeway speeds, lane keep assist, blind-spot monitoring and rear cross-traffic alert. It also scores a 360-degree parking camera and reverse auto braking.

Adaptive cruise control features (although not the semi-autonomous ‘BlueCruise’ offered in this car’s American version), alongside a healthy suite of airbags.

Only the Select and Premium grades are rated a maximum five ANCAP stars, with the GT excluded.

Ford offers its standard five-year/unlimited kilometre warranty on the Tourneo. Five years is fair enough, but can’t match the seven years or even more that some of the competition offer. It‘s worth noting, however, that the warranty does match many of the makes and models that will be the Ford’s natural enemies.

Service intervals are 12 months or a very long 30,000km, but it’s unlikely many families will clock up 30,000km in a 12-month period, anyway. There’s no word on capped-price servicing yet, but the mechanically similar Transit Custom has a service plan that limits the cost of each of the first four services to around $500.

The biggest additional running cost for the Tourneo will be the AdBlue additive to control emissions. How frequently you need to top up will be determined by what type of driving you do.

Ford offers a now industry standard five-year, unlimited kilometre warranty, as well as the battery manufacturer standard eight-years and 160,000km for the high-voltage components.

Unlike some EVs in this space which push intervals out to two years, the Mach-E needs to see a workshop once every year or 15,000km, whichever occurs first.

Thankfully, servicing is relatively affordable, at just $135 or $180 at alternating years for the first 10 years, and roadside assist is automatically topped up with each service (at an authorised Ford dealer) up to seven years.