Peugeot Expert vs Toyota GR Corolla

What's the difference?

Positives are higher payload and tow ratings than the Toyota HiAce along with superior fuel economy. Negatives are inferior safety, evidence of questionable build quality and a list price more than $3000 above a HiAce equivalent. So, whether the positives outweigh the negatives to justify its higher price, only a potential buyer can decide.

The GR Corolla had a lot to live up to before, given the likes of the GR Yaris and GR86 fit their briefs so well.

Now, with a little more daily useability and a little more performance, the GR Corolla is even better at both sides of its Jekyl and Hyde personality.

Note: CarsGuide attended this event as a guest of the manufacturer, with accommodation and meals provided.

Our 'Long' example rides on a 3275mm wheelbase with 5309mm overall length, 1920mm width and 1948mm height, so compared to the HiAce it's slightly longer in wheelbase and overall length but narrower and not as tall. It’s also significantly lighter with a kerb weight that’s almost 500kg (or half a tonne) less than the Toyota; a big factor in its spirited performance and superior payload rating.

The Peugeot’s front-wheel drive underpinnings include MacPherson strut front suspension, coil spring semi-trailing arm rear suspension, rack and pinion steering and four-wheel disc brakes. Its 12.4-metre turning circle is also more than a metre larger than the HiAce.

The Pro’s work focus can be seen in its black plastic front and rear bumpers and side mouldings where most scrapes and dents occur in hard-working vans. There’s matching black on other high-wear surfaces like the door mirrors, door handles, hubcaps, rear wipers and rego plate shroud.

The cabin has seating for three with a driver’s bucket seat and separate two-passenger bench seat. Although all occupants have ample headroom, the dashboard’s protruding centre console leaves little legroom. In fact, the centre passenger must travel with both knees skewed to the left of this extension, which then encroaches on the outer passenger’s legroom. So, for a crew of three we’d recommend short trips. Our only other criticism was the lower dash panel on the passenger’s side, which kept popping loose despite repeated attempts to click it back into place.

The Corolla already looks more sporting than most hatchbacks even before the GR treatment, but a few tweaks up front, some wider wheel arches and a third exhaust exit at the back have this thing looking almost ready for a rallycross.

The only downside to that is the changes are relatively minor from some angles. If you weren’t aware of the GR version, you'd need to see the GR Corolla from the front or spot that exhaust to know something was up.

The update has, however, ushered in a change at the front bumper, where the air intakes have been adjusted for improved airflow “to the radiator, intercooler, brake ducts, sub radiator and automatic transmission fluid cooler”

In part, this was necessary to help cool the new automatic gearbox, though it does generally help with overall cooling.

While the GR Corolla looks the part, there’s more function to it. The air that passes in through the side intakes at the front is vented to a duct in the wheel arch that also cools the brakes.

It’s the same as the GR Yaris sibling in terms of the philosophy behind aerodynamics and cooling in many ways, though much of the Yaris is bespoke, where on the Corolla, parts have been attached to the standard body.

Like the outside, the inside of the GR Corolla is mostly the same bones as its non-hot-hatch relatives, but the aforementioned sports seats, leather trim and aluminium pedals are all fairly strong hints this isn’t quite ‘hire car spec’.

Its relatively light 1743kg kerb weight combined with a 3100kg GVM allows for a sizeable 1357kg payload that’s almost 300kg more than the HiAce. It’s rated to tow up to 1800kg of braked trailer, which is also 300kg more than the Toyota. And with its 4900kg GCM, the Expert can legally tow its maximum trailer weight while carrying its maximum payload. These are excellent numbers for a multitude of working roles.

The cargo bay and cabin are separated by a stout steel bulkhead, which insulates the cabin from tyre noise emanating from the rear wheel housings and doubles as a cargo barrier. Its central window provides vision for the rear-view mirror and the ability to check on loads.

Lined to mid-height, the Expert’s cargo bay is accessed through large sliding doors on each side with handy 935mm-wide openings, while rear access is through glazed barn-doors which open to 180-degrees to aid forklift access. Each is equipped with its own windscreen wiper and demister.

The load floor is 2780mm long and 1628mm wide with 1258mm between the wheel housings, so it can carry up to three 1200 x 800mm Euro pallets or two 1165mm-square Aussie pallets, held in place by a total of eight floor-mounted load anchorage points. The 6.1 cubic metres of load volume splits hairs with the HiAce’s 6.2 cubic metres.

Cabin storage starts with a cavernous bin in the base of each front door that can easily hold a big 1.5-litre bottle and lots more. Each door also has two other compartments for smaller items. The dash-pad has a cup holder at each end and there’s a shrouded storage compartment in the centre. There are also two small storage nooks near the gearshift dial, plus on the passenger side is a glovebox and additional storage compartment (with 12V accessory plug inside).

The bench seat’s hinged base cushion also tilts forward to reveal two large storage bins below, with one thoughtfully lined with polystyrene foam to keep items either hot or cold.

As far as hatchbacks to build a daily-useable hot hatch upon go, the Corolla is a relatively solid starting point in terms of ergonomics.

Physical buttons and controls for things like climate are within reach for most functions of the car, though the multimedia touchscreen itself isn’t the most up-to-date.

The seats are comfortable but hold you firmly in place, and the steering wheel, pedals, and shifter are all in the correct positions for engaging driving - particularly important in the manual version.

The storage space is where the GR Corolla disappoints a little. There’s door card space for a water bottle, cupholders, the wireless device charger, but not really anywhere for larger items.

Behind the front row, adults will find themselves a little cramped in terms of kneeroom, while dark interior materials make the second row feel poorly lit.

Further back in the Corolla is the 213-litre boot, which is pretty small even for a hatchback, although Toyota lists a maximum 503 litres with the seats folded down.

Under the boot floor is a tyre repair kit, rather than a spare tyre. Keep that in mind if undertaking a road trip.

The 2025 Toyota GR Corolla comes in just one grade now, the highly-speced GTS, which starts from $67,990 plus on-road costs for the six-speed manual, but it's now available with an eight-speed automatic for $70,490.

Sounds like a lot for a Corolla, and it’s a little more than the $64,190 asking price the GTS manual wore before, but compare it to the highly-regarded Honda Civic Type R ($74,100) or the do-it-all VW Golf R ($70,590) and it lines up.

While the GTS has plenty of features for the price, they’re not all focused on the comfort of the interior.

For example, the synthetic leather and suede sports seats are manually adjustable, even though they are heated.

The 8.0-inch multimedia touchscreen is similar to that in the standard Corolla, too, plus dual-zone climate, USB-C ports, the wireless phone charger and JBL Audio system are all expected features of a hatchback at more than $60,000.

The GR Corolla does however gain heating for the leather-wrapped sports steering wheel, plus leather trim for the parking brake and shifter too. It also scores aluminium pedals.

There’s a lot more under the skin when it comes to the GR, some of which is visible via controls in the cabin, but we’ll come to that.

The Expert’s punchy 2.0-litre four-cylinder diesel is one of its strengths. Turbocharged and intercooled, it has Euro 5 emissions compliance and produces 110kW at 4000rpm and 370Nm at 2000rpm. The eight-speed torque converter automatic has near-seamless shifting and offers the choice of sequential manual-shifting using steering wheel paddle-shifters.

The GR Corolla’s 1.6-litre three-cylinder turbocharged petrol engine is now a little torquier than before, with outputs now 221kW (at 6500rpm) and 400Nm (between 3250 and 4600rpm) thanks to an extra 30Nm.

The G16E-GTS engine can now drive the Corolla’s four wheels through a choice of gearboxes, either the existing six-speed manual or an eight-speed torque converter automatic.

As well as the usual drive modes, Eco, Normal and Sport, the Corolla’s GR-Four all-wheel-drive system can split the torque to the front or rear wheels via its limited-slip diffs.

Normal, Track and Gravel modes can distribute drive either 60:40 front/rear in Normal, 53:47 in Gravel, or variably depending on conditions and need for acceleration in Track.

Toyota hasn't provided a 0-100km/h time for the 2025 GR Corolla in either variant, but the auto should knock it over in under five seconds, with the manual taking a little longer.

Peugeot claims a combined average consumption of 6.3L/100km and the dash display was close to that at 7.6L after 386km of testing, which included about one third of that distance carrying a full payload. Our own figure calculated from fuel bowser and tripmeter readings came in higher again at 8.3L/100km, which is still outstanding economy for a vehicle of this size. So, based on our numbers, you could expect an extensive driving range from its 70-litre tank of around 840km.

Toyota’s claimed fuel consumption for the GR Corolla with a manual gearbox hasn't changed from the previous 8.4L/100km, which isn’t bad for a sports car.

With the auto, Toyota says it burns through the fuel faster at a rate of 9.5L/100km.

In either case, the Corolla’s 50-litre fuel tank needs to be filled with premium 98 RON petrol, and theoretically could provide more than 500km of driving if conditions and your driving style are both perfect for efficiency.

Chances are, however, you’ll feel the need to put your right foot down a little harder than they did during WLTP testing, if for no other reason than to hear the turbo flutter when you lift off.

It has a comfortable driving position as the steering wheel is adjustable for height and reach, the bucket seat has a fold-down inboard armrest and there’s a prominent left footrest. Although the driver’s seat base has no rake adjustment, it’s long enough to provide good under-thigh support with enough rake to avoid sliding towards the front of it like some rivals.

The steering is responsive and nicely weighted, which combined with competent handling and braking makes the Expert feel sure-footed. The supple four-coil suspension provides a smooth unladen ride quality.

The energetic drivetrain with its 370Nm of torque has spirited acceleration and good agility in traffic. Although peak torque is at 2000rpm, the 2.0-litre turbo-diesel pulls cleanly from 1500rpm which showcases its flexibility.

The eight-speed automatic gets good results from this engine, but sequential manual-shifting using the paddle-shifters is handy when more driver input is required. The cabin is acceptably quiet at highway speeds, thanks to the cabin bulkhead and low tyre, engine and wind noise.

Our only major criticism is the absence of blind-spot monitoring and rear cross-traffic alert. In our opinion every van, particularly with solid side-walls and doors like this one, should at least have these active safety features as standard (like the HiAce which also has standard front parking sensors).

The Expert’s relatively small mirror on the passenger door is not sufficient in eliminating the large and potentially hazardous blind-spot over the driver’s left shoulder, particularly in heavy traffic and when reversing from driveways into busy streets.

The GR Corolla isn’t as engaging to drive as the GR Yaris, it’s not as honed as one particular rival, the Honda Civic Type R, and it’s not as ‘nice’ as the Golf R.

But the GR Corolla is still an excellent car to drive, and it’s better for its update. In fact, the two major gripes I had with the pre-facelift car have been addressed.

I was in a unique position to be able to compare the old and new versions of the GR Corolla as I drove a MY 2024 version a week prior to the media launch for the 2025 model.

The first and probably biggest issue I had was that the Corolla’s suspension seemed like it must have been rather stiff and the body bracing quite rigid for a car riding on 19-inch wheels to let that much road noise and that many harsh bumps into the cabin.

Though it wasn’t mentioned before the on-road drive loop, the car felt more compliant without sacrificing ability and seemed much more suited to daily duties.

Toyota’s product team confirmed there had been tweaks made to the rear suspension geometry and that I wasn’t just imagining it.

The second issue is more for the sake of passengers who may be less agreeable to the three-pot thrum resonating along the exhaust underfloor.

Toyota has solved this by putting a slight mute on the pipes in the Eco drive mode, so the car is now just ‘a bit’ lairy rather than full boy racer.

Generally, it’s hard not to compare the GR Corolla to the smaller (but original) GR hatch, the Yaris. Especially having driven them back-to-back at the media launch.

Without leaning too much on that, I will say that while the Yaris feels like a rally car that's been modified to be road-legal, the Corolla feels more like a road car that was tweaked for rallying.

The Corolla stops just short of being too ‘raw’ for everyday use in most aspects, but it’s still very capable when it comes to driving fast. 

Like its suspension, the steering feel is dialled in for feedback without being too rough, and allows you to corner accurately without feeling like you need to second-guess or adjust inputs.

When it comes to handling, it doesn’t feel like the Corolla is entirely leaning on the Yokohama Advan tyres for grip, as it feels tied-down and doesn’t pitch and roll through corners.

The duality of the GR Corolla is helped by its drive mode and differential settings and even on track can help you lean into your own driving style.

While the rear-biased 30:70 setting previously made for a slightly tail-happy hot hatch, the new variable Track setting does a fabulous job of keeping the drive where it needs to be, though it turns out it’s also rather handy for sliding the Corolla around a wet skid pan.

Another neat trick is the GR’s handbrake, same as the Yaris, which can disconnect the rear diff when engaged so you don’t need to dip the clutch pedal in the manual version when indulging in handbrake turns.

It will set you back to 2WD mode when the drivetrain overheats, however, or at least when its sensors suspect the drivetrain has overheated - something that only happened after a lot of handbrake turning and spinning wheels as the hatchback slid sideways.

The Corolla’s brakes are ventilated 356mm front and 297mm rear discs, and doesn't lose stopping power even after plenty of tight, twisting road driving where the brakes and the sticky Yokohama Advan tyres copped a workout.

The new auto transmission is also a delight. It's calm during normal driving but snappy with shifts in Sport mode and set to manual gear selection. It won’t really cooperate on a rapid drive of its own accord.

The only criticism of the auto gearbox (aside from being less engaging than the manual, but that’s your own choice) is that the shift paddles behind the wheel feel a little plasticky, but I’m nitpicking at this point.

The Corolla’s not lacking in safety kit, with a healthy list of passive and active features as well as a series of seven airbags and three ISOFIX points along the rear seats.

ANCAP tested the non-GR Corolla in 2018 and awarded it five stars, though that score is now outdated. It’s not clear if the car’s updated tech would manage five stars again, though the car is clearly structurally sound.

Aside from the usual expectations like auto emergency braking (AEB), a blind spot monitor, parking sensors front and rear plus a decent reversing camera, the GR Corolla also has rear cross-traffic alert and Toyota’s ‘Safety Sense’ suite of active kit.

That includes a pre-collision safety system with pedestrian detection and cyclist detection in daylight, active cruise, intersection assist, emergency steering assist, lane departure and lane-trace assist, road sign detection for speed limits and auto high beam.

The Expert is covered by a five years/200,000km warranty. Scheduled servicing every 12 months/20,000km whichever occurs first. Five years of capped-price servicing totals $3049 or an average of $609.80 per year.

Toyota offers a five-year/unlimited kilometre warranty plus an extra two-year warranty on the GR Corolla’s engine and driveline.

There’s also a capped price on the first three years of servicing for the GR Corolla at $310 per service.

The downside to the servicing arrangement is that intervals are six months or 10,000km, whichever comes first. That's more regular than a usual schedule and it means potentially pricier servicing for the seventh visit onwards.