Ford Transit Custom vs Mercedes-Benz Evito

What's the difference?

The Ford Transit Custom Trail has plenty of appeal as a work van or a camper fit-out candidate. It’s a well-packaged, comfortable and contemporary van that’s nice to drive and as a bonus, with all-wheel drive it’s given the scope of capability to be able to tackle mild off-roading situations with confidence.

It’s built for work and play and though it’s limited to two-up for travels, the Trail offers so much potential as a camper conversion for adventure seekers its few niggles are easily forgotten when you’re busy making memories.

It’s arguably the best-looking mid-size van on the market, particularly with the optional enhancements fitted to our example. And its longer (km-based) service intervals and capped-price servicing costs offer substantial savings compared to a diesel Vito equivalent.

However, the eVito has a much higher purchase price, smaller payload, shorter driving range, can’t tow a trailer and feels a tad under-powered at low speeds. Plus filling its battery with fresh charge takes much longer than filling a tank with diesel, which may or may not be an issue depending on planned usage.

Therefore, a buyer would need to have not only a sizeable purchasing budget but also very specific and resolute criteria for this vehicle to shine in a commercial role.

It looks like a van but with some striking yet low-key flourishes that all kind of work as a whole. Those include a Trail grille and the matt black alloy wheels. The yellow sticker-pack is a neat touch.

The Trail has more presence than a regular Trend with its 30mm-taller raised suspension and overall adventure-ready look with strong front end and chunky wheel arches.

The striking but low-key theme continues inside with a neatly laid-out yet spartan cabin. The two synthetic leather seats are topped with Trail embossing and lined with yellow stitching.

The cabin is separated from the rear cargo area by a bulkhead, which incorporates a small wired window.

The eVito’s front-mounted electric motor drives the front wheels. Its lithium-ion battery is located beneath the standard Vito floor to ensure load volume is not reduced. This substantial battery is as wide as the load floor and extends from just behind the front wheels to just ahead of the rears. Its charging port is located behind a spring-loaded body flap ahead of the left front wheel.

It rides on a 3200mm wheelbase with 5140mm overall length, 1928mm width and a kerb-to-kerb 13-metre turning circle, with 1916mm height allowing access to underground and multi-storey carparks. It’s equipped with strut-type front suspension, semi-trailing arm/coil spring rear suspension and four-wheel disc brakes.

It’s a van so there are two distinct sections to the Trail, the cabin and the load space.

Firstly, the cabin. More a work-friendly than family-friendly interior, this Trail is a two-seater with plenty of durable plastic everywhere – ready for work and life – as well as charging (with USB-A and -C ports) and storage (including a van-favourite dash-top slot for logbooks etc, outboard moulded cupholders and a nifty pop-out cupholder), all amenities enough to cope with most daily van-related duties.

The seats are comfortable, supportive and have a fold-down lock-in-place armrest.

Now for the load space. There are no seats back there and as such it has plenty of potential as a work van or touring vehicle.

Access to the rear load space is via a barn door at the back and this Trail has a sliding door on both sides.

The cargo area is substantial – 3002mm long (to the bulkhead; 3450mm long if load-through hatch is used), 1392mm wide (between wheel arches) and 1425mm high (floor to roof). Easily big enough for work equipment or recreational gear. It can cope with four Euro pallets (each measuring 1200mm x 800mm) and it has a listed maximum load volume (with the bulkhead) of 6.8 cubic metres.

Load height through the rear barn doors is 531-585mm, depending on how much weight is already onboard.

The load space has the aforementioned metal bulkhead (with window and load-through hatch), load area protection kit (full height walls and moulded floor), LED lights and eight tie-down loops.

Otherwise, this is a load area ripe for customisation. Maybe a plethora of shelves for a tradie, or some bedding and extra storage for an adventurous person or couple.

With its hefty 2318kg kerb weight and 3200kg GVM, the eVito has an 882kg payload rating. That is 183kg less than a diesel equivalent (119 Vito MWB RWD), given that the eVito is around 300kg heavier than the ICE version largely because of its battery.

And unlike the diesel alternative, which is legally rated to tow up to 2500kg of braked trailer, the eVito has no tow rating, which is consistent with other electric vans we’ve tested and a potential deal-breaker for tradies.

The cargo bay offers a competitive 6.0 cubic metres of load volume and is accessed through sliding doors on each side (822mm openings), with large internal assist-handles on the bulkhead. Rear cargo bay access is through a swing-up tailgate, which can limit the use of forklifts not fitted with extendable tynes. All doors and walls are internally lined.

The load area is 2678mm long, 1709mm wide and 1392mm high. With 1270mm between the rear-wheel housings, it can carry two 1165mm-square Aussie pallets or up to three 1200 x 800mm Euro pallets, secured by eight sturdy load-anchorage points.

The cabin bulkhead has a cavernous open storage area at its base which is handy for storing ropes, straps etc. The upper section of the bulkhead protrudes about 20cm into the openings of the side sliding doors which may obstruct loading of large items.

Cabin storage includes a large-bottle holder and bin in the base of each door, with smaller bins at mid-height. There’s also an overhead glasses holder, two cupholders and three open bins across the top of the dash, a single glovebox and a hidden compartment beneath the passenger seat which is handy for storing small items or valuables out of sight.

Our test vehicle is the eVito Panel Van MWB (Medium Wheel Base), which comes equipped with a single 85kW/360Nm electric motor and a 60kWh battery for an eyebrow-raising list price of $91,051 plus on-road costs.

Our sparkling example looks more upmarket than the standard offering, as it’s equipped with the optional $2779 Sport Package comprising metallic paint (Brilliant Silver on ours), body-coloured front and rear bumpers, black roof rails, fog lamps, black leatherette upholstery and a choice of 17-inch alloy wheels. These good-looking rims are fitted with 225/55R17C Dunlop Econodrive tyres and there’s a standard full-size steel spare.

Other options, including premium infotainment and electronic interface functions, cargo bay wood-flooring/LED lighting and more, raise the as-tested list price to $99,871 - which means you’re looking at six figures to drive away in this stylish two-seater.

So, what’s a $100K electric Mercedes-Benz van include as standard equipment? Let’s start with a conspicuously long (8.0 metres) charging cable stored in a vinyl bag. There’s also a chrome grille, tinted windows and heated door mirrors, but headlights/daytime running lights/tail-lights are halogen when you’d expect to see LEDs at this price.

Inside, there’s a full steel bulkhead (with large window) separating the cabin from the cargo bay, a leather-wrapped and two-way adjustable multi-function steering wheel, two USB ports, high-gloss black trim appointments in the upper central console, and a chrome interior package including air-vents, air-con dials, door-handles and surrounds.

Also standard are ‘Comfort’ bucket seats for driver and passenger with heating, base-cushion length adjustment, fold-down inboard armrests and powered adjustments including height/reach lumbar support. The infotainment system has a relatively small 7.0-inch touchscreen, but there’s digital radio, voice command and multiple connectivity including Apple/Android devices.

The Ford Transit Custom Trail has a 2.0-litre four-cylinder turbo-diesel engine producing 125kW at 3500rpm and 390Nm at 1750-2500rpm.

The Trail has a clever eight-speed automatic transmission and an on-demand all-wheel drive system.

It all works rather well, but it’s a van afterall and as such it is less dynamic and more dependably driveable than perhaps a cross-shopped SUV wagon. However, as an AWD van the Trail can be trusted to keep its grip on wet bitumen, soggy grass and loosely-gravelled tracks and that’s a strong part of its appeal over a 2WD van.

The eVito’s single electric motor drives the front wheels via a single-speed transmission. It produces 85kW of power and 360Nm of torque from the energy stored in its 60kWh battery.

Using the steering wheel paddles, drivers can switch between five energy-recuperation modes to optimise battery range and reduce manual brake use. These range from D- (strongest deceleration/recuperation) through D, D+ and D++ which progressively reduce these effects. DAuto uses a radar sensor to automatically adjust the recuperation level according to surrounding traffic.

There are also three switchable drive modes comprising E+, E and C, which allow drivers a choice of energy consumption/performance levels.

The Ford Transit Custom Trail has an official combined cycle (urban/extra-urban) fuel consumption figure of 8.5L/100km. On this test I recorded 8.8L/100km.

The Trail has a 70-litre fuel tank so going by my on-test fuel figure you could reasonably expect a driving range of about 795km from a full tank of diesel. However, as with any vehicle, once you’ve loaded the Trail with real-world burdens (e.g kids, dogs, camping gear, etc) you’ll soon see that fuel consumption increase.

It’s easy to get in and out of the Trail’s driver seat with a wide-opening door and a big step to help you inside.

The seats are comfortable and it’s simple enough to dial-in your driving position via the tilt-and-reach adjustable steering wheel and manually-adjustable seat.

Word of warning: the auto transmission is operated via a stalk mounted on the right-hand side of the steering wheel column, which takes some getting used to.

Once underway, the Trail is punchy enough around town and in the suburbs with its 2.0L 'EcoBlue' turbo-diesel engine offering a more-than-adequate amount of power and torque (125kW and 390Nm) and its clever auto helping out with nifty moves through traffic (for a van, anyway).

Visibility is impressive from the cabin and you’re afforded a convenient vantage point with the Trail standing a bit taller than its regular Transit Custom stablemates as it’s on lifted suspension, but feeling composed on most surfaces.

The Trail has a listed kerb weight of 2046kg and a turning circle of 12.1m, pretty standard for a long wheelbase van, so this is not an insubstantial vehicle and it’s a bit tricky to 'flip a u-ee' if the situation demands it.

It has six drive modes – 'Normal', 'Eco', 'Slippery', 'Tow/Haul', 'Sport', 'Trail' – which each adjust engine torque, throttle response and traction control, among other things, to suit the road surface and conditions.

But we’re all here to see how it goes off-road, aren’t we?

Well, obviously this is no rock-crawling machine and it’s not intended to be. It’s best thought of as having an all-wheel drive system that gives this van mild off-road capabilities, as in it can tackle wet bitumen, soggy grass, lightly corrugated bush tracks and very shallow mud puddles with more confidence than the Transit Custom Trend it's based on.

In a nutshell, the AWD Trail will be able to handle most low-level traction-compromised scenarios. But it does not have enough ground clearance, wheel articulation, grip or underbody protection to tackle any terrain beyond modest off-roading.

Speaking of grip, the Trail as standard rides on Bridgestone Duravis R660 (215/65 R16) rubber, a van/light truck commercial tyre and they are not so well suited to dirt tracks and the like. Grippier all-terrain tyres would help this van perform slightly better off-road than on its showroom rubber.

In its favour, the Trail has a front skid plate and underbody protection in case it cops some knock from the ground during its adventures.

Not in its favour, however, especially as a potential touring vehicle, is the fact it has a space-saver spare wheel and tyre.

If you’re thinking of using your Trail as a tourer, it’s worth knowing payload is listed as 1179kg, maximum braked trailer towing capacity is 2500kg, Gross Vehicle Mass (GVM) is 3225kg and GCM is 5725kg.

It’s easy to get comfortable given the height/reach adjustable leather-wrapped wheel and powered multiple seat adjustments, which include base cushion rake and height/reach lumbar support. The base cushion can also be manually extended for more under-thigh support by sliding the front section forward.

There’s good eyelines to the door mirrors and, thanks to the large window in the cabin bulkhead, the central rear-view mirror has an unobstructed view through the tailgate window. The passenger-side mirror’s wide-angle view, combined with active blind-spot monitoring, help to minimise the large blind-spot over the driver’s left shoulder that all solid-walled vans share.

Steering is nicely weighted and communicative, unladen ride quality is supple thanks to its four-coil suspension, and four-wheel disc brakes provided reassuringly strong braking response. However, there was also noticeable tyre noise intrusion at speeds above 60km/h on coarse bitumen surfaces.

Acceleration from standing starts feels leisurely at best, even when using full power. This is when the eVito’s 2.3-tonne kerb weight is noticeable, which is not surprising when you compare its weight-to-power and weight-to-torque ratios with a diesel Vito (MWB) equivalent.

For example, based on kerb weights, the 119 CDI Panel Van (140kW/440Nm) has to move 14.2kg/kW and 4.5kg/Nm compared to the eVito’s much heavier 27.3kg/kW and 6.4kg/Nm.

However, the power delivery is seamless and once up to cruising speeds the response noticeably improves, fortunately in the 60-80km/h range where much city and suburban travel occurs. The key to fluent progress in traffic is maintaining momentum.

To test its load-hauling ability, we inflated the tyres to the recommended pressures and forklifted 650kg into the cargo bay through the side doors. Combined with driver and equipment, this equalled a 750kg (three-quarter-tonne) payload which was about 130kg short of its maximum rating.

With the cargo bay load positioned well ahead of the rear wheels, the rear suspension only compressed 25mm with no risk of bottoming-out over bumps.

Our 50km test route comprised mostly city and suburban routes (for which this vehicle is tailored) plus some highway driving. There wasn’t a noticeable drop in handling, braking or ride quality with this payload, although standing-start acceleration felt more subdued as you'd expect.

There is currently no ANCAP rating. Even so, it comes with a suite of standard passive and active safety features including front, thorax and window airbags, AEB, blind-spot monitoring with rear cross-traffic alert, lane-keeping, active parking assist, crosswind assist, front/rear parking sensors, DRLs, active cruise control, reversing camera and more. There’s no speed sign recognition, though.

Ford’s five-year/unlimited kilometre warranty applies to the Trail.

Servicing is set down for every 12 months or 30,000km and capped-price servicing is offered. Four scheduled services will set you back $2000 (including a brake fluid change at year three) which isn't over the top for a vehicle of this type.

Ford Australia has about 195 independent Ford dealers in Australia, with many located in metropolitan or suburban areas.

The eVito has a five-year/250,000km vehicle warranty with an eight-year/160,000km battery warranty and a 24-hour roadside assist support package. Scheduled servicing is every 12 months/40,000km whichever occurs first. Capped pricing for first five scheduled services totals $2432 or an appealing average of $486 per service.