Mitsubishi Pajero Sport vs Isuzu NLR

What's the difference?

The Pajero Sport is reasonable on-road, more than satisfactory as a daily driver and it’s still a very effective 4WD.

This is a proven touring vehicle and while this update treatment doesn’t add a whole lot to the Pajero Sport package – and nothing in terms of power, torque or performance in general – it’s easily enough to tempt those who aren’t patient enough to wait for the next-generation version to arrive here.

Work out the weight of all the tools, equipment, materials, crew and (if applicable) trailer that you need to haul around each day and measure it against this truck’s formidable GVM and GCM ratings. When combined with its compact dimensions, robust design and build quality, solid warranty and ready-to-work pricing, you may find it’s hard to beat if you’re prepared to think outside the square on what a single cab-chassis ute can look like.

Most of the Pajero Sport’s latest round of upgrades is focused on styling refreshes, inside and out.

The upgraded interior in the GSR includes quilted two-tone burgundy and black synthetic leather upholstery.

This adds a welcome touch of understated class to an interior which is otherwise looking and feeling old.

The Pajero Sport now also has a three-spoke leather steering wheel and revised digital instrument display graphics, which may be difficult to discern for those unfamiliar with the previous renderings.

Outside, the GSR retains the distinctive Pajero Sport shape, albeit now with updated upper and lower grilles, front and rear bumper enhancements and black headlamp extensions (those are range-wide inclusions), as well as black door mirrors, door handles and tailgate handle.

This vehicle looks compact in comparison to a one-tonne ute - and the tape measure confirms it. Compared to a Ranger 4x4 dual cab ute for example, its 5020mm overall length is a surprising 339mm shorter, its 2490mm wheelbase is 730mm less and its 1855mm width is line-ball.

The Isuzu’s 2172mm height is 357mm taller, which could present a challenge if access to underground or multi-storey carparks is required. However, its remarkably small 8.7-metre turning circle is a whole 4.0 metres tighter than the Ranger, so it's highly maneuverable.

Built on a heavy-duty steel ladder-frame chassis, it has independent wishbone/coil spring front suspension, a leaf-spring live rear axle, power-assisted rack and pinion steering and four-wheel disc brakes. It also runs a 24-volt electrical system with twin batteries.

The single cab provides fabric-trimmed seating for up to three (driver bucket, passenger bench) but our test vehicle was fitted with seat covers from the Isuzu accessories range. With torsion bar assistance, the cab can be easily tilted forward to rest at a 45-degree angle and provide full access to the engine.

The service body, which is a blend of lightweight aluminium and steel, has a tough powder-coated finish. It comprises a large main storage compartment with big gull-wing doors on each side, plus a compact rear tray with checker-plate floor, drop-sides and load anchorage points. There are also rear underbody storage boxes on each side, plus sturdy body-mounted roof racks, safety yellow non-slip steps and sturdy grab handles front and rear.

The Pajero Sport cabin is practical, but now, as a result of the upgrade, it has more of a premium look and feel. Sure, it’s still on the wrong side of aged and it’s cramped, but at least it has a layer of gloss to it.

From front to back, it’s a well set-up space. The driver and front passenger seats (both power-adjustable) are very supportive, with a nice wrap-around feel to them. The other seats are also fine.

The reach- and height-adjustable steering wheel has paddle shifters for energetic shifting if you get the urge.

The dash and touchscreen media unit are nicely integrated, but that 8.0-inch screen is too small – and thankfully the likely introduction of a 9.0-inch screen in the 2025 Pajero Sport will sort out that issue.

The cabin’s familiar feel includes the fact that all buttons and dials are easy to locate and operate, even when you're bouncing around off-road.

The second row is comfortable and roomy enough, though the entire cabin tends towards the squeezy end of the spacious spectrum. Having said that, I slotted in behind my driving position and I had plenty of head, knee and foot room. 

There are three top tether points, two ISOFIX anchors and a fold-down armrest with cupholders in the second row. There are USB charge points and a power socket in the back of the centre console bin.

Third-row seating is a bit of a straight-up-and-down affair with a flat seat base, but passengers back there – god bless ’em – have access to cupholders and air vents.

In terms of packability, the Pajero Sport’s cabin, as mentioned, is quite narrow compared to most of its rivals and there are plenty of other SUVs and 4WD wagons around that offer more room inside for people, gear and dogs.

With the third-row seats in use, boot space is listed as 131L. There are power sockets and tie-down points in that rear cargo area. 

With the third row stowed away, there’s a claimed 502L of cargo space, which is pretty handy. With the second and third rows stowed, there’s a claimed 1488L.

With a hefty 2825kg tare weight and 4500kg GVM, the Isuzu has a big 1675kg payload rating. It’s also rated to tow up to 4000kg of braked trailer and with its sizeable 8000kg GCM, it can legally tow that weight with a 500kg reduction in payload. Or you can cap the towing weight at 3500kg and keep the full payload. Either way, these are substantial GVM and GCM ratings for any number of working roles.

In terms of cabin storage, there’s no glove box but both doors have narrow storage bins and there are overhead shelves with restraint netting to keep loose items in check. There’s also a pop-out dual bottle/cup holder in the centre dash along with two small storage nooks, but more places to store things would be welcome in this space.

Our test vehicle, to use its full model name, is the NLR 45-150 SWB AMT Servicepack X. It’s the most compact model in the N-Series range and as a result is similar (and in some cases much smaller) in key dimensions to a one-tonne ute. It only comes in one specification with 3.0-litre turbo-diesel, six-speed automated manual transmission (we’ll get to that) and dual-rear wheels, for a list price of $87,789.

In addition to its service body, this hard-worker comes standard with half a dozen 16-inch steel wheels, 195/75R16C Michelin tyres and a full-size spare. The single cab is well-equipped with useful features like keyless entry with central locking of cab and service body, big door mirrors with power adjustment, heating and lower wide-angle view, driver’s bucket seat with mechanical suspension and weight adjustment up to 130kg, two-way adjustable steering column, cruise control and bright LED interior lighting. Also standard is a 4000kg-rated tow-bar, reversing camera, loud reversing alarm and door-mounted cornering lamps.

There’s also an infotainment system with smallish 6.2-inch control screen and DAB+ radio. Even though there’s no Apple CarPlay or Android Auto, it has multiple connectivity including internet radio via smartphone, external camera inputs, navigation, reversing sensors and tyre pressure monitoring. The driver also gets a multi-information display and there’s plenty of the latest safety tech headlined by AEB.

The Pajero Sport has a 2.4-litre, four-cylinder, turbo-diesel engine producing 133kW at 3500rpm and 430Nm at 2500rpm – and that’s matched to a eight-speed automatic transmission.

This is a solid but lacklustre combination – it’s agricultural, truck-like and it takes a heavy right foot to punch it off the mark. But overall, I don’t mind the driving experience.

This is a respectable and well-proven combination, more than a bit sluggish and far from dynamic, but it does the job. 

The GSR has Mitsubishi’s 'Super Select II' 4WD (a full-time 4WD system), selectable off-road modes and a rear diff lock.

The Super Select dial is positioned at the rear of the shifter and enables the driver to switch from '2H' (two-wheel drive), '4H' (4WD high-range), '4HLc' (4WD High Range with locked centre diff) and '4LLc' (4WD Low Range with locked centre diff).

The driver is able to safely switch between 2WD (2H) and 4WD (4H, 4HLc) at speeds of up to 100km/h.

The GSR has a button-operated off-road mode system – with 'Gravel', 'Mud/Snow', 'Sand' or 'Rock' settings, each of which tweaks engine output, transmission settings and traction control to best suit the terrain. It also features hill descent control. 

The 2025 Pajero Sport will have the new Triton’s twin-turbo four-cylinder diesel engine (producing 150kW and 470Nm) and it’ll be paired with an eight-speed auto.

Isuzu’s 4JJ1-TCS 3.0-litre four-cylinder turbo-diesel is closely related to the 4JJ3-TCX in the current D-Max ute and MU-X wagon. Tuned for hard work and long life, it produces 110kW at 2800rpm and 375Nm across a 1200rpm-wide torque band between 1600-2800rpm. It’s also equipped with a vacuum-controlled exhaust brake which can be switched on or off.

Isuzu’s MYY-6E is a six-speed fully-automated manual transmission, which may sound like a contradiction in terms, However, like the engine, it's designed for a long service life under continuous heavy loads. It uses an electro/hydraulically controlled wet clutch and lock-up torque converter to provide either fully automatic or clutch-less manual shifting. There’s also slow/fast gear engagement control, first gear start (for heavy loads) and normal or economy drive modes.

A handy power take-off (PTO) facility can drive numerous on-site implements, with drive coming from a counter gear on the left-hand side of the transmission case.

The Pajero Sport has an official fuel consumption figure of 8.0L/100km on a combined (urban/extra-urban) cycle.

I recorded 9.8L/100km on this test. I did a lot of high- and low-range 4WDing and the Pajero Sport was never working hard.

The Pajero Sport has a 68L fuel tank, so, going by my on-test fuel-consumption figure, you could reasonably expect a driving range of about 694km from a full tank. 

Average combined fuel consumption figures are not required for commercial vehicles in this weight division. Even so, the dash display was claiming 13.2L/100km at the end of our 295km test which included about one third of that distance hauling a heavy payload. So, based on those figures you could expect a real-world driving range of around 570km from its 75-litre tank.

There have been no power, torque or driver-assist tech changes to this upgraded Pajero Sport – you’ll have to wait for the next-gen version for those – so no surprises lay in wait when driving.

But that’s okay, because the Pajero Sport in its current guise is a solid daily driver – not spectacular, but far from atrocious.

The Pajero Sport is 4840mm long (with a 2800mm wheelbase), 1815mm wide, 1835mm high and has a kerb weight of 2130kg.

Compared to other similarly-sized 4WD wagons, the Pajero Sport is narrower and has a higher centre of gravity, so it’s nimble – the turning circle is a respectable 11.2m – but it also feels a bit floaty on roads and tracks, but not despicably so.

The Pajero Sport is reasonable on sealed surfaces, although it is sluggish, noisy and there’s quite a lot of body-roll through sharp turns, especially compared to some of its more refined rivals, such as the Ford Everest.

But it is a very capable off-roader, mostly because the driver has access to a raft of technical advantages engineered into the Pajero Sport aimed at making 4WDing a safer challenge.

One of the major points of difference it has with its rivals is Super Select II 4WD. You can switch, via a dial to the rear of the auto shifter, from 2H into 4H (four-wheel drive, high-range), if you're not already driving with 4H engaged, and that gives you the best traction possible in low-grip conditions, which you may face on rough back-roads and dirt tracks peppered with loose rocks and potholes.

There's no risk of transmission wind-up because the centre diff is open when 4H is engaged in the Pajero Sport, so Super Select II 4WD adds an extra element of safety and sure-footedness to your driving experience.

Then turn the dial to 4HLc (four-wheel drive, high-range, locked centre diff) and you're ready to take on more difficult terrain but at lower speeds, because the centre diff is no longer open.

If you want to tackle even harder stuff than high-range territory, turn the dial to 4LLc (four-wheel drive, low-range, locked centre diff) and the Pajero Sport has an opportunity to excel in low-speed, low-range four-wheel driving.

Turn the dial to 4HLc and you're ready to take on more difficult terrain but at lower speeds.

So, along with decent high- and low-range gearing and a centre diff-lock – activated when 4HLc (4WD high-range, locked centre diff) or 4LLc (4WD low-range, locked centre diff) is selected – the Pajero Sport has a rear diff lock, which is engaged/disengaged via a button in front of the shifter and this further help you to easily maintain safe forward momentum.

Hill descent control sustains a controlled low speed of 3.0-4.0km/h all the way down steeper, longer hills.

The GSR also has selectable off-road modes, including Gravel, Sand, Mud/Snow (when in high-range 4WD) and Rock (when in low-range 4WD).

Each of these modes adjusts engine output, transmission settings and braking, the aim being the acquisition of superior traction to suit specific conditions and terrains. 

The Pajero Sport is riding on Toyo Open Country A32 all-terrains (265/60R18 110H), which are decent tyres, but it would perform even better with more aggressive rubber.

Wheel travel is adequate, ground clearance (218mm) is reasonable, although you still have to mind your driving line through rough terrain and be mindful of this 4WD’s approach (30 degrees), departure (24.2) and ramp-over (23.1) angles. Wading depth is listed as 700mm.

While it’s never been regarded as a tow rig in the same vein as something like the Toyota LandCruiser or the Nissan Patrol, the Pajero Sport offers sensible claimed towing capacities of 750kg (unbraked) and 3100kg (braked).

Payload is listed as 645kg (so about standard for this size 4WD wagon), gross vehicle mass (GVM) is 2775kg and gross combined mass (GCM) is 5565kg.

The doors open 90 degrees for easy access and there are decent boot-sized steps plus big handles on the windscreen pillars to help you climb aboard.

It’s a different driving position to a ute, as you sit high above the engine with your feet ahead of the front wheels and hands on a bus-style flat steering wheel. There’s also a big left footrest with lots of open floor around it, so there’s ample space to rest your foot given there’s no clutch pedal.

The suspension seat can be easily adjusted to suit a driver’s weight and works well in providing a more comfortable ride. The seat’s base cushion has no rake adjustment but there is some movement available in the backrest. Large glass areas deliver a commanding view ahead and to the sides while the big door mirrors provide excellent coverage of what’s behind. 

Its harsh ride quality when unladen is to be expected as it’s designed to carry permanent payloads between 1.0 and 1.5 tonnes. You do get thrown around, particularly on poor road surfaces with large bumps and dips. However, it’s no worse than the rodeo ride we’ve experienced in some unladen single-cab chassis utes which don’t have the luxury of a suspension seat.

The cab’s insulation ensures low engine and tyre noise, particularly during highway use where the turbo-diesel requires 2200rpm to maintain 100km/h and 2500rpm at 110km/h. The most noticeable noise at these speeds comes from wind buffeting around the mirrors, roof racks etc but it’s far from intolerable, as conversations can still take place at normal volumes.

Braking (particularly when using the exhaust brake) and steering response are good but the automated manual transmission takes some getting used to, as it shifts gears at about the same leisurely speed you would do manually.

These long pauses between cogs can be frustrating when climbing hills, as you naturally want to downshift quicker to avoid losing momentum, but you can’t do it in either automated or manual modes. Isuzu claims that the duration of these automated shifts can be shortened, but after consulting the owner’s manual to make this adjustment, we didn’t notice much if any difference (or perhaps we just didn’t do it correctly).

The engine has good flexibility and does not respond well to aggressive treatment. A more relaxed approach is best, using low rpm to optimise torque.

There’s no ANCAP rating required for vehicles in this weight class. Even so, it does have numerous passive and active safety features including driver and passenger airbags plus advanced driver assistance systems (ADAS) including AEB, forward collision warning, distance warning, lane departure warning, traffic movement warning, cab-tilt warning and more. There’s also a reversing camera, reversing alarm (the loud beep-beep type) and door-mounted cornering lamps.

The Pajero Sport has a 10-year/200,000km manufacturer’s warranty as long as you get it serviced as per the schedule at an authorised Mitsubishi dealer.

Mitsubishi’s 10-year capped price servicing applies – with prices ranging from $399 to $999 – and servicing is scheduled for every 12 months or 15,000km whichever occurs first. Check with your dealership for up-to-date servicing costs.

All Pajero Sports come with 12-months roadside assistance, but that can be extended to four years if the vehicle is serviced at an authorised Mitsubishi dealer in line with the official service schedule.

There's a reassuring standard warranty of six years or 250,000km (unlimited operating hours) whichever occurs first. Includes three years/unlimited km coverage for body equipment, plus six years of 24/7 roadside assistance with unlimited km. Scheduled servicing every 15,000km/12 months whichever occurs first. Choice of servicing packages available.