Recalls

The recall involves cars built between June 2005 and April 2007 and is part of a world-wide recall of 1.3 million cars.The carmaker says in severe front-end collisions, the seat belt is at risk of causing a foam pad in the car to ignite.Toyota Australia spokesman, Glenn Campbell, said three cars globally, including one in Australia, had experienced the problem.“There is a possibility that a noise-absorbent insulation could heat up when the seatbelt-tensioner is activated in a crash,” he said.“In extreme cases, this could lead to a post-crash fire.”Campbell said Toyota was contacting customers by mail to have their cars checked and have the faulty insulation removed.“The repair takes less than an hour and will be done at no cost to customers,” he said.The insulation was originally designed to reduce noise but subsequent testing by Toyota has found it does not increase noise levels when removed. 

In extreme situations, owners have been warned their vehicles may catch fire.Mitsubishi was hit with the biggest safety recall for the three month period. It has written to owners of Pajeros built between 2000 and 2003 to warn them of a potential brake problem. As many as 13,400 vehicles may need to be checked.The company also recalled 4400 of its now-defunct 380 sedan, built between 2006 and 2007, which may have a faulty fuel tank retaining strap. In a severe collision the tank may be dislodged and spill fuel.Mitsubishi is also checking more than 8300 Colts built this year which may have a problem with door windows which may drop and unlock or open the door while the car is being driven.Honda has recalled 11,800 of its 2004-05 Jazz to check whether they have a faulty handbrake, while Mazda needs to look at 1770 of its B4000 utes built between 2005-2006 because the bonnet may open unexpectedly.Subaru has recalled 5380 of its Imprezas, built between 2001 and 2003 because of a faulty rear tailgate which may suddenly drop.Subaru Australia spokesman, Dave Rowley, said many of the recalls were to check for "minor or niggling" faults."We have had no incidents of anyone being injured in Australia and we found only six cars which had the faulty (tailgate strut) connection."Many recalls are done as a pre-emptive measure to avoid possible problems further down the track, " he said.Other potential faults include electrical short circuits, which in extreme circumstances, may start a cabin fire in Landrover Freelander diesels built since 2007. Landrover warns the fault may occur when the vehicle is parked and unattended.Other recalls were to check for short circuits in Fiat's Grande Punto; and a chance that the panoramic glass roof in a small number of Citroen's Picasso could be dislodged.Suzuki has warned of potential fire risk in its 3-door Suzuki Grand Vitara (2006-07) because of a possible cracked fuel pipe, while the 2005-08 Vitara diesel has a remote fire risk in a filter because of a problem with the intercooler outlet pipe insulator.Other problems include faulty rear seat belt D-loop attachments in the current Jaguar XF, and the potential for a loss of steering in Chrysler's 300C built last year because of a problem with rear axle hub nuts which could see the half shaft disengage from the wheel hub.Mercedes Benz wants to look at axles, springs and the park brake in its Sprinter or Vito vans.Jayco has recalled some of its motor homes to check and fix awning and exhaust pipe problems.Of the 1500 motorcycles recalled, safety issues to be fixed include a faulty fuel filler on Kawasaki models, a windshield which may come off Buell bikes if ridden at high speed and a rear view mirror which may fall off on certain Yamaha models.An ACCC spokeswoman said this year's figures were actually less than last year but the number has been steadily rising over the past 20 years.The ACCC says there have been 52 individual recalls this year compared to 171 last year.Full details of the recalls can be found at www.recalls.gov.au 

If a minor collision sets off all 12 airbags in a 7 Series BMW it could well be written off.Not because of the crash damage but because of the cost of replacing the airbag and seatbelt systems.An Airbag Mobile Reset Service spokesman said the cost of replacing the airbags, the damaged trim and replacing the pre-tension seatbelts on a 7 Series could easily amount between $30,000 and $40,000. “I know of BMWs in Sydney that have been written off because of this cost,” the spokesman said.Airbags are in the news as Australian road-safety campaigns are expanded, but British road safety group, the Guild of Experienced Motorists (GEM), says many people had no idea what happens when airbags deploy or the dangers the bags pose if occupants are unaware of their presence or operation.GEM Motoring Assist says the airbag is a great safety feature and used in conjunction with a seatbelt can often prevent serious injury. But GEM boss David Williams says unless people have experience of the quick-inflating devices, drivers and passengers could panic in a crash.GEM member Matt Day described his first experience of an airbag deploying when he and his wife were involved in a crash.“We were thankful for the extremely fast deployment of the airbags,” Day said. “They seem to have deflated again before I realised they had inflated. What's more, the seatbelts did their job and we didn't get thrown forward.”Day said that when the airbags inflated his car filled with smoke from the mini-explosion, which was necessary to deploy them.“I could sense the car filling rapidly with smoke and my initial reaction was to get out. I screamed at my wife to get out, too.”Day's reaction is typical but based on a lack of knowledge.The airbags are inflated by a small explosion and white smoke or fine powder often fills the car because the airbags have a big hole in the base to allow gases to escape.“The airbag has inflated and is already letting the air out of the big hole usually before the driver or passenger has hit them,” the AMRS spokesman says. “At the same time in most modern cars an explosive charge has gone off down by the seat where the seatbelt is mounted at the base of the seat. This pulls the seatbelt tight. So there can be lots of noise and the smell of burning which often frightens people.”Airbag Mobile Reset Service website warns of airbag dangers.“Airbags inflate in a fraction of a second and with great force. This means if the front-seat occupants of the car are not properly seated and strapped in with seatbelts or are obstructing an airbag compartment with part of their body, they may be injured. There have been reports in the US of children sitting in the front seat or lying in a rear-facing child restraint mounted in the front seat being crushed to death by airbags in low-speed accidents, which they might have otherwise survived."“According to the NSW Roads and Traffic Authority, it is common practice to carry small children in the front seat in the US and Europe. In Australia they're generally in the back because our child restraints usually can't be fitted in the front seat. As long as this doesn't change we shouldn't have the same problem with children being injured."“However, Australian adults still need to be cautious — there have been reports in the US of airbags causing bruises, broken arms, eye damage and adult fatalities."“But they do save lives. Despite the occasional problems, airbags in most cases do prevent serious injury and save lives. For example, General Motors Holden says there has been a 'dramatic' reduction in facial, head and chest injuries to occupants of airbag-equipped Commodores involved in accidents.“The US-based Insurance Institute for Highway Safety has also compared driver deaths in airbag-equipped cars with cars without airbags. The research found there were 23 per cent fewer deaths in airbag-equipped cars involved in frontal and front-angled crashes.”Have you had any problems with your airbags? Let us know by filling out the bottom field. 

On the day it was named as Australia's top selling car in 2007, Holden has recalled 86,000 current model V6 Commodores and Statesmans because of the risk of an engine bay fuel leak that could cause a fire.The recall affects all V6 VE Commodores and WM Statesman and Caprice long-wheelbase models built by the company since the new generation model was launched in mid-2006, following a $1 billion development program.Holden spokesman John Lindsay said the recall was a precaution to prevent a potential fuel leak under the bonnet."We've got a condition where one of the fuel lines in the engine compartment has the potential to rub against a clip on an adjacent hose, so over a period of time this could potentially - and I emphasise potentially - result in a leak in the hose and a fuel smell may become evident," Mr Lindsay said."The chances of this happening are very low but obviously we are erring on the side of caution and we are administering a recall of all (V6) VE and WM Commodores since the start of production..."The fuel leak problem had affected about 20 of the 86,000 cars affected by the recall, Mr Lindsay said.The recall includes about 53,000 Commodores and Statesmans sold in Australia, about 5000 in New Zealand, 27,000 sold in the Middle East and 784 in Brazil.But the lucrative export of its Pontiac G8 version of the car has not been affected because the US models use a different layout under the bonnet.Holden will launch a national advertising campaign to advise owners of the recall. The company will also write to owners individually.They will be asked to contact their Holden dealer's service or Holden's recall advice line - 1800 632 826 - to arrange for a simple repair to re-route the affected fuel line.A similar recall of 1850 V8 models of the same car was announced in October 2006, because of a fuel line in the engine bay that was supplied to Holden by an outside company that could, under certain circumstances, be torn.Then, a month later about 13,000 cars were recalled because of a minor fault in the rear seatbelt buckles on some cars.The recall comes as the Federal Chamber of Automotive Industries officially announced the Holden Commodore was Australia's top-selling car last year.Last year was a bumper year for car sales, with more than one million cars sold in Australia in a single year for the first time.