Ford Tourneo Custom vs Volkswagen Amarok

What's the difference?

There’s absolutely no doubt that the van-based people-mover has some distinct advantages over a three-row SUV. The rear seat is bigger, access to it is far better and there’s more luggage space even when all eight seats are occupied. But the Tourneo goes a step or two further with the sliding, swivelling seats that make it one of the most practical and flexible interiors on the market.

True, the driving experience is a bit alien at first, but it’s a case of different, rather than worse. Meantime, the ride is excellent and the performance and economy from the turbo-diesel driveline are both absolutely spot on for this vehicle’s intended purpose.

And perhaps that’s the metaphor for the whole thing: By not trying to be something it’s not, and concentrating on what it needs to do, the Tourneo emerges as a bit of a quiet achiever.

As we said earlier, this type of vehicle concept is never a sure-fire proposition. Parcel vans converted to passenger duties haven’t always worked out. This time, though, it’s different.

It’s been developed with adventurous four-wheel-drive enthusiasts in mind, but we don’t know exactly what it will cost. However, given the current ballpark estimate, the value equation will likely stack up well and things like safety and the ownership package are solid. And we know it’s tough and capable in rough going, which is the main point, after all. This package works brilliantly well.

Note: CarsGuide attended this event as a guest of the manufacturer, with travel, accommodation and meals provided.

Perhaps the biggest revision of the successful Transit Custom formula needed to make the leap from FedEx to Brady Bunch has been to the rear suspension. Where the Transit uses a leaf-sprung arrangement, the Tourneo has switched to coil rear springs. These technically offer much greater ride comfort at the expense of some load-carrying ability. Which is fine, even if your kids are the bigger variety.

The move to powered sliding side doors is a welcome one, but I found out the hard way that the doors will still open a fraction if you push the button while still travelling at low speed. Not sure why that would be, but at least the buttons in question are up front in Adult-Land, not within reach of you-know-who.

The reality is, too, that the Tourneo is destined to run with the air-con on any time you have bodes in the back. That’s because – like a lot of van conversions – there’s no opening side windows beyond the tiny, hinged windows that open an equally tiny amount. This has more to do with the Transit’s basic structure than any desire to oxygen-deprive the young `uns, but as any parent knows, a supply of fresh air on the move is sometimes the only thing between a happy day out and a clean up in Aisle five.

The Amarok is already a sleek-looking dual cab and the ‘Clear White’-only 10 Deserts Edition picks up unique black badging, a standard black tonneau cover and 17-inch satin ‘Asphalt Black’ alloy wheels shod with all-terrain rubber. More hardcore off-road tyres are a no-cost option, which is a nice touch, and there are black side steps and a ‘Asphalt Black’ mesh grille with ‘Bolder Grey’ inserts.

An ARB lift kit raises ground clearance by 40mm, from an already decent 235mm to 275mm, and ‘Genuine VW’ underbody protection is added.

The interior is cool, calm and collected in typical VW fashion with a predominantly dark grey colour palette highlighted by silver and brushed metal accents.

The 8.0-inch digital instrument display and 10.1-inch multimedia screen look contemporary without being garish, and there’s a workable mix of digital and physical controls, with climate being the former and audio the latter.

Here’s where a vehicle like this stands or falls. Because if something like a Tourneo can’t cope with lots of people and their luggage in a single bound, then there’s really not much point to it, is there? I mean you’re not going to buy it for its sporty looks or supercar dynamics, so unless it works brilliantly as family transport, it’s kind of dead in the water. Fortunately Ford seems to have got it right. Mostly, anyway.

That starts up front where the two front seats feel like they’re metres apart. In reality, this huge gap forms a walk-through function for getting access to anything or anyone misbehaving in the second or third row of chairs. But you can’t help wondering what if… What if Ford had ditched the stubby centre console and added a third front-row seat? Wouldn’t a nine-seater be better than eight?

But the seats themselves are comfy and the high-and-mighty driving position gives plenty of vision in every direction. With one exception. And that is when you’re pulling out of a side street on to a main road and need to see what’s coming from the left. Depending on the angle you’re on, the fat frame of the pop-out side window (in the sliding door) becomes a blind spot, especially for taller drivers.

There’s nothing irretrievably wrong with the way the controls are laid out, but they will take some acclimatisation. That goes for the menu system on the touchscreen as well as the column-mounted shifter wand which is about the same size and shape (and in the same place) as a conventional indicator stalk. Tip the lever accidentally and you’ll wind up in neutral, wondering what just happened. The manual-shift mode is also fiddly to use and paddle sifters would be vastly better. Most won’t bother anyway.

The front cabin is home to a shallow lidded bin in the centre console, a deeper bin below that and a couple of charge points. There are also cup-holders in great spots up high in the corner of the dashboard, a shelf across the top of the dashboard and no less than two gloveboxes (the top one is pretty shallow) thanks to moving the passenger’s airbag into the roof lining. Both front doors also feature bins and storage nooks but there’s a fair bit of hard plastic on show, surely a legacy of the Tourneo’s parcel-van DNA.

The Tourneo’s party trick is the way both the second and third rows of seats can be slid to almost any point on a pair of tracks in the floor. The move is simply accomplished via a lever at the front or a rip-cord in the back of the seats, and all three centre-row seats can be moved individually (the third row is split 60:40). The upshot is that you can have all three rows bunched together for a large luggage space, or the rear row pushed right back to form a rear row with huge legroom. Don’t need all eight seats? How about a second row with the two outside chairs in place and the centre one folded forward to expose a work-surface with built-in cupholders.

But it gets even better, because individual seats can be removed to suit the weirdest of loads and the second-row seats even swivel 180-degrees to form a loungeroom on wheels. The kids will be begging you to take them for a drive in this thing.

The seats fold forward, but they don’t tumble. They don’t need to really, and they don’t fold into a bed either. But if you fancy camping in the Tourneo, you can remove both rows of rear seats for a huge flat floor.

The second row is home to storage bins in each sliding door (yes, a door on each side) a pop-put window that opens only about 40mm, temperature controls, air vents and reading lights. The third row, meantime, is not only easily accessed provided the second row isn’t slid all the way back (at which point you wouldn’t be using the third row anyway) but the good news is that the rearmost seat itself is basically three bucket seats with the same comfort levels (high) as the second row. There are also reading lights and a pair of phone pockets and cup-holders in the last row, too. Only the way the track system works and the shape of the seat base means that foot-room is limited to an extent.

With all three rows in place, but pushed as far forward as they can go, there’s a long load area of up to 725mm. But you can also push the second and third rows all the way back and have a cargo area 2622mm long behind the front seats. Maybe the van DNA is a good thing after all.

With all eight seats in place, there’s a minimum of 673 litres of luggage space which can be expanded all the way to a monster 4683 litres with the second and third rows removed.

There’s also a 12-volt power socket and a lighting system in the back, too, although while the side doors are automatic, the tailgate is manual. And you’ll need plenty of real estate to open it, too. Even tall folk will hit the button to open the tailgate, start the strut-assisted opening and then take a step or two back to allow the huge tailgate to rise without clobbering them. An automatic tailgate where you hit the button and run away to a safe distance would be much nicer.

At just over 5.3m long, a little more than 1.9m wide and close to 1.9m tall (with a 3270mm wheelbase) the Amarok lives within the same dimensional footprint as key competitors like the Ford Ranger, Toyota HiLux and Isuzu D-Max.

Up front, it's easy to get in and out thanks to big door apertures and this limited edition’s slightly higher ride height. There’s plenty of breathing space and good separation from your co-pilot.

In terms of storage there are door bins with room for decent size bottles, a couple of cup/bottle holders in the centre console, a lidded storage box between the seats (which doubles as a centre armrest), a wireless charging pad ahead of that, two glove boxes, a shallow well in the centre of the dashtop and a drop down sunglasses holder.

In the back, sitting behind the driver’s seat set to my 183cm position, there’s plenty of head, leg and toe room.

Three full-size adults across the second row will be okay for short to medium trips and a trio of up to late teenage kids will be fine. There are bins in the doors with room for medium-size bottles, a fold-down centre armrest with a pair of cupholders and map pockets in the front seat backs.

On the not so good side, there’s no individual ventilation control for back-seaters and the only power option is a 12-volt socket with USB-A and -C ports confined to the front only. Shout out for the USB input in the mirror housing for a dash cam, though.

The roughly 1.5m long by 1.2m wide illuminated tray will accommodate a Euro pallet between the wheel arches. There are multiple tie-down rings and tailgate closing is assisted.

Maximum towing capacity for a braked trailer is 3500kg (750kg unbraked), a full-size spare is on-board and there are two towing hooks at the front.

Although it’s being cagey on exact pricing at this stage, Volkswagen says the Amarok 10 Deserts Edition will be positioned between $65 and $70K (likely closer to former than the latter).

The Amarok Life TDI500 this car is based on boasts a healthy standard equipment list including LED headlights, daytime running lights and fog lights, adaptive cruise control (with stop/go), alloy rims, a towbar, wireless charging and tailgate lift assist plus wireless Android Auto and Apple CarPlay. 

There’s also six-speaker audio (with digital radio), single-zone air-con, electrically folding and heated exterior mirrors (with courtesy lamps), auto headlight and high-beam control, a leather-trimmed steering wheel and gearshift, and auto rain-sensing wipers.

Not a bad fit-out, even before adding the extra 10 Deserts kit (see Design) and that prospective price puts it between the existing Amarok TDI500 Life ($59,490) and Style $69,740), both before on-road costs, and a step up from Ford’s close to $57K limited-run (1500 unit) Ranger Black Edition.

Because the platform is (mostly) borrowed from the Transit Custom, you get the same driveline. That starts with a 2.0-litre turbo diesel, good for 125kW of power and a useful 390Nm of torque. It drives through a conventional eight-speed automatic transmission and then to the front wheels as a means of keeping the load floor as flat and low as possible.

Ford claims a 2500kg towing capacity with a braked trailer, but on a wet road or damp boat ramp, that’s really going to test the limits of the front wheel’s grip which can be overcome even in the dry if you’re too hasty with the throttle.

The biggest engineering change in the move from Transit Custom to Tourneo has been the switch from leaf springs on the former to coil springs and an independent suspension on the latter. This is all in the name of ride quality and recognises the fact that the Transit will often be called on to cart heavier loads than eight humans.

The record-breaking Amarok was a V6 Style, but this limited edition is based on the Amarok TDI500 Life, so a 2.0-litre turbo-diesel four-cylinder engine sits under the bonnet, sending 154kW/500Nm to the rear, or all four wheels, via a 10-speed automatic transmission.

This twin-turbo, dual-overhead cam unit is shared with the Amarok’s twin under the skin, the Ford Ranger (where it’s referred to as the ‘Bi-Turbo’), and the selectable all-wheel-drive system features three driving modes - 2H, 4H & 4L - and there’s a mechanical rear diff lock.  

Ford quotes an official combined fuel consumption figure of 7.4 litres for the Tourneo. Over a few days of running in a pretty broad mix of urban and country work, we saw an average of 8.6 litres per 100km which is still pretty good for a vehicle of this size.

With the standard 70-litre fuel tank, that gives the Tourneo a theoretical combined range of around 900km between fills, but the real-world number says closer to 800km is more realistic.

Don’t forget, either, that running costs will be a little higher than some diesels, as the Tourneo requires AdBlue at regular intervals, in line with its Euro 6 emissions levels.

The TDI500’s official fuel consumption figure on the combined (urban/extra-urban) cycle is 7.2L/100km. With an 80-litre fuel tank on board, theoretical range is around 1100km.

Stop-start is standard, but we’ll have to wait for an as-tested figure, as this launch drive leant heavily into arduous off-road work.

For reference, in previous testing we’ve recorded real-world consumption closer to 10.0L/100km for this Amarok powertrain, which would deliver a driving range of around 800km.

If you haven’t driven a one-box van for a decade or more, you’re in for a treat. Just like the Transit Custom on which this car is based, the Tourneo represents a different experience to that of a conventional car or SUV, but one that is not without merit.

For a start, you sit very high which means a great view out across the traffic. And while the driving position is a little less laid-back than a modern car, once you get used to the almost square steering wheel, neither is it the dreaded sit-up-and-beg of older van designs.

The four-cylinder engine doesn’t make the Tourneo a fast vehicle, but it does give it lots of flexibility thanks to all that turbo-torque being available from just off idle. The eight-speed transmission helps, too, but the real surprise is just how quiet the Tourneo is when on a cruising setting. In fact, it’s almost uncanny how such a big, empty metal box could be so silent, but beyond a little tyre noise on coarse surfaces, the Ford pulls it off. As a result, it’s very relaxed and effortless feeling at freeway speeds.

The other surprise is how good the ride quality is. By swapping the cargo van’s leaf rear springs for coils, the Tourneo suddenly displays a very good match between the front and rear axles in terms of how they work to absorb bumps. You do still get some of the front-seat sensation that you’re sitting over the front axle, but it’s not terrible and the reality is that you simply sitting closer to the axle, not right over it.

For many drivers perhaps the over-riding impression will be of the vehicle’s external size. And, yes, it’s a long and wide piece of equipment, but at least the boxy shape means the corners are easy to place and the huge glass area and driver aids like parking sensors and blind-spot warnings help a lot in the daily cut and thrust.

Things are also improved by the fabulously small turning circle of 10.9m kerb-to-kerb (courtesy of the Transit’s role as an inner-city delivery van) that gives an agility the looks don’t suggest. But there’s a sense that the Tourneo is a little wider in the rear track than the front, as you’ll sometimes find the inside rear tyre finding the lips of roundabouts and suburban gutters.

The Amarok TDI500 is easy and effortless to drive on the open road. Peak power of 154kW (at 3750rpm) is adequate, but it’s the 500Nm of pulling power, delivered exactly where you want it at just 1750rpm, that sets the tone.

With 10 ratios to cycle through, the auto transmission also helps keep things in the sweet spot and while you’re aware of a certain amount of diesel thrum under acceleration, in this type of ute that’s more reassuring than annoying.

Suspension is by double wishbones and coil springs at the front with leaf springs supporting a live axle at the rear. And as is typical for a ute with this set-up (particularly unladen) bumps on a typical B-road make their presence felt, but not to an alarming degree.

We drove it on loose dirt roads and some challenging trails (which we’ll get to shortly), but overall it feels capable and pretty well planted on the road.

The steering is electrically assisted and there’s a good connection between your hands on the wheel and the tyres on the road.

Standard 17-inch alloys are shod with 225x70 Continental CrossContact ATR (all-terrain) tyres and they’re civilised on the highway. Also worth noting more aggressive off-road-focused rubber is a no-cost option, which is a nice touch.

The brakes are discs front and rear, which is notable because the entry-level Amarok Core is fitted with drums at the back.

On the open-road and in slow-going off-highway, where you’re constantly feathering the brakes during steep declines, braking remains strong with a progressive pedal feel. 

The off-road section of the launch drive was more about the nature of the terrain than ultra-steep inclines or declines.

Big boulders, cavernous ruts, bulging tree roots as well as loose gravel and sand surfaces were the flavours of the day and the Amarok did a great job.

Standard approach, departure and ramp-over angles for the Life TDI500 are pretty solid, but an extra 40mm of ground clearance makes a big difference. 

Worth noting the 10 Deserts Edition held its own with the more heavily modified V6 Style that set the Guinness record, which we also had a chance to steer.

With around 80kg less weight on the front axle, the four-cylinder feels agile and eager in the rough stuff and we saw some impressive axle articulation as the suspension and drive systems helped the Amarok pick its way through the most difficult sections.

We stepped our way through two-wheel high, four-wheel high and 4WD low modes, pulling in the diff lock only when things got hairy.

In terms of miscellaneous observations, it’s worth noting the turning circle is 12.8m. The Amarok is a sizeable vehicle and you’d expect the turning circle to be up there, but just be prepared for a reasonably wide arc when you’re parking or making three-point turns. 

And the front seats are a stand-out. They’re pretty much sports editions - grippy and comfortable even after a full day behind the wheel on- and off-road. And their lateral support keeps you nicely located in the corners.   

The Amarok was given a maximum five-star ANCAP assessment in 2022 and active (crash-avoidance) tech includes AEB (with pedestrian and cyclist monitoring), lane keeping assist and lane departure warning, adaptive cruise control (with stop and go function), rear cross-traffic alert, blind-spot monitoring, hill-descent control, tyre-pressure monitoring, driver fatigue alert, roll-over mitigation and trailer sway control.

There’s also ‘Swerve Steer Assist’, road and speed sign recognition, front and rear parking distance controls, and a reversing camera. That’s an impressive suite for the category.

If a crash is unavoidable, there are nine airbags onboard - dual front and front side, dual front knee, full-length side curtain and a front-centre bag to help reduce the chance of head clash injuries in a side-on crash. Again, above average.

The Amarok scores well with ANCAP for vulnerable road user protection, multi-collision braking minimises the chances of secondary collisions following an initial impact and there’s an auto emergency call-out function able to sense if the driver is incapacitated following an airbag deployment.

Important to note there are top tethers and ISOFIX anchors for baby capsules and/or child seats on the outer rear seat positions only.

Ford offers its standard five-year/unlimited kilometre warranty on the Tourneo. Five years is fair enough, but can’t match the seven years or even more that some of the competition offer. It‘s worth noting, however, that the warranty does match many of the makes and models that will be the Ford’s natural enemies.

Service intervals are 12 months or a very long 30,000km, but it’s unlikely many families will clock up 30,000km in a 12-month period, anyway. There’s no word on capped-price servicing yet, but the mechanically similar Transit Custom has a service plan that limits the cost of each of the first four services to around $500.

The biggest additional running cost for the Tourneo will be the AdBlue additive to control emissions. How frequently you need to top up will be determined by what type of driving you do.

Volkswagen covers the Amarok with a five-year/unlimited-km warranty, which is expected in the mainstream market.

Service is recommended every 12 months/15,000km, which is pretty handy, and the price averages $360 for the first five years, which is competitive for the class and price point.

Fixed price three- or five-year plans are also offered, which brings a modest discount and locks in the pricing. Twelve months of roadside assistance is complementary, renewed for another year each time you service the car at an authorised VW dealer.