Mahindra Scorpio-N vs Mercedes-Benz G580

What's the difference?

It may seem like I've been harsh on this Mahindra but I reckon the Scorpio Z8L+ is a positive product for the company.

It’s nice enough to drive on-road – reasonably refined and comfortable – and it’s also a capable 4WD, with some trade-offs.

But this seven-seat wagon remains a good value-for-money prospect with the addition of more driver-assist tech onboard boosting its safety and adding to its overall appeal.

As per the 1979 original, the current G-Class is produced by Magna Steyr in Arnie’s home town of Graz in Austria. And many fundamental things haven’t changed since then. But clearly this EV monster’s exotic electric powertrain is a huge departure.

It retains impressive off-road ability and straight-line speed. But will it hit the mark with top-end luxury 4WDers? Short story, this thing is wild, and it will be irresistible for a likely narrow band of tech-focused ‘must have the latest and greatest’ buyers. Nothing like impressing friends and family with a tank turn.

Note: CarsGuide attended this event as a guest of the manufacturer, with travel, accommodation and meals provided.

Nothing has changed on the Scorpio’s exterior. It still reminds me of the early-generation Hyundai Terracan – long bonnet, generic cabin (i.e. inoffensive, soft lines, nothing to set it apart from most other mid-sized SUVs) and, though its off-road angles check out (more about those later) it looks quite low to the ground.

So it’s all standard for a 4WD wagon.

The Scorpio also has 18-inch alloy wheels, side steps, roof rails and a sunroof.

Potential main rival GWM Tank 300 holds sway in the looks department.

Okay, so Mercedes-Benz says, with a straight face, that “with the aim of optimising the vehicle’s aerodynamics” classic G-Class elements have been revised, including the reprofiled bonnet, ‘air curtain’ vents in the flares over the rear wheel arches, A-pillar cladding and the small spoiler on the edge of the roof.

At the same time, the 20-inch wheels are also claimed to be "aerodynamically optimised” and underneath, a 26mm underbody casing made from a mix of materials, including carbon-fibre (attached to the ladder frame with more than 50 steel screws), protects the battery from dust, dirt and rocks.

In ticking off the Edition One, car-spotters should look for black rims with blue brake callipers behind them, blue inserts in the exterior protective strips as well as black door handles and a new rectangular design box on the rear door for storing items such as charging cables, tools or snow chains. If you want a spare wheel, choose the standard model.

An optional black-panel radiator grille ($3800) features tinted lighting units as well as an animated LED light band and chrome surround. The light band can be activated as a running light or an animation when locking and unlocking the vehicle.

And it’s worth noting Mercedes-Benz and the car’s contracted manufacturer, Magna Steyr, have invested much time and many Euros in retaining the car’s classic handle and door lock design. G-Wagen owners will recognise its sound from several kilometres away.

Inside the G580 it’s clear this is one area where the G-Class has progressed enormously over the decades. It’s still quite upright in terms of the dash design, but you’re confronted by twin 12.3-inch screens, supporting the Mercedes-Benz user interface. 

All very high-tech, but that’s balanced by an old-school grab-handle for the front passenger to latch onto during off-road work. 

The signature turbine-style air vents are located within squared-off panels, and in the limited Edition One you have a blue fleck running through carbon-fibre inserts on the centre console, door cards and that front grab handle. In the standard car it’s a (very attractive) walnut open-pore wood rather than carbon.

A luxurious interior for sure.

Nothing much has changed inside the Scorpio, either, except for the addition of an electronic park brake.

The cabin has a neat layout with a 8.0-inch touchscreen multimedia system that is easy to operate but it needs to be bigger.

The synthetic leather trim looks and feels only adequately premium and if you more closely scrutinise the Scorpio’s interior it lacks the build quality, storage spaces and USB charge points of rival wagons.

Driver and front passenger get adequate room, while the second row is actually satisfactorily spacious without being capacious; behind my driving position I had more than enough leg, head and shoulder room – but, take note, I'm the size of a garden gnome. The third row is the stuff of nightmares – only joking, but it should quite rightly be limited to use by small children or your mate the jockey.

There’s one cupholder (between the driver and front passenger), door pockets are narrow and there are few other storage spaces. In this respect, the Scorpio cabin lacks general functionality.

The Scorpio also cops a mark down because of its third row. With the third-row seats in use, there’s a small rear cargo area, and those seats don’t fold flat so when they’re not in use they occupy a lot of what could be useable storage space.

As a result, the Scorpio is one of the few modern 4WDs I’d consider removing the third row every time long-distance loaded-up travel was on the cards – just so it’s a more practical touring vehicle.

Some features, such as the directional air vents, feel flimsy. Otherwise, the Scorpio’s cabin is adequately practical, rather than overly impressive.

Suffice to say, in terms of practicality, the Scorpio’s rivals have it beaten.

For the record, the G63 is just over 4.6m long and a little more than 1.9m wide with a 2890mm wheelbase. So, not huge, but its close to 2.0m height is hard to ignore. 

In the front there’s lots of breathing space, and in terms of storage you have generous bins in the doors with plenty of room for big bottles. Then there’s a centre armrest, which doubles as the top of a deep storage box housing a USB-C port inside. 

A sliding roller cover in the centre console reveals two cupholders, another two USB-C sockets, a 12-volt outlet and a wireless charging pad. Add in a big glove box and you’ve got plenty of options in terms of storage, power and connectivity. 

In the back, sitting behind the driver’s seat set for my 183cm position I’ve got tons of foot and legroom and, no surprise, lots of headroom.

There’s a fair bit of sculpting in the rear seat, which is as nice as it is unusual (makers often avoid bolsters on the rear seat as it makes the backrest harder to fold flat). And in terms of three-abreast accommodation, a smaller adult will be okay in the centre spot for shorter journeys. Three up to mid-teenage kids will be swimming in it.

Then, for practicality you again have generous bins in the doors. And if you need even more capacity, fold down the centre armrest which houses two different size cupholders. 

In the rear of the centre console you’ve got two USB-Cs, a 12-volt power outlet, individual climate control and directional vents.

There are map rockets on the front seatbacks and more air vents in the B-pillar. So, when it comes to comfort, powering up devices and storing ‘things’ you’re well taken care of.

The side-opening tailgate door opens from right to left, which isn’t ideal when parallel parked on the left hand side of the road, but boot volume is over 600 litres (VDA) with all seats upright, expanding to nearly 2000 litres with the 60/40 split-folding rear seat lowered.

There are multiple tie-down hooks, a netted pocket, two lights, a 12-volt outlet as well as a ‘ski-port’ door and sliding cargo cover to enhance practicality and security.

As mentioned earlier, the full-size spare in the standard model, but the Design Box replaces it on the Edition One, although Mercedes-Benz says it’s aiming to make a spare available as an option later in the year.

The new Mercedes-Benz G580 is priced at $249,900 and a more highly-specified limited Edition One version comes in at $299,900, both before on-road costs.

That’s a price territory where the BMW X5 and X6 M Competition ($244,900 & $250,900) as well as the Range Rover Autobiography ($233,961) live. Not to mention competition from the G580’s still available and appreciably pricier twin-turbo V8 Mercedes-AMG G63 stablemate ($365,900).

As you’d expect, the standard features list is substantial and the highlights are Burmester 3D Surround Sound audio (with digital radio), leather upholstery, keyless entry and start, a multi-function steering wheel trimmed in Nappa leather, power front seats with memory function, heated and cooled cupholders, and wireless smartphone charging. 

There’s also dual 12.3-inch driver instrument and central media displays, ambient lighting and adaptive LED headlights as well as Android Auto and Apple CarPlay.

As well as cosmetic changes, covered shortly, the Edition One steps up to ‘Silver Pearl’ and black Nappa leather trim (with blue contrast stitching).

There’s also a range of optional packages bundling up everything from exterior body elements to interior trim and additional multimedia, the latter especially for back-seaters. 

The ‘Night Package’ ($4300) includes black exterior mirror housings, black running boards and wheels as well as darkened exterior lights and a radiator shell that can be illuminated for an impressive profile while driving.

A ‘Superior Line Interior Plus Package’ ($14,500) brings full Nappa leather upholstery, ‘Active Multicontour Seat Package Plus’ and grab handles in leather. Then a ‘Manufaktur Exterior Package’ ($4100) finishes the roof, bumpers and wheel arches in ‘Obsidian Black’. 

But the one that will score you maximum brownie points with the kids is the ‘Interior Comfort Package’ ($8500), featuring a rear seat entertainment system, including two integrated 11.6-inch touch displays.

The Mahindra Scorpio Z8L+ has a 2.2-litre four-cylinder turbo-diesel engine, producing 129kW and 400Nm and it’s matched to a six-speed automatic transmission.

This engine-and-auto combination is sluggish at times but it’s generally okay.

The Scorpio has a part-time 4WD system (with high- and low-range) and an automatic rear diff lock.

Worth noting the Scorpio must be in neutral and stationary for the driver to shift into '4WD low-range', but the driver is able to shift between '2WD' and '4WD High' on the move, up to 80km/h.

This 4WD wagon’s '4Explor' system’s drive modes include 'Normal' (2WD for sealed surfaces), 'Grass/Snow' (4WD), 'Mud & Ruts' (4WD) and 'Sand' (4WD).

The Scorpio lags behind its rivals here.

The G580 is powered by four permanently excited synchronous motors, each delivering around a CLA200’s worth of power and torque to each wheel for overall outputs in excess of 432kW/1164Nm.

Each motor has its own two-stage transmission and power electronics for almost infinite fine-tuning of the direction and amount of drive sent to individual wheels. Merc calls it ‘individual-wheel drive’.

Official fuel consumption is 7.2L/100km on a combined (urban/extra-urban) cycle on regular unleaded fuel.

Actual fuel consumption on this test was 9.0L/100km, which is better than the 9.6L/100km I recorded on my last Scorpio review a couple of years ago.

The Mahindra Scorpio Z8L+ has a 57-litre fuel tank so, going by those fuel figures, you could reasonably expect a driving range of about 633km from a full tank. It also has a 16-litre Adblue tank, so keep that mind.

Remember, that 633km is a best-case scenario figure and has not had a 30-50km safe-distance buffer subtracted from it. And it doesn't take into account the fact that, when being used for touring, the Scorpio may be loaded with people, pets, camping gear and more.

Rivals such as the GWM Tank 300 easily outclass the Scorpio when it comes to off-roading and all-round touring suitability.

Housed in a torsion-resistant casing and embedded low down in its ladder-frame chassis, the G580’s 116kWh two-tier, liquid-cooled lithium-ion battery pack delivers a WLTP-rated range of 473km, or 567km on the more lenient NEDC scale.

‘Eco Assistant’ and ‘Range Monitoring’ functions provide continuous information on battery status, energy consumption and estimated range.

Maximum system capacity is 400 volts which enables 200kW DC charging, meaning a 10 to 80 per cent fill in as little as 32 minutes. Maximum AC charging capacity is 11kW.

Claimed energy use is 23.1kWh/100km, and we saw an average of 28.6kWh across urban and highway running on the launch drive program.

Not exactly a ‘green’ EV choice, then, but it’s worth noting a one-year Chargefox subscription is included to off-set the car’s energy appetite.

On road the Scorpio is reasonable. It’s comfortable and refined but can be a bit firm on the suspension it has – double wishbone and coil springs at the front, live axle with multi links, Watts link and coil springs at the rear. But for a four-wheel drive wagon it's quite nice on sealed surfaces.

The powertrain is generally a reasonable set-up, although there is lag between foot-down and acceleration and it holds onto gears for too long before upshifting.

There have been no mechanical changes to this Scorpio over the previous generation and that's fine because this Mahindra’s tractable engine offers reasonable power and torque across enough of a rev range to make it an effective 4WD.

The Scorpio feels comfortable and reasonable off road. And when it’s time to tackle ‘4WD-only’ territory, it is generally capable. High- and low-range gearing is decent, and as mentioned earlier, its off-road drive modes adjust traction control, among other aspects, to best suit the terrain you’re tackling.

Its no rock-crawling beast but as a result of these mechanical and technical elements this 4WD wagon is able to drive the kind of terrain you’d reasonably expect to be able to cover in a standard off-roader that's been engineered for 4WDing across light to moderately difficult terrain.

The Scorpio’s off-road angles and ground clearance are on par with mid-size SUV rivals. Ground clearance is a listed 227mm. It feels quite low, but if you drive it with care and consideration, you should be fine.

The rear diff lock doesn't feel as clunky in its application as it has in the past. Maybe I'm more forgiving in my old age because, as I mentioned earlier, there haven't been any upgrades mechanically or in terms of off-road-specific driver-assist tech or in diff lock operation.

Hill descent control works reasonably well, although it's not the greatest, allowing for some free-wheeling before it bites.

The Scorpio’s road-oriented Bridgestone Ecopia (255/60 R18) tyres are fine on formed dirt tracks but are found wanting on anything rougher than that.

In terms of towing capacity, the Scorpio is able to tow 750kg unbraked and 2500kg braked. So if you're looking to haul anything larger than a small box trailer, camper trailer or tinny, you'll have to look elsewhere.

GVM and GCM are 2610kg and 5155kg, respectively.

Main potential rival GWM Tank 300 has it over the Scorpio in terms of off-roading prowess and, even though it’s not a towing beast, the GWM wagon is better suited to life as a touring platform than the Mahindra.

So, with 432kW and around 1160Nm, even though the G580 weighs in at around three tonnes, you’re talking 0-100 km/h in 4.7 seconds. And this car gets up and goes… like a beast.

What you don’t get is that traditional Merc-AMG G63 V8 rumble, because, of course, no engine. 

But you do get what Mercedes calls ‘G-Roar’, essentially a sound bar at the front of the car also using the audio system inside to give it what is not exactly an engine noise but some sense of the car progressing. And you can turn it off for completely silent running.

‘Electric Dynamic Select’ changes the parameters of the motors, transmission, suspension, ESP and steering as required. On-road that means ‘Comfort’, ‘Sport’ and ‘Individual’ modes, with off-road comprising ‘Trail’ and ‘Rock’. In the Comfort setting drive flows primarily to one axle for optimum energy efficiency.

Suspension is by double wishbones at the front and a De Dion-style live (rigid) axle at the rear. You’ve got the same adaptive-type set-up as per other G-Class models, so ‘Comfort’ and ‘Sport’ modes and of the many traditional G-Class traits this car exhibits, ride quality is one of them.

Even in Comfort you’ll find even little bumps and thumps making their way up into the seat of the pants and the cabin. It is after all a body-on-frame, ladder-chassis type vehicle and that’s not unusual.  

In terms of steering, it’s accurate and road feel is good. You’ve got 275-wide Falken Azenis FK520 tyres that are more on- than off-road focused. The car feels stable and nicely planted on the road.

The physical brakes are by ventilated discs front and rear, and the big rotors are the same size (353mm) all around. They work nicely and feel like a conventional set-up.

Regenerative braking kicks in as soon as you lift off the accelerator pedal. The powertrain is harvesting energy as the car decelerates and there are four levels you can adjust with the steering wheel paddles up to a quite aggressive level - not quite, but close to a single-pedal set-up.

Off-road, the G580’s ‘G-Steering’ system allows the wheels to turn at different speeds to induce slight ‘drift-like’ oversteer and tighten the turning circle. It works beautifully and the car’s fording depth is 850mm, a full 150mm more than internal-combustion G-Class models.

A three-speed off-road crawl function is adjustable to speeds as low as 2.0km/h, and the car is claimed to remain stable on sideways slopes up to 35 degrees. 

Torque vectoring is used to create ‘virtual diff locks’ and there’s a ‘low-range’ setting. Switch to the ‘Offroad Cockpit’ and data including gradient, lateral inclination, compass readings, tyre pressures and the selected G-Mode appear.

A ‘Transparent Bonnet’ function creates a virtual view of what’s approaching and passing under the front wheels to help the driver pick their way through steep ascents or declines.

For the record, the G580’s approach angle is 32 degrees, departure is 30.7, breakover is 20.3 and ground-clearance is 250mm.

And of course, with the wheels independently powered, the G580’s signature move is what Mercedes-Benz calls a ‘G-Turn’ but the rest of the world calls a tank turn.

If you encounter an obstacle that makes forward progress impossible, the system spins the left- and right-hand wheels in opposite directions so this brute can turn on the spot like an M1 Abrams. You can’t help but crack up laughing when executing this extreme party trick!

In terms of miscellaneous observations around ergonomics and the car in general, it has a 13.6-metre conventional turning circle. So if you’re not using the G Turn function in the car park be ready for a sizeable turning arc.

Also, those aero tweaks here and there seem to have had an effect. Wind noise, especially for such an upright, squared-off design is surprisingly modest. And overall, from a build point of view, this car feels as though it’s been carved from a solid piece of metal. In every aspect it presents as a quality item.

Although the Mercedes-AMG G63 carries a maximum five-star ANCAP safety assessment from 2018, the pure-electric G580 is unrated. But crash avoidance tech includes active cruise control, ‘Active Steering Assist’, high-speed AEB, traffic sign recognition, lane-keeping assist, blind-spot monitoring, driver fatigue monitoring as well as a 360-degree camera view and ‘Active Parking Assist’.

And if a crash is unavoidable, there are no fewer than 11 airbags on-board, including driver and front passenger front and side, rear side, full-length curtains, driver and passenger knee and a front centre bag.

There are three top-tether points for child seats across the second row, with ISOFIX anchors on the two outer positions.

The Mahindra Scorpio Z8L+ has a seven-year/150,000km warranty and comes with seven years' of roadside assistance if your Scorpio is serviced by Mahindra.

The first service is scheduled at the 1500km mark, then every 12 months or 10,000km. Pricing details were not available at the time of writing.

Five years of capped price servicing is available at an average cost per visit of $471.

For reference, the GWM Tank 300 offers a seven year/unlimited km warranty, five years' of roadside assistance, and five years of capped price servicing (starting at $360 for the first service and topping out at $1035 for the sixth). Service intervals are scheduled for every 12 months or 15,000km.

At time of writing there were reportedly about 80 Mahindra dealerships spread across Australia. According to the company, "the dealer network spans all states and territories, including locations in major cities like Melbourne, Brisbane, Adelaide, and Perth". Your Scorpio can be serviced at any authorised Mahindra dealership.

The G580 is covered by Mercedes-Benz Australia’s five-year/unlimited-km warranty, which remains the standard offering in the premium part of the market and an eight-year/160,000km drive battery warranty.

Service intervals are every 12 months or 20,000km with service plan pricing available over three ($2645), four ($3980) and five ($4670) years. In approximate terms, each workshop visit will cost ‘around’ $900. Not exactly cheap, especially for an EV, but this is no ordinary electric vehicle.