Mitsubishi Challenger 2012 Problems

Cars are either being built worse -- or companies are getting better at detecting faults.a range of models made over the last 10 years replacing potentially deadly Takata airbags in 1.3 million cars in Australia. a second, airbag-related recall for the Priusreplacing potentially deadly Takata airbags in 1.3 million cars in Australia

The safety recall is to fix a fault that could see the powered seats' reclining lever stick in the operating position after use, allowing current to continue to flow to the seat motor. Mitsubishi says there is a risk the motor, seat cushion and surrounding parts could melt or burn."There have been two incidents recorded in Australia, with no injuries," Mitsubishi spokesperson Shayna Welsh says."There are 3,647 vehicles affected in Australia.  Customers need to take their vehicle to a dealership to be inspected, which should take around 20 mins, however, if the seat adjuster assembly needs to be replaced, this action will take up to two and a half hours."The recalled vehicles are the 2007-2013 Triton 4WD Double Cab and 2010-2013 Challenger 4WD models fitted with power front driver's and/or passenger's seat.Mitsubishi says that as a precaution until the owners have their vehicles inspected, they should make sure the reclining lever always returns to the central position after they have used it -- and whenever they leave the vehicle.All owners of affected vehicles have been contacted by mail sent to their last known address, and are asked to contact their nearest Mitsubishi service dealer to have their vehicle inspected and the seat assembly replaced if needed.Owners who believe their vehicle is in the affected range and who have not received a letter by today, September 27 -- or seek more information -- should call Mitsubishi on 1300 13 12 11 and select option 4, then select option 2.

Mitsubishi has issued a safety recall on a total of 20,405 vehicles from the 2011-2012 Triton and Challenger ranges. The recall is to fix a defective weld on the front suspension lower control arms that could fail -- making the vehicle become unstable and pull to the left or right while driving.The recall affects both 2WD and 4WD versions of the models, with 17540 Tritons and 2865 Challengers impacted in Australia.Mitsubishi says if the weld fails, the driver will notice their vehicle pulling off-centre -- which poses a safety concern for both the vehicle and other traffic. Owners are advised to drive conservatively to reduce shock load on the suspension until the defect is fixed.All owners have been mailed the recall notice at their last known address, and should contact their nearest Mitsubishi service centre to have the problem rectified. They can also call 1300 13 12 11, select option 2 and enter their post code to be directed to the nearest Dealer.Owners who have not received a letter by November 22 but believe their vehicle affected by the recall -- or who want further information -- should call 1300 13 12 11, select option 4, then select option 2.  

It took a pick-up and applied a four-door wagon body to create an off-road capable SUV, many years before the concept became as common as it is now (Fortuner, Everest, MU-X, and more)

When introduced to Australia in 1998, the Mitsubishi Challenger was virtually a Triton pickup fitted with a station wagon body. Over the years it retained parts in common with the Triton but became more sophisticated.Challenger is slightly smaller and less passenger oriented vehicle than selling Mitsubishi Pajero. This makes it significantly cheaper. Many 4WD enthusiasts say the Challenger is closer to being a ‘real’ 4WD than the Pajero, and love it for that.Take it to forest trails and it will cope with ease, likewise it handles beach driving well. Having said that, a well driven Pajero can be pretty handy off-road as well. From mid 2007 until December 2009 no new Challengers were built.That’s because the engineers concentrated on designing the all-new Triton (the one with the interesting shape at the rear of the doors) before starting to expand their efforts onto the Challenger. Mitsubishi Challenger was a five-seater until the all-new model of 2009 when a seven-seat option was offered.All Challengers have good head and legroom but the older models are a bit cramped for width in the back for three big adults. Luggage space is excellent in the five-seater, with plenty of length and width. Naturally, the seven-seat models lose space in the rear, but are still pretty good.The area is quite easy to load despite being high off the ground. There is also plenty of in-cabin storage space. The Challenger has reasonable on-road comfort for its type and most owners are happy with its characteristics. Later models improved in this.However, those looking for a very relaxed suburban ride may be better off opting for Pajero instead. The Mitsubishi Challenger’s engine is either a 3.0-litre petrol V6 unit or a four-cylinder 2.5-litre turbo-diesel. The petrol engine is willing enough, but is slightly down on torque at everyday revs.So you have to work at gearchanging to keep it working to best advantage. The five-speed manual gearbox is light and easy to use. The automatic transmission used prior to 2009 is a four-speed unit, then moved up to five-speed unit with the all-new 2009. The auto has Mitsubishi’s semi-intelligent change system and can be used as a sequential manual.The Challenger’ doesn’t use the highly-regarded Super Select 4WD system fitted to the Mitsubishi Pajero, rather it has an old-style setup which normally drives the rear wheels only. The two-speed transfer case can be shifted on-the-fly between 2H and 4H at speeds of up to 100 km/h and the front hubs are automatic.So, apart from the inability to use 4WD on sealed roads the system is almost as good as the Super Select one. Though some see this setup as being old-fashioned it explains part of the aforementioned appeal to buyers looking for a ‘real’ 4WD.The suspension in the original ute-based model has a very firm ride that can make the Challenger tiring on a long trip. Mitsubishi made major revisions to the suspension as part of the mid-2000 facelift and mechanical makeover. The 2009 Triton is much more civilised in the comfort department.Spare parts availability is good and we have heard of no complaints about pricing. Mitsubishi is long established in Australia, having built cars in its Adelaide factory for many years, so is well represented in most areas. Even when you’re deep into the outback there’s a good chance you can find parts and a mechanic who understands the Challenger.Insurance is generally at the lower end as it’s the sort of vehicle that normally sells to conservative people.WHAT TO LOOK FORIf you suspect the Mitsubishi Challenger has had a lot of use on dirt roads and in off-road conditions make a careful check of the interior fittings as the firm suspension can eventually cause squeaks and rattles.Look over the cabin for signs of rough usage, being sure to look into all the hidden storage areas for damage that may have been caused by bored junior travellers. At the same time check out the luggage area for damage and/or bad staining.While the Challenger was built down to a price, quality certainly didn’t suffer and there's the typically impressive Japanese attention to detail. Look under the Challenger’s body for signs of damage caused by too-hard driving in harsh areas. Also look and taste for salt on the chassis rails.Salt can really attack steel and frequent beach use can cause corrosion to rip into the metal if it’s left unchecked. Make sure that the Mitsubishi’s engine starts easily and idles smoothly as soon as it settles into its rhythm.Check the engine doesn't blow any exhaust smoke when accelerated hard, especially after it's been idling for a while. It if does it could be due for an expensive overhaul. Be sure that all gearchanges are smooth and light. Check that 4WD is engaged in both high and low ratios without too much effort.CAR BUYING TIPDon’t even think of handing over your hard earned until you've had a full professional inspection, preferably from an expert on the make/model you’re considering.

When launched in 1998, the Mitsubishi Challenger was virtually a Mitsubishi Triton pickup with a station wagon body. Over the years it has became more slightly more sophisticated but still shares some components with the Triton. Which is no bad thing as the Triton is a tough ute with a good reputation in Australia.