Jeep Wrangler vs Mahindra XUV500

What's the difference?

The Overland is (surprisingly) not atrocious on-road and (not surprisingly) very capable off-road. It costs a lot but, geez, it's a barrel of laughs.

If your heart is set on a four-door mid-size 4WD that's a whole lot of fun to drive, but rather impractical for daily life, then it’s difficult to over-look the Overland.

If you’re really gung-ho about hard-core off-roading – rock-crawling etc – then perhaps you should focus on the Rubicon, but for everything else the Overland, even on standard tyres, is more than capable.

This petrol-powered and well-priced XUV500 W6 might mark Mahindra's most convincing effort at cracking Australia's congested SUV market, but we're still not completely convinced.

That said, it's certainly cheap, the ownership credentials stack up and it's a very comfortable way to transport seven people.

The Wrangler's appearance has been tweaked throughout the years without ever sacrificing any of the ol’ Wrangler spirit.

It has stuck to its traditional roots and, as such, retains its old-school chunkiness, which is good, but the Overland is less of a hardcore-looking 4WD and more of a lifestyle-suited off-roader than its Rubicon stablemate. 

Though the Overland version has a certain blocky appeal, I reckon the Rubicon is better for having fully embraced the all-out off-road look and feel, tyres and all. 

There's no getting away from the fact the XUV500 is not the sleekest, prettiest SUV in the pack. But it's not ugly, either. More that it looks like it's doing its best with a design philosophy hatched a generation or two ago.

Its best angle by far is when viewed straight on, where the piano-black grille, dual bonnet bulges and complicated (read: a little weird) headlight clusters all add some road presence to Mahindra's only SUV.

A side-on viewing, however, is less satisfying, where a combination of strangely placed and super-sharp body creases (including one over the rear wheelarch, which adds a Harbour Bridge-style crescent to the otherwise-straight window line) and serious rear overhang give the XUV500 an inescapable awkwardness.

Inside, expect a vast collection of rock-hard (though nicely patterned) plastics, with the ambiance rescued somewhat by the clean-looking and vertical central control unit, which is home to the media screen and air-con controls. 

Ready for some hashtag real talk? There are better-looking and better-feeling seven-seat SUVs out there. But there aren't many that start at $25,990 drive-away. And I think that's Mahindra's point.

What can you say about a vehicle that has a “wash-out interior with drain plugs” listed in its specs?

This is a purpose-built off-roader and the Overland’s five-seat cabin is a basic but functional space, in which it’s easy to immediately feel comfortable. 

All dials, knobs and switches are easy to locate and chunky enough to operate while skipping over corrugations or climbing up steep rock steps.

There's leather everywhere – seats, steering wheel, shifter knob – but durable outdoors-tough surfaces also abound.

What always strikes me about the Wrangler interior is the fact that it’s abundantly clear Jeep designers regularly experience – or at least are familiar with – the type of life that Wranglers are aimed at: fun, dirty, rough-and-tumble adventures in the great outdoors.

There isn’t a lot of storage space inside but there are a few small, deep, and textured receptacles – ideal for keeping your bits and pieces in the same spot while you bounce around off-road – as well as grab handles, including a big sturdy one in front of the front-seat passenger. 

There are also tensioned net pockets on the doors so you can throw stuff in there, but beyond those there aren't a lot of storage options.

There are air vents, two USB-C ports, and a 230V inverter in the centre console.

Rear cargo space is listed at 898 litres; with the rear seat stowed away, there is a claimed 2050 litres of room.

Pretty damn practical, actually, regardless of whether you want to carry people or cargo. Carrying both at the same time, however, is tricky.

But let's start with people. There is a huge amount of room in the third row of the XUV500, a space with enough head and legroom to put plenty of its competition to shame.

Thanks to second-row seat backs that fold flat, before the the entire seat lifts up and pushes forward, climbing into seats six and seven isn't too big a drama, either. 

We rarely say this about seven-seat cars, but at 175cm, I'd feel plenty comfortable back there on a longer drive. There are two air vents in the third row, too, along with bottle storage and side-seat storage for thin items.

All XUV500's are fitted with a 70-litre fuel tank. 

The space in the middle row is ample as well, and you'll find three ISOFIX attachment points, one for each of the three seats. There's also a door pocket in each rear door and storage nets on the rear of the two front seats. A pull-down divider that separates the back seat is home to two cupholders, matching the two for front seat riders. 

The only downside to all this people-lugging happiness is that, with the third row of seats in place, there is absolutely no room for luggage. Mahindra doesn't quote a litre storage figure when seven are seated (mostly because it would probably be embarrassing to write "one litre"), but trust us, you'll be lucky to squeeze a soft backpack in the boot with all seats in place.

Things improve considerably when you drop the third row of seats, though, which unlocks 702 litres of storage, and that number climbs to 1512 litres with the second and third row folded down.

Make no mistake, this Mahindra kills the competition on price. The entry-level W6 version will cost you a lean $25,990, while the fruited-up W8 version will set you back $29,990. You can even have an AWD W8 for $32,990. The best part? All of those are drive-away prices.

Go for the W6, and you can expect 17-inch alloy wheels, cloth seats, air-con with vents (powered by a second compressor) in the second and third row, cornering headlights with DRLs, front and rear fog lights, cruise control, rear parking sensors and a 6.0-inch multimedia screen linked with a six-speaker stereo.

Spring for the W8, and you'll add leather seats, a reversing camera, tyre-pressure monitoring and a bigger, 7.0-inch screen with standard sat-nav.

This Jeep has a 3.6-litre 'Pentastar' V6 engine – producing 209kW at 6400rpm and 347Nm at 4100rpm – and an eight-speed automatic transmission.

It's an effective engine-and-auto pairing for driving on sealed surfaces and well suited to high- and low-range 4WDing.

There's a diesel engine currently available, but the clock is ticking - Mahindra expects it to be phased out within six months. But the big news here is the new petrol engine, a turbocharged 2.2-litre unit good for 103kW/320Nm. It's paired exclusively with an Aisin-developed six-speed automatic transmission, and will send it's power to the front or all four wheels.

Mahindra doesn't quote official performance figures, but those engine outputs hardly scream excitement, do they?

Official fuel consumption is listed as 9.7L/100km on a combined cycle. 

Actual fuel consumption on this test, from pump to pump, was 13.6L/100km, largely attributable to the fact I did a lot of low-range four-wheel driving on this test, as always. 

The Wrangler Overland Unlimited has an 81-litre tank so, going by that fuel figure above, you could reasonably expect a driving range of about 595km from a full tank.

Note: Drop 30km to 50km from your total calculated fuel-range figure for a better idea of your vehicle’s safe touring range – so that figure above would be 565km.

Also, remember that numerous other factors affect your fuel consumption and so impact your touring range, including how much extra weight you have onboard (passengers, camping gear etc), whether your vehicle is fitted with any aftermarket equipment (bullbar, spare-wheel carrier, etc), whether you are towing (a camper-trailer, caravan, or boat etc), your vehicle's tyre pressures and the conditions.

Local numbers are yet to be confirmed, but after an admittedly vigorous local test, the on-board computers was reading 13+ litres per 100km. All XUV500's are fitted with a 70-litre fuel tank.  

The Wrangler Overland is a fun, go-kart style drive and yields a real driver-direct experience you get from few other contemporary vehicles on the blacktop and the dirt.

But while it’s nowhere near as atrocious as you might expect on sealed surfaces its planted, squared-off stance gives it a definite composure on bitumen. It’s certainly no sports car in terms of ride and handling.

It’s quite soft on-road, soaking up most imperfections with ease, but it also takes quite a lot of effort and concentration to keep this Jeep in line on the open road because it tends to float around on the blacktop if not constantly reined in. 

Also, its steering has a lightness about it that can sometimes be a bit disconcerting. 

The V6 is a gutsy unit, capable of punching the Overland along at a fair clip, all while the eight-speed auto handles clever and nicely controlled shifts.

Because it’s so blocky, straight up and down, with big wing mirrors and the like, the Overland is rather noisy on sealed surfaces.

But it remains one of the few modern vehicles that deserves to be driven with the windows down, because it offers that kind of visceral driving experience – as the LC70 Series, or Suzuki Jimny do.

So, how does the Overland perform off-road? Bloody glad you asked.

Spoiler alert: The Overland is not as good an off-roader as the Rubicon because it does not have that variant’s BFGoodrich Mud-Terrain tyres, 'Rock-Trac' active on-demand 4x4 system (with 4:1 transfer case*, and 77.2:1 crawl ratio), front and rear locking differentials, or the Rubicon’s very handy electronic front sway bar disconnect. (* The Overland has 2.72:1.)

But, having said that, the Overland is still an extremely capable off-roader.

To be honest, I wasn't expecting any strife because it retains all the traditional goodness of the Wrangler with very few compromises. It’s a genuine 4WD with a dual-range transfer case, a ladder chassis, solid axles and well-proven 4WD heritage.

In terms of size, the Overland is 4882mm long (with a 3008mm wheelbase), 1894mm wide, 1838mm high. It has a listed kerb weight of 1900kg.

Steering has a nice weight to it at lower speeds, giving the driver a great sense of sustained control through even the most severe obstacles, but the Overland’s turning circle is a listed 12.44m, so this off-roader can sometimes feel like a mini-bus to steer through tight turns.

However, this is a purpose-built off-roader with a wide wheel track and low centre of gravity, so it feels planted no matter how rough and bumpy the terrain gets.

On the gravel track to our off-road testing site, there are numerous steering-wheel-jolting corrugations but overall the Overland – with a coil spring at each corner – soaked them up.

Our 4WD loop included the aforementioned gravel tracks, light to medium corrugations, undulating mud tracks and mud holes, and some very challenging low-range 4WD sections (in particular, a steep rocky hill), and a few other set-pieces to see if the Overland was able to do everything safely and comfortably. 

As a true 4WD worth its weight in gold, the Wrangler is immediately more at home taking on low-speed 4WDing than it is negotiating suburban traffic.

Again, the V6 engine comes into its own, delivering smooth, even torque when needed, but not ever over-working to achieve that.

Considered driving is necessary as is slow and steady throttle, but that's easily achieved in the Wrangler as its go pedal is none too sensitive to a bouncing boot.

It’s refreshing to note that switching to 4WD High or 4WD Low range is still done via a stubby stick to the left of the auto shifter, rather than the push of a button, or the turn of a dial. 

Low-range gearing is very good and the Overland has a well-calibrated off-road traction control that seamlessly launches into action when required, and wasted wheelspin is kept to an absolute minimum.

This Wrangler has 242mm ground clearance and a standard wading depth of 760mm, and was never troubled on climbing steep rock steps, traversing deep ruts or punching through mudholes.

It’s supremely sure-footed during low-range work but visibility can be an issue: over-bonnet visibility has improved slightly over previous generations but the driver’s view to the front and side is still a bit squeezed, making it at times difficult to visually pick correct wheel-placement, especially when driving steep terrain at sharp angles.

It can go hardcore, no worries, but it simply requires a bit more thought and you know what? That’s fine with me because it makes the off-roading experience an even more engaging one. 

The Overland has approach, departure and breakover angles of 35.8, 31.2 and 20.4 degrees, respectively.

With live axles front and rear, the Overland has plenty of wheel travel to keep moving and under control through truly off-grid country.

The only real compromises in the Overland’s 4x4 set-up are its standard Bridgestone Dueler (255/70R18) highway tyres and, even on those, the Overland walked up and over our toughest off-road challenges.

Though the Overland is not historically regarded as a towing platform, it’s handy for you to know that it has listed towing capacities of 750kg (unbraked trailer) and 2495kg (braked).

About as old school as rocking a pair of button-up tracksuit pants with a Run-DMC cassette stuffed into your Walkman.

On a straight and unchallenging road, there's stuff to like about the petrol-powered XUV500. The engine, while gruff under heavy acceleration, doesn't feel too wheezy when you're not asking a great deal of it, and nor is the cabin overly loud at suburban speeds. It's a comfortable space for driver and passengers, too, and the gearbox performed seamlessly on our short test drive.

But that's about where the good news ends. There's an unshakeable agricultural feel to the way this Mahindra SUV goes about its business, and nowhere is that more obvious than through the steering wheel, which has only a vague and difficult relationship with the the front tyres, making it seriously tricky to approach twisting roads with anything approaching confidence.

The steering is slow and cumbersome - light when you first begin turning the wheel, with a ton of weight appearing by surprise midway through the cornering process - and it has a tendency to fight back should the front wheels find a bump or corrugation in the road, too. 

The body lolls about when challenged, too, and the tyres are quick to give up their grip on tighter corners. All of which would give it a certain retro charm if it wasn't so very new, and I must admit I was cackling maniacally on some of the more twisting roads.

But it's simply not a car I could live with.

Expect dual front, front-side and curtain airbags (though the latter don't extend to the third row of seats), along with rear parking sensors and ESP. Stepping up to the W8 trim adds a reversing camera with dynamic guidelines. The XUV500 was awarded a four-star (out of five) ANCAP assessment when tested in 2012.

The Overland Unlimited is covered by a five-year/unlimited km warranty.

Servicing is set at 12 month or 12,000km intervals at a total cost of $1995 over five years, with servicing capped at a maximum $399 per appointment.

Lifetime roadside assist is available to Overland owners when they service through Jeep.

All XUV500s are covered by a five year/100,000km warranty (though the final two years apply only to the drivetrain), along with five years of complimentary roadside assistance.

The XUV500 is also covered by Mahindra's capped-price servicing program for the first three years of ownership, and will require servicing every six months or 10,000km.