Ford Tourneo Custom vs Toyota GR Corolla

What's the difference?

There’s absolutely no doubt that the van-based people-mover has some distinct advantages over a three-row SUV. The rear seat is bigger, access to it is far better and there’s more luggage space even when all eight seats are occupied. But the Tourneo goes a step or two further with the sliding, swivelling seats that make it one of the most practical and flexible interiors on the market.

True, the driving experience is a bit alien at first, but it’s a case of different, rather than worse. Meantime, the ride is excellent and the performance and economy from the turbo-diesel driveline are both absolutely spot on for this vehicle’s intended purpose.

And perhaps that’s the metaphor for the whole thing: By not trying to be something it’s not, and concentrating on what it needs to do, the Tourneo emerges as a bit of a quiet achiever.

As we said earlier, this type of vehicle concept is never a sure-fire proposition. Parcel vans converted to passenger duties haven’t always worked out. This time, though, it’s different.

The GR Corolla had a lot to live up to before, given the likes of the GR Yaris and GR86 fit their briefs so well.

Now, with a little more daily useability and a little more performance, the GR Corolla is even better at both sides of its Jekyl and Hyde personality.

Note: CarsGuide attended this event as a guest of the manufacturer, with accommodation and meals provided.

Perhaps the biggest revision of the successful Transit Custom formula needed to make the leap from FedEx to Brady Bunch has been to the rear suspension. Where the Transit uses a leaf-sprung arrangement, the Tourneo has switched to coil rear springs. These technically offer much greater ride comfort at the expense of some load-carrying ability. Which is fine, even if your kids are the bigger variety.

The move to powered sliding side doors is a welcome one, but I found out the hard way that the doors will still open a fraction if you push the button while still travelling at low speed. Not sure why that would be, but at least the buttons in question are up front in Adult-Land, not within reach of you-know-who.

The reality is, too, that the Tourneo is destined to run with the air-con on any time you have bodes in the back. That’s because – like a lot of van conversions – there’s no opening side windows beyond the tiny, hinged windows that open an equally tiny amount. This has more to do with the Transit’s basic structure than any desire to oxygen-deprive the young `uns, but as any parent knows, a supply of fresh air on the move is sometimes the only thing between a happy day out and a clean up in Aisle five.

The Corolla already looks more sporting than most hatchbacks even before the GR treatment, but a few tweaks up front, some wider wheel arches and a third exhaust exit at the back have this thing looking almost ready for a rallycross.

The only downside to that is the changes are relatively minor from some angles. If you weren’t aware of the GR version, you'd need to see the GR Corolla from the front or spot that exhaust to know something was up.

The update has, however, ushered in a change at the front bumper, where the air intakes have been adjusted for improved airflow “to the radiator, intercooler, brake ducts, sub radiator and automatic transmission fluid cooler”

In part, this was necessary to help cool the new automatic gearbox, though it does generally help with overall cooling.

While the GR Corolla looks the part, there’s more function to it. The air that passes in through the side intakes at the front is vented to a duct in the wheel arch that also cools the brakes.

It’s the same as the GR Yaris sibling in terms of the philosophy behind aerodynamics and cooling in many ways, though much of the Yaris is bespoke, where on the Corolla, parts have been attached to the standard body.

Like the outside, the inside of the GR Corolla is mostly the same bones as its non-hot-hatch relatives, but the aforementioned sports seats, leather trim and aluminium pedals are all fairly strong hints this isn’t quite ‘hire car spec’.

Here’s where a vehicle like this stands or falls. Because if something like a Tourneo can’t cope with lots of people and their luggage in a single bound, then there’s really not much point to it, is there? I mean you’re not going to buy it for its sporty looks or supercar dynamics, so unless it works brilliantly as family transport, it’s kind of dead in the water. Fortunately Ford seems to have got it right. Mostly, anyway.

That starts up front where the two front seats feel like they’re metres apart. In reality, this huge gap forms a walk-through function for getting access to anything or anyone misbehaving in the second or third row of chairs. But you can’t help wondering what if… What if Ford had ditched the stubby centre console and added a third front-row seat? Wouldn’t a nine-seater be better than eight?

But the seats themselves are comfy and the high-and-mighty driving position gives plenty of vision in every direction. With one exception. And that is when you’re pulling out of a side street on to a main road and need to see what’s coming from the left. Depending on the angle you’re on, the fat frame of the pop-out side window (in the sliding door) becomes a blind spot, especially for taller drivers.

There’s nothing irretrievably wrong with the way the controls are laid out, but they will take some acclimatisation. That goes for the menu system on the touchscreen as well as the column-mounted shifter wand which is about the same size and shape (and in the same place) as a conventional indicator stalk. Tip the lever accidentally and you’ll wind up in neutral, wondering what just happened. The manual-shift mode is also fiddly to use and paddle sifters would be vastly better. Most won’t bother anyway.

The front cabin is home to a shallow lidded bin in the centre console, a deeper bin below that and a couple of charge points. There are also cup-holders in great spots up high in the corner of the dashboard, a shelf across the top of the dashboard and no less than two gloveboxes (the top one is pretty shallow) thanks to moving the passenger’s airbag into the roof lining. Both front doors also feature bins and storage nooks but there’s a fair bit of hard plastic on show, surely a legacy of the Tourneo’s parcel-van DNA.

The Tourneo’s party trick is the way both the second and third rows of seats can be slid to almost any point on a pair of tracks in the floor. The move is simply accomplished via a lever at the front or a rip-cord in the back of the seats, and all three centre-row seats can be moved individually (the third row is split 60:40). The upshot is that you can have all three rows bunched together for a large luggage space, or the rear row pushed right back to form a rear row with huge legroom. Don’t need all eight seats? How about a second row with the two outside chairs in place and the centre one folded forward to expose a work-surface with built-in cupholders.

But it gets even better, because individual seats can be removed to suit the weirdest of loads and the second-row seats even swivel 180-degrees to form a loungeroom on wheels. The kids will be begging you to take them for a drive in this thing.

The seats fold forward, but they don’t tumble. They don’t need to really, and they don’t fold into a bed either. But if you fancy camping in the Tourneo, you can remove both rows of rear seats for a huge flat floor.

The second row is home to storage bins in each sliding door (yes, a door on each side) a pop-put window that opens only about 40mm, temperature controls, air vents and reading lights. The third row, meantime, is not only easily accessed provided the second row isn’t slid all the way back (at which point you wouldn’t be using the third row anyway) but the good news is that the rearmost seat itself is basically three bucket seats with the same comfort levels (high) as the second row. There are also reading lights and a pair of phone pockets and cup-holders in the last row, too. Only the way the track system works and the shape of the seat base means that foot-room is limited to an extent.

With all three rows in place, but pushed as far forward as they can go, there’s a long load area of up to 725mm. But you can also push the second and third rows all the way back and have a cargo area 2622mm long behind the front seats. Maybe the van DNA is a good thing after all.

With all eight seats in place, there’s a minimum of 673 litres of luggage space which can be expanded all the way to a monster 4683 litres with the second and third rows removed.

There’s also a 12-volt power socket and a lighting system in the back, too, although while the side doors are automatic, the tailgate is manual. And you’ll need plenty of real estate to open it, too. Even tall folk will hit the button to open the tailgate, start the strut-assisted opening and then take a step or two back to allow the huge tailgate to rise without clobbering them. An automatic tailgate where you hit the button and run away to a safe distance would be much nicer.

As far as hatchbacks to build a daily-useable hot hatch upon go, the Corolla is a relatively solid starting point in terms of ergonomics.

Physical buttons and controls for things like climate are within reach for most functions of the car, though the multimedia touchscreen itself isn’t the most up-to-date.

The seats are comfortable but hold you firmly in place, and the steering wheel, pedals, and shifter are all in the correct positions for engaging driving - particularly important in the manual version.

The storage space is where the GR Corolla disappoints a little. There’s door card space for a water bottle, cupholders, the wireless device charger, but not really anywhere for larger items.

Behind the front row, adults will find themselves a little cramped in terms of kneeroom, while dark interior materials make the second row feel poorly lit.

Further back in the Corolla is the 213-litre boot, which is pretty small even for a hatchback, although Toyota lists a maximum 503 litres with the seats folded down.

Under the boot floor is a tyre repair kit, rather than a spare tyre. Keep that in mind if undertaking a road trip.

The 2025 Toyota GR Corolla comes in just one grade now, the highly-speced GTS, which starts from $67,990 plus on-road costs for the six-speed manual, but it's now available with an eight-speed automatic for $70,490.

Sounds like a lot for a Corolla, and it’s a little more than the $64,190 asking price the GTS manual wore before, but compare it to the highly-regarded Honda Civic Type R ($74,100) or the do-it-all VW Golf R ($70,590) and it lines up.

While the GTS has plenty of features for the price, they’re not all focused on the comfort of the interior.

For example, the synthetic leather and suede sports seats are manually adjustable, even though they are heated.

The 8.0-inch multimedia touchscreen is similar to that in the standard Corolla, too, plus dual-zone climate, USB-C ports, the wireless phone charger and JBL Audio system are all expected features of a hatchback at more than $60,000.

The GR Corolla does however gain heating for the leather-wrapped sports steering wheel, plus leather trim for the parking brake and shifter too. It also scores aluminium pedals.

There’s a lot more under the skin when it comes to the GR, some of which is visible via controls in the cabin, but we’ll come to that.

Because the platform is (mostly) borrowed from the Transit Custom, you get the same driveline. That starts with a 2.0-litre turbo diesel, good for 125kW of power and a useful 390Nm of torque. It drives through a conventional eight-speed automatic transmission and then to the front wheels as a means of keeping the load floor as flat and low as possible.

Ford claims a 2500kg towing capacity with a braked trailer, but on a wet road or damp boat ramp, that’s really going to test the limits of the front wheel’s grip which can be overcome even in the dry if you’re too hasty with the throttle.

The biggest engineering change in the move from Transit Custom to Tourneo has been the switch from leaf springs on the former to coil springs and an independent suspension on the latter. This is all in the name of ride quality and recognises the fact that the Transit will often be called on to cart heavier loads than eight humans.

The GR Corolla’s 1.6-litre three-cylinder turbocharged petrol engine is now a little torquier than before, with outputs now 221kW (at 6500rpm) and 400Nm (between 3250 and 4600rpm) thanks to an extra 30Nm.

The G16E-GTS engine can now drive the Corolla’s four wheels through a choice of gearboxes, either the existing six-speed manual or an eight-speed torque converter automatic.

As well as the usual drive modes, Eco, Normal and Sport, the Corolla’s GR-Four all-wheel-drive system can split the torque to the front or rear wheels via its limited-slip diffs.

Normal, Track and Gravel modes can distribute drive either 60:40 front/rear in Normal, 53:47 in Gravel, or variably depending on conditions and need for acceleration in Track.

Toyota hasn't provided a 0-100km/h time for the 2025 GR Corolla in either variant, but the auto should knock it over in under five seconds, with the manual taking a little longer.

Ford quotes an official combined fuel consumption figure of 7.4 litres for the Tourneo. Over a few days of running in a pretty broad mix of urban and country work, we saw an average of 8.6 litres per 100km which is still pretty good for a vehicle of this size.

With the standard 70-litre fuel tank, that gives the Tourneo a theoretical combined range of around 900km between fills, but the real-world number says closer to 800km is more realistic.

Don’t forget, either, that running costs will be a little higher than some diesels, as the Tourneo requires AdBlue at regular intervals, in line with its Euro 6 emissions levels.

Toyota’s claimed fuel consumption for the GR Corolla with a manual gearbox hasn't changed from the previous 8.4L/100km, which isn’t bad for a sports car.

With the auto, Toyota says it burns through the fuel faster at a rate of 9.5L/100km.

In either case, the Corolla’s 50-litre fuel tank needs to be filled with premium 98 RON petrol, and theoretically could provide more than 500km of driving if conditions and your driving style are both perfect for efficiency.

Chances are, however, you’ll feel the need to put your right foot down a little harder than they did during WLTP testing, if for no other reason than to hear the turbo flutter when you lift off.

If you haven’t driven a one-box van for a decade or more, you’re in for a treat. Just like the Transit Custom on which this car is based, the Tourneo represents a different experience to that of a conventional car or SUV, but one that is not without merit.

For a start, you sit very high which means a great view out across the traffic. And while the driving position is a little less laid-back than a modern car, once you get used to the almost square steering wheel, neither is it the dreaded sit-up-and-beg of older van designs.

The four-cylinder engine doesn’t make the Tourneo a fast vehicle, but it does give it lots of flexibility thanks to all that turbo-torque being available from just off idle. The eight-speed transmission helps, too, but the real surprise is just how quiet the Tourneo is when on a cruising setting. In fact, it’s almost uncanny how such a big, empty metal box could be so silent, but beyond a little tyre noise on coarse surfaces, the Ford pulls it off. As a result, it’s very relaxed and effortless feeling at freeway speeds.

The other surprise is how good the ride quality is. By swapping the cargo van’s leaf rear springs for coils, the Tourneo suddenly displays a very good match between the front and rear axles in terms of how they work to absorb bumps. You do still get some of the front-seat sensation that you’re sitting over the front axle, but it’s not terrible and the reality is that you simply sitting closer to the axle, not right over it.

For many drivers perhaps the over-riding impression will be of the vehicle’s external size. And, yes, it’s a long and wide piece of equipment, but at least the boxy shape means the corners are easy to place and the huge glass area and driver aids like parking sensors and blind-spot warnings help a lot in the daily cut and thrust.

Things are also improved by the fabulously small turning circle of 10.9m kerb-to-kerb (courtesy of the Transit’s role as an inner-city delivery van) that gives an agility the looks don’t suggest. But there’s a sense that the Tourneo is a little wider in the rear track than the front, as you’ll sometimes find the inside rear tyre finding the lips of roundabouts and suburban gutters.

The GR Corolla isn’t as engaging to drive as the GR Yaris, it’s not as honed as one particular rival, the Honda Civic Type R, and it’s not as ‘nice’ as the Golf R.

But the GR Corolla is still an excellent car to drive, and it’s better for its update. In fact, the two major gripes I had with the pre-facelift car have been addressed.

I was in a unique position to be able to compare the old and new versions of the GR Corolla as I drove a MY 2024 version a week prior to the media launch for the 2025 model.

The first and probably biggest issue I had was that the Corolla’s suspension seemed like it must have been rather stiff and the body bracing quite rigid for a car riding on 19-inch wheels to let that much road noise and that many harsh bumps into the cabin.

Though it wasn’t mentioned before the on-road drive loop, the car felt more compliant without sacrificing ability and seemed much more suited to daily duties.

Toyota’s product team confirmed there had been tweaks made to the rear suspension geometry and that I wasn’t just imagining it.

The second issue is more for the sake of passengers who may be less agreeable to the three-pot thrum resonating along the exhaust underfloor.

Toyota has solved this by putting a slight mute on the pipes in the Eco drive mode, so the car is now just ‘a bit’ lairy rather than full boy racer.

Generally, it’s hard not to compare the GR Corolla to the smaller (but original) GR hatch, the Yaris. Especially having driven them back-to-back at the media launch.

Without leaning too much on that, I will say that while the Yaris feels like a rally car that's been modified to be road-legal, the Corolla feels more like a road car that was tweaked for rallying.

The Corolla stops just short of being too ‘raw’ for everyday use in most aspects, but it’s still very capable when it comes to driving fast. 

Like its suspension, the steering feel is dialled in for feedback without being too rough, and allows you to corner accurately without feeling like you need to second-guess or adjust inputs.

When it comes to handling, it doesn’t feel like the Corolla is entirely leaning on the Yokohama Advan tyres for grip, as it feels tied-down and doesn’t pitch and roll through corners.

The duality of the GR Corolla is helped by its drive mode and differential settings and even on track can help you lean into your own driving style.

While the rear-biased 30:70 setting previously made for a slightly tail-happy hot hatch, the new variable Track setting does a fabulous job of keeping the drive where it needs to be, though it turns out it’s also rather handy for sliding the Corolla around a wet skid pan.

Another neat trick is the GR’s handbrake, same as the Yaris, which can disconnect the rear diff when engaged so you don’t need to dip the clutch pedal in the manual version when indulging in handbrake turns.

It will set you back to 2WD mode when the drivetrain overheats, however, or at least when its sensors suspect the drivetrain has overheated - something that only happened after a lot of handbrake turning and spinning wheels as the hatchback slid sideways.

The Corolla’s brakes are ventilated 356mm front and 297mm rear discs, and doesn't lose stopping power even after plenty of tight, twisting road driving where the brakes and the sticky Yokohama Advan tyres copped a workout.

The new auto transmission is also a delight. It's calm during normal driving but snappy with shifts in Sport mode and set to manual gear selection. It won’t really cooperate on a rapid drive of its own accord.

The only criticism of the auto gearbox (aside from being less engaging than the manual, but that’s your own choice) is that the shift paddles behind the wheel feel a little plasticky, but I’m nitpicking at this point.

The Corolla’s not lacking in safety kit, with a healthy list of passive and active features as well as a series of seven airbags and three ISOFIX points along the rear seats.

ANCAP tested the non-GR Corolla in 2018 and awarded it five stars, though that score is now outdated. It’s not clear if the car’s updated tech would manage five stars again, though the car is clearly structurally sound.

Aside from the usual expectations like auto emergency braking (AEB), a blind spot monitor, parking sensors front and rear plus a decent reversing camera, the GR Corolla also has rear cross-traffic alert and Toyota’s ‘Safety Sense’ suite of active kit.

That includes a pre-collision safety system with pedestrian detection and cyclist detection in daylight, active cruise, intersection assist, emergency steering assist, lane departure and lane-trace assist, road sign detection for speed limits and auto high beam.

Ford offers its standard five-year/unlimited kilometre warranty on the Tourneo. Five years is fair enough, but can’t match the seven years or even more that some of the competition offer. It‘s worth noting, however, that the warranty does match many of the makes and models that will be the Ford’s natural enemies.

Service intervals are 12 months or a very long 30,000km, but it’s unlikely many families will clock up 30,000km in a 12-month period, anyway. There’s no word on capped-price servicing yet, but the mechanically similar Transit Custom has a service plan that limits the cost of each of the first four services to around $500.

The biggest additional running cost for the Tourneo will be the AdBlue additive to control emissions. How frequently you need to top up will be determined by what type of driving you do.

Toyota offers a five-year/unlimited kilometre warranty plus an extra two-year warranty on the GR Corolla’s engine and driveline.

There’s also a capped price on the first three years of servicing for the GR Corolla at $310 per service.

The downside to the servicing arrangement is that intervals are six months or 10,000km, whichever comes first. That's more regular than a usual schedule and it means potentially pricier servicing for the seventh visit onwards.