Peugeot Boxer vs Ford Transit Custom

What's the difference?

It has its faults like any vehicle but it’s a competent all-rounder, that combines sub-$50K pricing with a big payload capacity, mostly user-friendly design, improved safety and a compelling warranty. It also faces stiff competition in the 3501-8000kg GVM class, particularly from rivals with an automatic option. 

The Ford Transit Custom Trail has plenty of appeal as a work van or a camper fit-out candidate. It’s a well-packaged, comfortable and contemporary van that’s nice to drive and as a bonus, with all-wheel drive it’s given the scope of capability to be able to tackle mild off-roading situations with confidence.

It’s built for work and play and though it’s limited to two-up for travels, the Trail offers so much potential as a camper conversion for adventure seekers its few niggles are easily forgotten when you’re busy making memories.

It comes ready for work with hard-wearing black plastic in the most vulnerable places for scrapes and dents, including the front and rear bumpers and down the sides. The same black finish can be found on the window surrounds, door handles, huge door mirrors (which would not look out of place on a Kenworth) and the housing for the high-mounted third brake light.

It’s a large vehicle measuring 5413mm long, 2050mm wide and, thanks to the conspicuously high roof line, stands 2522mm tall. So, like numerous rivals in this weight class, it can’t access most shopping centre and underground carparks.

The front-wheel drive chassis, with its 3450mm wheelbase and 12.6-metre turning circle, features a simple and rugged combination of coil-spring strut front suspension, four-wheel disc brakes, power-assisted rack and pinion steering and single-leaf/solid beam rear suspension. Long rubber bump-stop cones, attached to the underfloor above each end of the rear axle, provide extra support when the springs compress under heavy loads.

The steel bulkhead, which separates the cabin from the cargo bay, insulates the driver/passenger from cargo bay noise and doubles as a robust cargo barrier. Its window is large enough to allow the driver to make a quick over-shoulder glance at any time to check the load is secure.

Criticisms? The relatively small 5.0-inch media screen can make the reversing camera’s vision difficult to see in detail. The height adjustment on the driver’s seat, using two levers on the lower right side, is clunky to operate. And although the rear barn-door windows are heated, there are no wiper/washers, which we didn’t get to test in wet conditions, which is most unusual for Melbourne.

It looks like a van but with some striking yet low-key flourishes that all kind of work as a whole. Those include a Trail grille and the matt black alloy wheels. The yellow sticker-pack is a neat touch.

The Trail has more presence than a regular Trend with its 30mm-taller raised suspension and overall adventure-ready look with strong front end and chunky wheel arches.

The striking but low-key theme continues inside with a neatly laid-out yet spartan cabin. The two synthetic leather seats are topped with Trail embossing and lined with yellow stitching.

The cabin is separated from the rear cargo area by a bulkhead, which incorporates a small wired window.

The Boxer 160’s 1865kg tare weight and 3510kg GVM results in a sizeable 1645kg payload rating. However, we always quote kerb weights (full tank of fuel) rather than tare weights (10 litres of fuel) to keep things consistent.

So, in this case, adding the missing 80 litres of diesel (67kg) results in a kerb weight of 1932kg, which reduces the payload by the same amount to 1578kg. That’s still almost 1.6 tonnes which is more than ample for this category. It's also rated to tow up to 2500kg of braked trailer and, based on European figures at least, can do this with a full payload.

The cargo bay provides a competitive 11.5 cubic metres of load volume and 10 sturdy load-anchorage points. Its floor, which is 3120mm long and 1870mm wide with 1420mm between the wheel housings, can  accommodate two 1165mm-square standard Aussie pallets or three 1200 x 800mm Euro pallets. There’s ample forklift access through the rear barn-doors with full 270-degree openings or sliding side doors with their big 1250mm openings.

The high roof cavity means even tall adults can stand inside with headroom to spare. It also provides a large and very useful open storage area over the driver’s cabin, which is ideal for storing ropes, straps, load-padding and any other gear a hard-working van might need.

Although the side doors and barn-doors are lined to mid-height, the cargo bay walls are unlined which leaves numerous cavities exposed that could make small items like pens, keys, phones etc disappear if they were dropped. The load floor is also unprotected.

Cabin storage options include upper and lower bins in each door, with the lower bins being wide and deep enough to hold several large bottles. There’s also a full-width map shelf that sits about forehead height for tall drivers, which is easy to access and can hold heaps of stuff.

The dashboard also has numerous storage choices including open shelves to the right of the steering column and underneath it, cup/small-bottle holders in the centre of the dash and on top a fixed clipboard with spring-loaded clamp. There’s also a glovebox with another large open storage bin below it plus even more storage, about the size of a baking tray, under the driver’s seat.

It’s a van so there are two distinct sections to the Trail, the cabin and the load space.

Firstly, the cabin. More a work-friendly than family-friendly interior, this Trail is a two-seater with plenty of durable plastic everywhere – ready for work and life – as well as charging (with USB-A and -C ports) and storage (including a van-favourite dash-top slot for logbooks etc, outboard moulded cupholders and a nifty pop-out cupholder), all amenities enough to cope with most daily van-related duties.

The seats are comfortable, supportive and have a fold-down lock-in-place armrest.

Now for the load space. There are no seats back there and as such it has plenty of potential as a work van or touring vehicle.

Access to the rear load space is via a barn door at the back and this Trail has a sliding door on both sides.

The cargo area is substantial – 3002mm long (to the bulkhead; 3450mm long if load-through hatch is used), 1392mm wide (between wheel arches) and 1425mm high (floor to roof). Easily big enough for work equipment or recreational gear. It can cope with four Euro pallets (each measuring 1200mm x 800mm) and it has a listed maximum load volume (with the bulkhead) of 6.8 cubic metres.

Load height through the rear barn doors is 531-585mm, depending on how much weight is already onboard.

The load space has the aforementioned metal bulkhead (with window and load-through hatch), load area protection kit (full height walls and moulded floor), LED lights and eight tie-down loops.

Otherwise, this is a load area ripe for customisation. Maybe a plethora of shelves for a tradie, or some bedding and extra storage for an adventurous person or couple.

The 2025.75Y Ford Transit Custom Trail has a MSRP of $61,990 (excluding on-road costs).

Standard features onboard include a 13-inch multimedia touchscreen (with wireless Apple CarPlay and Android Auto), a 12-inch digital instrument display and synthetic leather upholstery with Trail logos on the seats.

Other gear includes an eight-way manually adjustable driver’s seat, keyless entry and start, front and rear parking sensors, climate-control air and automatic LED headlights.

It also has all-wheel drive, LED headlights and daytime running lights, a variant-specific grille, black wheel arch moulding and side strip, yellow exterior decals and 16-inch matt black Trail twin-spoke alloy wheels.

The standard no-cost exterior paint is 'Frozen White'. Anything else – 'Agate Black Metallic', 'Grey Matter', 'Magnetic' or 'Moondust Silver' – will cost you $700.

The 2.0-litre Blue HDI four-cylinder turbo-diesel engine, which meets the toughest Euro 6 emissions standard using AdBlue, produces peak values of 120kW at 3500rpm and 310Nm of torque at 1500rpm.

Peugeot claims this engine was tested for more than 10,000 hours, subjected to more than 1.3 million km of drive-testing and 16,000 thermal shock cycles (cold starting and accelerations), corresponding to 15 years of intensive use. In short, it should be tough enough. Transmission is a sweet-shifting six-speed manual.

The Ford Transit Custom Trail has a 2.0-litre four-cylinder turbo-diesel engine producing 125kW at 3500rpm and 390Nm at 1750-2500rpm.

The Trail has a clever eight-speed automatic transmission and an on-demand all-wheel drive system.

It all works rather well, but it’s a van afterall and as such it is less dynamic and more dependably driveable than perhaps a cross-shopped SUV wagon. However, as an AWD van the Trail can be trusted to keep its grip on wet bitumen, soggy grass and loosely-gravelled tracks and that’s a strong part of its appeal over a 2WD van.

Peugeot’s official combined average is a fanciful 6.4L/100km. The dash readout was claiming a more realistic 9.0L/100km when we filled the tank after 282km of testing, which included more than a third of that distance lugging its maximum payload.

However, our own figure calculated from fuel bowser and tripmeter readings came in at 9.9L, which is more than 3.0L/100km above the official figure. Even so, sub-10L economy is very efficient  for a vehicle of this size, so based on our figures you could expect an excellent real-world driving range of around 900km from its big 90-litre tank.

The Ford Transit Custom Trail has an official combined cycle (urban/extra-urban) fuel consumption figure of 8.5L/100km. On this test I recorded 8.8L/100km.

The Trail has a 70-litre fuel tank so going by my on-test fuel figure you could reasonably expect a driving range of about 795km from a full tank of diesel. However, as with any vehicle, once you’ve loaded the Trail with real-world burdens (e.g kids, dogs, camping gear, etc) you’ll soon see that fuel consumption increase.

You sit up high with the huge windscreen providing a commanding view of the road ahead. Clear eye-lines to the large door mirrors (with wide-angle mirrors in their lower thirds) provide ample coverage of side and rear traffic.

Vision through the central rear-view mirror is also relatively clear compared to the cluttered views found in numerous rivals we’ve tested. The join of the barn-doors obscures the mirror’s central portion, but the driver still has a good view of what’s behind.

The fold-down inboard arm-rests combined with the door contours provide balanced support for arms and elbows to reduce strain on neck and shoulders. This support is particularly good for the driver, as it also allows your hands to rest comfortably on the steering wheel.

There’s negligible cargo bay noise thanks to the bulkhead. However, engine noise is noticeable and tyre noise can be quite intrusive, particularly at highway speeds on coarse bitumen surfaces. Cruising in top gear results in a fairly relaxed 2100rpm at 100km/h and 2300rpm at 110km/h.

The engine, with maximum torque at 1500rpm, has good all-round performance and pulling power under heavy loads, but lacks the sharper throttle response of some rivals. Even so, the manual gearshift has a light but well-defined action combined with a light clutch pedal weight.

Steering is nicely weighted and the quartet of disc brakes have plenty of bite. Handling and stability are also good regardless of load. The rear suspension tuning is commendable when running without loads on bumpy roads, providing a surprisingly smooth ride given spring rates that are designed to cope with 1.5 tonne-plus payloads.

Our only gripes are that the driver’s seat’s adjustable lumbar support presses too firmly against the spine for our liking, even on its softest setting. We also detected a couple of rattles and squeaks on bumpy roads, which sounded like they were coming from the dashboard area.

It’s easy to get in and out of the Trail’s driver seat with a wide-opening door and a big step to help you inside.

The seats are comfortable and it’s simple enough to dial-in your driving position via the tilt-and-reach adjustable steering wheel and manually-adjustable seat.

Word of warning: the auto transmission is operated via a stalk mounted on the right-hand side of the steering wheel column, which takes some getting used to.

Once underway, the Trail is punchy enough around town and in the suburbs with its 2.0L 'EcoBlue' turbo-diesel engine offering a more-than-adequate amount of power and torque (125kW and 390Nm) and its clever auto helping out with nifty moves through traffic (for a van, anyway).

Visibility is impressive from the cabin and you’re afforded a convenient vantage point with the Trail standing a bit taller than its regular Transit Custom stablemates as it’s on lifted suspension, but feeling composed on most surfaces.

The Trail has a listed kerb weight of 2046kg and a turning circle of 12.1m, pretty standard for a long wheelbase van, so this is not an insubstantial vehicle and it’s a bit tricky to 'flip a u-ee' if the situation demands it.

It has six drive modes – 'Normal', 'Eco', 'Slippery', 'Tow/Haul', 'Sport', 'Trail' – which each adjust engine torque, throttle response and traction control, among other things, to suit the road surface and conditions.

But we’re all here to see how it goes off-road, aren’t we?

Well, obviously this is no rock-crawling machine and it’s not intended to be. It’s best thought of as having an all-wheel drive system that gives this van mild off-road capabilities, as in it can tackle wet bitumen, soggy grass, lightly corrugated bush tracks and very shallow mud puddles with more confidence than the Transit Custom Trend it's based on.

In a nutshell, the AWD Trail will be able to handle most low-level traction-compromised scenarios. But it does not have enough ground clearance, wheel articulation, grip or underbody protection to tackle any terrain beyond modest off-roading.

Speaking of grip, the Trail as standard rides on Bridgestone Duravis R660 (215/65 R16) rubber, a van/light truck commercial tyre and they are not so well suited to dirt tracks and the like. Grippier all-terrain tyres would help this van perform slightly better off-road than on its showroom rubber.

In its favour, the Trail has a front skid plate and underbody protection in case it cops some knock from the ground during its adventures.

Not in its favour, however, especially as a potential touring vehicle, is the fact it has a space-saver spare wheel and tyre.

If you’re thinking of using your Trail as a tourer, it’s worth knowing payload is listed as 1179kg, maximum braked trailer towing capacity is 2500kg, Gross Vehicle Mass (GVM) is 3225kg and GCM is 5725kg.

The Ford Transit Custom was tested as part of ANCAP’s Commercial Van Safety Comparison in 2024 and received a Platinum score “achieving a near-perfect score in safety assessments”, according to ANCAP.

The Trail has all of the Custom’s driver-assist tech and safety features, including six airbags (driver, front passenger, front side curtain and front side seat), as well as AEB, adaptive cruise control (with stop and go), traffic sign recognition and lane centering, blind-spot monitoring and assist, rear cross-traffic alert, forward collision warning, hill launch assist, side wind stabilisation, front and rear parking sensors, a rear view camera (with 180-degree split view) and on-board tyre pressure monitoring.

The Boxer is covered by Peugeot's five years/200,000km warranty and scheduled service intervals of 12 months/20,000km, whichever occurs first. Capped-price servicing applies for the first five scheduled services with a total cost of $3445 valid until June 30, 2020.

Ford’s five-year/unlimited kilometre warranty applies to the Trail.

Servicing is set down for every 12 months or 30,000km and capped-price servicing is offered. Four scheduled services will set you back $2000 (including a brake fluid change at year three) which isn't over the top for a vehicle of this type.

Ford Australia has about 195 independent Ford dealers in Australia, with many located in metropolitan or suburban areas.