Toyota Fortuner vs Chery Tiggo 8 PRO MAX

What's the difference?

The Toyota Fortuner is a family friendly wagon and a very capable 4WD, but it’s looking and feeling decidedly old, especially when cross-shopped against the current highly competitive 4WD wagon market in which vehicles are increasingly stylish, sophisticated and packed with driver-assist tech (that isn't clunky) and standard features (that are extensive).

The Fortuner is practical and easy to live with as a daily driver, and in GXL spec it makes a lot of sense as a functional not flashy off-road tourer, but it’s far from the best family 4WD wagon around.

Until a next-generation Fortuner possibly arrives, there are plenty of Toyota fans who’d happily settle for a current Fortuner – if they haven’t already.

This mid-sized seven-seat SUV segment is dominated by just a handful of nameplates, and it’s easy to see how some of them might be under threat by something like the Chery Tiggo 8 Pro Max.

There are a few areas where it could use some fine-tuning, but these are mainly restricted to being pedantic about the drive experience. There are no dealbreakers here as there often can be for low-cost alternatives, and so long as you’re primarily putting kids in the back seats, this Tiggo is well equipped, comfortable, plush, and surprisingly refined.

With a robust ownership proposition as well, it’s hard to see why you wouldn’t consider one of these if you’re shopping in the seven-seat SUV space - and that's why this could be Chery's shot at the big leagues.

The GXL is 4795mm long with a 2745mm wheelbase. It is 1855mm wide, 1835mm high and has a listed kerb weight of 2185kg. It has a 11.6m turning circle.

Not a lot has changed in terms of the Fortuner’s looks over the years and while it stubbornly retains that pleasingly non-offensive exterior of most modern SUVs, it does manage to not be totally bland.

The GXL is a body-on-frame 4WD based the HiLux, so it’s no sports car in appearance whether you gaze at it from the front, side, rear or from a bird’s eye view, but it doesn’t look like a block of rotten wood, so unless you’re looks-obsessed, then you should be okay driving this around.

The Fortuner interior is looking dated and the standard dark grey fabric cloth seats, though well-suited to coping with day-to-day messes and spills, don’t do the cabin any favours either, and – you know what? – I don’t mind any of it. Note our test vehicle on this occasion had black leather-accented seats as part of its GXL Option Pack, but I've spent time in cloth-seat Fortuners.

The Tiggo 8 Pro Max just looks like a mid-size SUV. Perhaps if you calculated the average design cues of every mid-size SUV on the market, this would be what you end up with.

Of all the Chinese automakers currently in the market though, the Tiggo range of SUVs are the least controversial. There’s no weird theme to the design, there’s no bizarre light fittings or controversial angles. You could stick a badge on this car from any Korean or Japanese brand and you wouldn’t think twice about it.

It doesn’t say much for innovation, but I think it will very much work in this car's favour. It provides a much more globally appealing look when compared to the controversial design of BYD products, the crazy grilles and badging on GWM products, or the derivative style of the MG range.

For this reason it won’t turn heads at the school drop-off, but that’s perfect for families who want to run incognito and would normally buy a conservative mainstream SUV from Toyota or Mitsubishi.

Inside things get a bit more interesting. The Tiggo 8 has a contemporary design, complete with a high-riding bridge-style console, and the dual-screens are encased in a single housing that spans half the length of the dash.

It’s ambitious too, with generous amounts of soft-touch surfaces and synthetic leather finishes. Clearly, it’s inspired by others in the industry. The dual-screen layout is very Hyundai or Kia via Mercedes, while the Benz influence extends to the wood grain-look plastic inserts and even the little silver finishes covering the speakers up. Rather than a naff knock-off though, the Chery interior genuinely feels its own space.

The only areas that you can see through the facade to a car built-to-a price is in a handful of places. The steering wheel buttons, for instance, feel a bit cheap, and when it comes to those big screens, the resolution isn’t as high as you might expect, and the processing isn’t as fast as it could be, leading to a slightly laggy experience.

Still, the same can be said for many mainstream manufacturers, and at least Chery’s native software has been localised and is easy to navigate. Also, none of this stops the Chery from feeling properly plush on the inside. It was also seemingly pretty well put together, free of rattles, switchgear with too much play, or nasty hollow plastics.

First impressions are good.

The Fortuner’s cabin has a comfortably familiar feel to it and, thankfully, this interior is all about function not fashion.

It’s a practical space, with standard cloth seats (as mentioned our test vehicle has the Option Pack leather-accented seats, but I’ve spent enough drive time in Fortuners with cloth seats to know how those cope with the mess and dirt of everyday life), carpet floors with rubber mats, and durable plastic surfaces everywhere.

Up front, there’s an 8.0-inch multimedia screen (too small, not clear and bright enough) and that system has USB-connected Apple CarPlay and Android Auto (no wireless anything), and a 4.2-inch colour driver’s display, which is too small, too basic and part of an outdated mix of analogue and not-new-enough digital instrumentation.

There are the usual storage spaces – including a glovebox, a centre console, a tray for your smartphone, pop-out cup-holders on the outboard edges of the dash – and a USB port and a 12V socket for charging purposes.

The Fortuner’s three rows are in a 2-3-2 seat configuration. The 60/40 split-fold second-row seat has a one-touch, tumble feature. The 50/50 third-row seats are able to be stowed away, sort of. When folded to each side they protrude into the load space, reducing the size of what would otherwise be a more useable cargo area.

It’s reasonably comfortable in the second row; I sat behind my driving position and I had adequate head and knee room.

The second row has cup holders in the fold-down armrest, ceiling-mounted controls for the aircon, and two ISOFIX and three top-tether anchor points.

All three rows get aircon – with ceiling-mounted vents – and there are a few storage spaces in the third row, but no cup-holders. 

In terms of comfort, it’s ordinary back here; the seats are flat and unsupportive – and, for anyone other than children, the space is tight. 

Boot space is listed as 200 litres with the third-row seats in use, and in that area there are cargo hooks and a 12V socket.

Stow away the third-row and cargo space increases to 716 litres. But the seats still jut into the cargo area, greatly reducing your actual useable load space, and they also obscure a lot of driver vision to the rear.

With the second and third rows out of the way you have a listed 1080L of cargo area.

The interior is also thoughtfully designed, but it needs to compete with user-friendly cars like the Honda CR-V and Nissan X-Trail in this segment.

The front occupants are treated to a reasonably spacious cabin, which for the driver is quite adjustable, although the design of the dash means it sticks out into the front passenger’s knee area. Head and shoulder space is impressive, and everywhere you put your arms or knees there’s a soft-clad finish rather than hard plastic to greet you.

As already mentioned, the software isn’t half bad when it comes to ease-of-use, however the lack of tactile toggles or dials for the climate unit is a bit of a miss. It has its own dedicated set of touch controls below the screen itself, but they provide no tactile feedback, so are a little hard to use while on the move.

Storage is great, with large pockets and bottle-holders in the doors, a further two bottle holders in the centre console, a wireless phone charger, and a neat little set of drive mode buttons and a digital shift lever within easy reach.

The bridge-style console also offers a large pass-through area underneath for the storage of larger items, and there’s a deep centre armrest console box, too.

The second row is quite versatile, offering rail adjustment for the base, so you can maximise the room available to the third row if need be.

Second-row occupants (with the seats set to a decent position for myself at 182cm tall) have plenty of knee room and plenty of headroom, and the doors open nice and wide for the loading of objects or people.

Storage includes large pockets on the backs of the front seats, a bottle holder in each door, and a further two in the drop-down armrest. There is a set of adjustable air vents on the back of the centre console, with both a USB-A and USB-C port for power delivery.

The third row is a bit more challenging. I had to contort myself to get in with the second row seat either slid forward or folded flat. Once I was in there, I was surprised to find I fit, but only just.

My knees were hard up against the seat in front, while my head was touching the roof. Mercifully, I had enough room to slide my feet under the seat in front, otherwise it would’ve been too tight. It’s passable for adults then, but only in a pinch, and you wouldn’t want to be back there for long. No problem if you’re just putting kids back there though.

The third row gets air vents on either side with an independent fan speed controller on the mid-grade Elite and top-spec Ultimate, and there’s a useful storage tray, and small bottle holder on each side. You don’t get USB ports, but there’s a 12 volt outlet available just behind the rear seats in the boot.

On the topic of the boot, it is not as large as I was hoping, but then neither is the car itself.

The boot measures 479 litres with the second-row up, or just 117-litres with all seven seats deployed. It’s smaller than some mid-size rivals, but not enough for it to be a dealbreaker. We’ll get it back for a longer test to see what does and does not fit.

The floor is quite high to facilitate those fold-flat rear seats, and there’s a small under-floor storage tray where you can hide the retractable luggage cover on the Urban and Elite variants. Unfortunately the Ultimate gets a subwoofer here.

All variants get a space-saver spare wheel mounted outside underneath the car, so at least you don’t need to deal with a tyre repair kit.

The Tiggo 8 Pro Max needs to be keenly priced to compete, but you might be surprised to find it’s not the most affordable option in this category. For slightly less money than the Tiggo 8 Pro Max, you can get into the Mahindra XUV700 or the LDV D90, but Chery says it is aiming to provide a little more than just a low price-tag.

Still, thanks to its keen national drive-away prices, the Tiggo 8 does manage to undercut its prominent Japanese competition. The price starts from $41,990 for the base Urban, moves to $43,990 for the mid-grade Elite, and tops out at $47,990 for the all-wheel drive Ultimate.

If you’ve been shopping around this space, you’ll note these prices, once you get the car on the road, will manage to undercut the likes of the Nissan X-Trail (from $40,290), Mitsubishi Outlander (from $39,540) and the Honda CR-V (from $46,800).

Keep in mind that this is very much a mid-size SUV offering too. At 4720mm long, 1860mm wide, and 1705mm tall, the Tiggo 8 Pro Max isn’t competing with the Hyundai Santa Fe, Toyota Kluger, or Kia Sorento, which are seven-seaters in the medium-to-large segment a full category up.

Like other Chinese challenger brands, Chery aims to dazzle on the specification front. Even the base Urban scores a comprehensive list of standard inclusions like 18-inch alloy wheels, LED headlights, synthetic leather interior trim, dual 12.3-inch screens in the cabin, as well as relative luxuries usually unheard of in base cars like heated and ventilated front seats with power adjust, a 360-degree parking camera, and wireless phone chargers.

You also score an eight-speaker audio system, an air purification system, dual-zone climate, keyless entry with push-start ignition, built-in navigation, a voice command system, power folding exterior mirrors, and ambient LED multi-colour interior lighting.

It’s a lot of stuff for a base car, and yet the Elite manages to add a power tailgate, heated exterior mirrors, a built-in dash-cam (nice touch), third-row air vents with independent fan speed control, illuminated door sills and a retractable cargo blind.

Finally, the top-spec Ultimate scores all-wheel drive with additional drive modes, 19-inch alloy wheels, a panoramic sunroof, a 10-speaker Sony-branded audio system, tinted rear windows, puddle lamps, and the option to choose an alternate brown theme for the synthetic leather interior trim.

All variants get all the active safety equipment - check out the full list in the safety section of this review.

Every Fortuner in the line-up has a 2.8-litre four-cylinder turbo-diesel engine – producing 150kW and 500Nm – and that’s matched to a six-speed automatic transmission.

In terms of performance, the Fortuner is not going to set any hearts a-flutter: it’s sluggish off the mark, it takes a heavy right boot to make it feel like anything other than lacklustre on the move, and the six-speed auto downshifts quite harshly at times, especially when going up or down long, gradual inclines on the highway.

However, the 4WD set-up is effective, with adequate low-range gearing, a quietly efficient (but a tad clunky) off-road traction control system, and a rear diff lock.

There is only one engine option in the Tiggo 8 Pro Max range, a 2.0-litre turbocharged four-cylinder petrol unit that produces 180kW/375Nm.

No matter which variant you choose, it’s also mated to a seven-speed dual-clutch automatic transmission. The Urban and Elite variants are front-wheel drive, while the Ultimate scores a Borg-Warner-sourced all-wheel-drive system with additional off-road drive modes.

The outputs are more than competitive with a lot of rivals, but there’s no fuel-saving hybrid option in the line-up just yet. It’s something Chery wants to add in the future.

Especially for Australia, the folks at Chery also made sure to get the Tiggo 8 Pro Max certified to tow. It can do that at up to 1300kg braked, or 750kg unbraked.

The Fortuner has official fuel consumption of 7.6L/100km.

On this test I recorded 9.6L/100km.

Going by my on-test fuel figure, you could reasonably expect a driving range of about 833km from this Fortuner’s full 80-litre tank.

The 2.0-litre turbo engine has an official/combined consumption rating of 8.1L/100km for the front-wheel drive variants, or 8.7L/100km for the all-wheel drive Ultimate.

On our drive route for the day which took place on curvy country roads and expressways, my Ultimate all-wheel-drive test example produced a figure of 9.5L/100km which seems reasonable.

Unfortunately the engine also requires mid-shelf 95RON unleaded fuel, so this will push your running costs up slightly.

The Tiggo 8 Pro Max has a 57-litre fuel tank, indicating an estimated maximum cruising range of 703km for FWD variants.

On-road, the Fortuner offers up a pretty standard driving experience for a ute-based wagon. It’s on the HiLux ladder-frame chassis, and it has a firm ride, bordering on harsh. Having said that, you do get used to it soon enough and the Fortuner's coil-spring suspension set-up takes most of the sting out of surface irregularities, except for the more severe dips and bumps.

The Fortuner’s driving position offers plenty of visibility – although the A-pillars are bulky and the third-row seats block vision to the rear when they’re folded up to the sides of the cabin.

This 4WD wagon is generally quiet, although there’s noticeable wind-rush noise around the wing mirrors and engine noise builds to a diesel shriek when you use a heavy right boot as is regularly required.

Steering – reach- and rake-adjustable – is adequately light and sharp, and the Fortuner, with its 11.6m turning circle, is reasonably nimble in suburban areas.

Acceleration, from a standing-start or for overtaking, is laggy but available power and torque come in handy during general driving, making the Fortuner more agreeable all-round than previous versions.

The six-speed auto is generally right for the job, but it downshifts harshly, especially when going up or down long, gradually sloping highway stretches. That happens enough for it to be on the wrong side of annoying.

Some aspects of the Fortuner’s driver-assist tech is annoying: active cruise control is too abrupt and pre-emptive, consistently miscalculating the space between the Fortuner and the vehicle in front as accurately as most of its rivals. This clunky application of tech to real-world scenarios works against the Fortuner. 

While driving a lightly corrugated and rutted dirt track o the way to our set-piece off-road tests, the Fortuner’s ladder-frame chassis yielded a stiff, firm ride, bashing and bouncing over any and all surface imperfections. Airing down the Yokohama Geolandar ATs (265/65R17) from 38 psi (pounds per square inch) to 26 psi takes some sting out of the ride.

The Fortuner is a very capable 4WD with standard off-road measurements, including ground clearance (216mm), approach angle (29 degrees), departure angle (25 degrees) and rampover angle (23.5 degrees). It has a listed wading depth of 700mm.

The Fortuner’s switchable part-time 4WD system has two-wheel drive (H2), and high- (H4) and low-range (L4) four-wheel drive. There’s ample low-end torque on offer – on tap across a broad rev range – for controlled low-speed 4WDing and the unfussed turbo-diesel engine keeps the Fortuner ticking along, without any hassle. 

Engine braking is good, keeping the Fortuner to a sustained and composed momentum on downhill runs.

The off-road traction control system is an effective set-up, limiting wheel-spin and sending much-needed torque to the tyres with some useable traction, with the aim to keep the vehicle moving along at a safe, controlled pace.

Besides that, the driver always has the option of engaging the rear diff lock for more traction action.

Wheel travel is decent for a wagon like this and if you can get the full suspension flex, and drop any mid-air tyres to the dirt for more traction, chances are you’ll be able to get moving along safely soon enough.

So, the mechanicals are fine – its 4WD set-up is very effective – but the Fortuner doesn’t have a whole lot of ground clearance (a claimed 216mm, standard for a contemporary 4WD wagon) and the side steps are prone to hitting on the edges of steep and deep ruts, but those factors are easily overcome through considered driving and tyres that are better suited to off-roading. 

The standard Yokohama Geolandar AT tyres are somewhat of a flaw in the Fortuner’s off-roading set-up. Sure, they’re technically all-terrains, but I reckon a better bet for you – if you’re planning to drive anything beyond formed trails – is to invest in a set of more aggressive all-terrains with greater sidewall bite. 

If you’re planning to use your Fortuner to tow anything, keep in mind that it has a 750kg unbraked towing capacity and 3100kg braked towing capacity. Remember: to be on the safe side, avoid going loading up to anywhere near those capacity figures.

Payload is 615kg (easily reached when you factor in people, pets, camping gear and more), gross vehicle is (GVM) is 2800kg, and gross combined mass (GCM) is 5900kg.

Cars from Chinese brands often fall short of expectations when it comes to the drive experience, but the Tiggo 8 Pro Max moves everything in the right direction, and importantly it doesn’t add any deal-breaking characteristics along the way.

Visibility is great out of the cabin, with large windows all-round. The wing mirrors are great, but the centre rear-vision mirror is a quirky piece with a wide viewing angle. In a way this is great for parents, because with one glance you can see both out the rear of the vehicle and the rear seats to keep an eye on kids, but it does mess with your depth perception a bit.

On multiple occasions I felt like the car behind was tailgating, only to peer in the side mirrors to find that it was actually quite far back. Odd!

The steering is very light, and a bit disconnected as a result. While this sounds like a negative, I actually think suburban buyers who often negotiate with shopping centre parking lots, apartment towers, and school drop-offs will love it. It makes a big SUV feel really easy to steer and position.

Sure, it feels a bit doughy out on the open road, meaning it's hardly a confident corner-carver, but that’s not really the point of this car.

The engine on the other hand has loads of poke. Power of 180kW sounds like a lot because it is (once upon a time not so long ago this was well into V6 territory) and actually for the front-wheel-drive versions it might be a little bit too much power. It will readily spin the front wheels with slightly too much throttle input, which brings us nicely to the dual-clutch automatic which is responsible for communicating that power to the ground.

Dual clutches rightly raise a bit of a red flag for some because they can be particularly jerky from a standstill and have some pretty questionable gear shifts once you’re rolling. For the most part though, the Tiggo 8’s dual-clutch unit is pretty good. The brand stressed that it had done significant software tuning to this transmission to try to iron out nasty characteristics, and while it's still occasionally caught off-guard, I’ve certainly driven worse. It will occasionally produce a bucking feeling rather than a full second of lag like some rivals, but its enthusiasm to deliver power to the ground quickly gives the front-drive versions that slightly skittish feel.

It is one of those rare occasions when it’s worth splashing for the all-wheel drive. I found the Ultimate to be much more sure-footed and confident on the road, able to handle the engine’s relatively mountainous torque with ease.

On the open road I was impressed by the Tiggo 8’s level of refinement. The amount of sound entering the cabin in both variants was low, with minimal tyre roar or wind noise. Thuds from the suspension and roar from the engine under load were also pleasingly distant, even at freeway speeds.

When it comes to the ride it’s built to a certain cadence. It’s soft and comfortable, matching the semi-luxurious cabin feel nicely, but it can be a bit springy and lose a bit of body control over undulations and corrugations. Again, it’s not exactly an athlete, but then for most people, it won’t have to be.

Importantly, it filters out sharper bumps like potholes, road imperfections, and speed bumps with relative ease. It’s even better in the 2WD versions thanks to larger tyres and smaller alloy wheels.

Mercifully, the active safety systems don’t intrude on the driving experience either. Chery has apparently learned some hard lessons after the feedback it received on the overbearing lane assist equipment on the smaller Omoda 5, and applied those learnings here in the Tiggo 8.

The lane systems are still there, but they only intervene when they really have to, while warning chimes from things like the traffic sign recognition, blind spot monitoring, and driver attention alert are, at worst, background. It’s a good thing too because of all the systems, the driver attention alert is the one that triggers most often as you look away from the road to adjust the touch-based climate systems.

Where does that leave us? Actually pretty impressed. The Tiggo 8 Pro Max might not have the balancing act between ride quality and performance quite as well tuned as some of its Japanese and Korean rivals, but this is a comfortable, quiet, and refined SUV that, importantly, feels very normal. There’s no deal-breaking safety bugs, or a terrible transmission or frustrating software that takes away from the experience. Chery is learning, and it’s learning fast.

Every Tiggo 8 Pro Max gets the full array of active safety gear, including auto emergency braking, lane keep assist with lane departure warning, blind spot monitoring with rear cross-traffic alert and rear auto braking, traffic sign recognition, driver attention alert, and adaptive cruise control with traffic jam assist.

It also scores the expected array of traction and brake controls, as well as a 360-degree parking camera, and dual ISOFIX positions on the outboard rear seats.

The airbag total seems to come to 10 with dual front, dual curtain, quad side, a front centre airbag, and a knee airbag, although from what we can tell the curtain and side airbag coverage unfortunately still doesn’t manage to extend the full length of the third row. Worth keeping in mind if you plan on regularly putting people back there.

At the time of writing the Tiggo 8 Pro Max was yet to get an ANCAP safety rating.

A five-year/unlimited kilometre warranty covers the Fortuner, which is par for the course these days.

If you stick to the relatively short servicing schedule – six months or 10,000km with at authorised dealerships – Toyota says it will cover the engine and driveline for up to seven years. All warranty elements are subject to terms and conditions, so make sure you’re fully aware of those.

Capped-price servicing applies and, for our test vehicle, it was $290 per appointment for the first five, then $377.38, $813.93, $572.55, $478.93 and $377.38.

Chery offers its line-up with seven years and unlimited kilometres of warranty, seven-years of capped-price servicing, and seven years of roadside assist.

The roadside assist is topped up on a 12 monthly basis so long as you service with Chery. At the time of writing, Chery was yet to provide costings for its capped-price servicing program, but if it follows the same scheme as the Omoda 5 and Tiggo 7, it will be competitive.