Mini Cooper 2009 News

The new Mini arrives here early next year with new efficient engines, a larger body and some changes to styling, but largely continuing with the signature design recipe. It has however  grown 98mm in length to 3821mm, 44m in width to 1727mm and 7mm in height to 1414mm on a 34mm longer wheelbase at 2495mm to give more cabin room and an additional 51 litres of luggage space. There's big news under the skin too, where the Mini debuts the new UKL platform that will in time underpin more new Minis and some new models from parent company BMW. Watch the 2014 Mini Cooper unveiling video on our desktop site. _______________________________________  

The new unit is based on the one in the 1.6-litre Mini Cooper S, with twin-scroll turbocharger, direct fuel-injection and variable valve control. The turbocharger is tweaked for extra boost and the engine has been fitted with a new high-performance exhaust system – finished with twin stainless-steel tailpipes. Engine outputs are 155kW of power at 6000rpm, and 260Nm of torque from 1850-5500rpm, with 280Nm available for a few seconds on overboost between 2000-5200rpm. It will be mated to a six-speed manual transmission as standard, but there will still be the option of a six-speed automatic with a manumatic mode and shift paddles mounted on the steering wheel. Mini says the new engine gets a weight-saving aluminium block and bearing mounts, lighter crankshaft, reinforced pistons and a high-strength cylinder head. The manual transmission gets a fuel saving stop-start system, and the load on the electrical system is reduced by brake energy recapture with the alternator disengaging at high revs – combining to cut your fuel burn by about 500ml per 100km.  

High performance versions of the Mini Cooper are being recalled worldwide to fix an engine problem that could potentially start a fire.More than 235,000 of the turbocharged Cooper S models built between 2006 and last year are being recalled worldwide to remedy a secondary water pump fitted to cool down the turbocharger.The company has global reports of just over 80 water pump failures and four fires as a result, but BMW Australia and local authorities have deemed the program here to be a technical service campaign,Mini Australia spokesman Piers Scott says just over 3700 Cooper S (of which one may have experienced the smoldering engine bay issue) and John Cooper Works vehicles built between 2006 and 2011 are effected in Australia."This was deemed to be a technical campaign, in-line with similar campaigns conducted in the past," he said.Mr Scott said the use of the term `recall' overseas to describe the issue."It is the Department of Infrastructure and Transport that we liaise with locally and they would advise us if it were to be a safety Recall.""There is no less urgency under a technical campaign - replacement parts are now in the country and Mini Australia has already begun contacting affected customers," he said.The worldwide recall of 235,000 cars includes 29,868 in the UK and 89,000 in the US and involves replacing the water pump free of charge.The company head office said that the turbocharged engines are fitted with an additional water pump to remove residual heat from the turbocharger after the engine was switched off."Under high operating temperatures an electro-migration can occur at the circuit board installed in the additional water pump," it said."This can lead to a failure of the additional water pump or smoldering and even a fire cannot be excluded."More than 200,000 Minis are built each year at the company's Oxford plant, where production started in 2001and recently passed two million vehicles built - the car is exported to more than 90 countries.The turbocharged engine is shared with Citroen and Peugeot, but both French companies said there engines employed different electrical systems.

So the 2011 Mini Cooper S facelift photographed by Carparazzi in Europe is essentially … more of the same.There are some small changes in terms of a revised air intake and it’s likely there could still be a surprise under that bumper camouflage.  Some attention has also been paid to the light clusters, with the rear set now sporting LEDs.However, with the increasing pressure of emissions regulations, the Mini is also likely to have some upgraded engine technology aimed at reducing CO2 while improving outputs.Insiders are tipping that a variable-valve system will be added to the current 128kW/240Nm turbocharged 1.6-litre petrol engine, while the naturally aspirated 88kW/160Nm version will also be tweaked – although there are no hints of how much it will increase the outputs of either.

Mini designer Alec Issigonis and performance tweaker John Cooper had a brain explosion in 1964 and developed a model with twin motors. Cooper crashed it, spent eight months in hospital and the idea was officially shelved. It hasn't stopped many backyard mechanics from having a go ever since, including Brisbane dentist Bill Westerman."Five years ago I was drinking beer with my friend Fred Sayers and we both decided to build one," he says in his garage littered with Mini engines in various states of rebuild. "Right from the word go — when the hangover cleared — we got stuck right into it."His 1964 Mini Cooper S with a "worn-out" 1293cc engine in the front and another in the back is called "Nuts". "Because you have to be nuts to drive it and it's better with two," says Westerman with a cheeky grin."I don't know what I paid for this one. It came from a shell. I had a shed load of Minis at the time. It's a sickness, you know."The graduate dentist began learning his mechanical skills from his first car which was a composite Series II Land Rover he made from two he bought at auction. His love of Minis started with his second purchase in 1969 when he bought a new Cooper S for $2500 and headed off to work in outback Waikerie, South Australia."I realised fairly quickly that what you really need in the outback is a V8, so I bought an XY Falcon ute," he says. "It went through a set of tyres every 6000 miles (9656km), a set of shocks every three months and universal joints at least once a year over those corrugated roads."His next car was a modified VB Commodore V8 wagon donated to the young dentist by Holden. He had it about five years before returning to Brisbane, more study at the University of Queensland and the start of his amateur career racing Minis from 1986 to today."The aim was to race all the circuits in Australia and I've just about done that except for Perth and Darwin," he says. "I've had a lot of fun. Racing has been very good to me. I've always been in the middle of the pack because I didn't spend enough money on the race car to win."His efforts to get more power out of a Mini and get further to the front of the pack led him down the ignominious Issigonis path of a twin-engined model. "We were worried after the first drive as it was an extremely difficult beast to keep on the road," he says. "There has to be co-ordination between the two motors. The gearing is the same and all the internals in the engine are the same, but we set the front so it was revving slightly harder so there is a bit of a pull factor."The revelation that kept the beast on the road came from an article in a 1960s Sportscar World magazine about the Formula One Ferguson all-wheel-drive race car. "We got a lot of hints from that; you need an overdrive diff on the front and back," he says. "We put one in the front and it made a bit of a difference and then we put one in the back and all of a sudden it goes. The diff takes up the front-to-back bias. It used to crab before that."The other major problem was the suspension. "Minis usually understeer, but this one was really taily at the start, not because of the weight in the rear but the front suspension we put in the rear. The problem was the back castor ... it had too much toe-in and we had to remove it. Instead of a steering box and steering geometry we made it into a straight-ahead suspension. Now I can drive it over all the ripple strips and still maintain control of the car. We have handling reasonable so now we are after more horsepower."Two more powerful engines in various stages of rebuild are sitting on the floor of his garage waiting to be thrown into the "Nuts" car. "I have the theoretical knowledge of mechanics to build an engine but Fred has the practical knowledge to make it work," he says. "It's been an interesting engineering exercise."Unfortunately, the car won't be ready in time for the second annual Cootha Classic hillclimb which Westerman organises for the Historic Racing Car Club of Queensland. "Maybe next year," he says.The Cootha Classic will be held on May 29-30 featuring more than 250 cars and about 50 motorcycles from the 1920s to today in timed sprints around a 1450m track up and down Sir Samuel Griffith Drive with seven corners and chicanes.Racing starts at 8.30am. Entry is $20 a day, $15 for concession, $30 for a two-day pass and $5 for parking in the J.C. Slaughter Falls carpark.Visit: www.visitbrisbane.com.au.

It is the Ford Fiesta ECOnetic, which re-set the economy benchmark this year at just 3.7L/100km - that is 76.3 miles-per-gallon in pre-decimal currency - and also produces just 98 grams of carbon for

The latest round of official crash tests has given five-star occupant protection ratings to some of the most fuel-frugal small cars sold in Australia, the Mini Cooper diesel, the Ford Fiesta ECOnetic diesel, the Volvo C30 diesel and the Toyota Prius hybrid.On the Global Green Challenge, a 3150km drive from Darwin to Adelaide and with driving in Adelaide last month, the Ford Fiesta ECOnetic averaged just 3.13 litres/100km fuel consumption and the Mini diesel was not far behind.  Transport Department director of road safety, Martin Small, said yesterday (Tuesday 17) the crash test results showed that new-car buyers could save fuel and still get five-star safety."These ratings show that manufacturers can make a range of fuel efficient vehicles which do not compromise safety," Mr Small said.  Other vehicles to score five stars in these tests are the new Subaru Liberty Exiga and the latest Hyundai Sante Fe with four-cylinder engine.  The only car in this round of tests not to get the full five stars is the Honda City sedan which managed four stars.RAA (SA) technical services manager Mark Borlace said this was because that model Honda did not have electronic stability control, a requirement since 2008 before five stars could be awarded.  "It makes the lack of ESC for the Honda City disappointing," Mr Borlace said."All of these five-star models include head-protecting side airbags or curtains, anti-lock brakes with electronic brake distribution and electronic stability control as standard," he said. "And it is pleasing to see the results apply to all models in the various ranges, not just luxury-specified vehicles."In separate testing for pedestrian protection, the Honda City, Subaru Exiga and Fiesta achieved three out of a maximum four stars. The upgraded Sante Fe, previously scoring zero, this time got one star.

It doesn't really matter what you call it, the push is all about sustainability and leaving as much as we can from this generation for the next rather than gobbling up finite resources with no regard

It doesn't really matter what you call it, the push is all about sustainability and leaving as much as we can from this generation for the next rather than gobbling up finite resources with no regard

Later this month he will face a different challenge - driving to save fuel.The Aussie-born long distance sportscar driver has raced in Formula 1, the Indianapolis 500 and Bathurst, and now the 66-year-old veteran of speed is tackling the Global Green Challenge from Darwin to Adelaide.The 3000km Challenge, which starts on October 24, will test  the real-world fuel consumption of 21 production cars. The winner will be the car which can return the greatest improvement over its official fuel rating. The event, with a mix of urban and highway conditions, has been sanctioned by the FIA and is being run under the control of CAMS. And it's not a go-slow event to save fuel. Cars will have to keep within speed limits but also maintain a minimum average of 75km/h on open roads.Schuppan will be behind the wheel of a Mini Cooper D, trying to better BMW's official figure, achieved in a laboratory, of  just 3.9l/100km. "Driving in the first Global Green Challenge is a very exciting prospect. It's such a unique event which allows the general public to see how far modern production cars have come in terms of fuel consumption," Schuppan said. "I'm sure that the event will grow into something really big in the coming years."Schuppan has never driven the Cooper D in its latest form, but says he finds it "amazing that you can have such impressive fuel economy packaged in something like this and still have the performance people expect." "I think we're in with a shot. The Cooper D has a good chance of winning its class," he said.Make One Degree of difference today by calculating your carbon footprint and finding out what you can do to reduce it.