Avan Cruiseliner vs Mercedes-Benz Vito

What's the difference?

The Avan isn’t for everyone, although usually when I speak to owners, they’re a passionate lot who love their campers. 

I really like how easy this is to set up and pack up, and the level of comfort a solid-walled camper offers. They don’t feel very large inside, mainly thanks to the sloping roof, and that’s where something like the Jayco Penguin just wins out. 

But if you can sacrifice that ‘feeling’ of space, this is a highly featured camper with a good amount of rough-road ability.

This is a very competent light commercial van that’s nice to drive, either unladen or with a heavy load. It’s also rated to carry more than a tonne (like the HiAce) while towing 2.5 tonnes (one tonne more than the HiAce) which would make it well suited to a wide range of job applications, particularly given the forklift-friendly option of rear barn-doors.

However, even in standard trim, without our test vehicle’s options, it costs about $20K more than Toyota’s dominant rival. So, only a potential buyer can decide if the Vito’s much higher pricing is justified after a decent test drive and consideration of its higher tow rating - and perceived prestige.

Almost no-one builds an 11-foot caravan any more, and hasn’t since the 1960s, probably, but that’s essentially what the interior of the Cruiseliner is like. 

Small and pokey as it is, though, it’s not impractical and not even uncomfortable. With a bed at the back, kitchen in the middle and dinette at the front, it’s got all the basic elements for comfort and because of the steep pitch of the roof, there’s plenty of headroom where it’s needed most. 

It’s actually quite an efficient little space for two people, and that’s demonstrated in the storage that’s available. Almost all of it is easy to get to – except the cupboard under the table – and some of the biggest areas can be accessed from inside or out.

With its relatively light 1967kg kerb weight (a HiAce equivalent tops 2200kg) and 3050kg GVM, our test vehicle has a 1083kg payload rating, so it’s a genuine one-tonner. And up to 150kg of that can be carried on the roof, where you’ll find four pairs of mounting points along each side of the roof ready for rack-mounting.

It’s also rated to tow up to 2500kg of braked trailer and with its 5550kg GCM (or how much it can legally carry and tow at the same time) it’s rated to tow its maximum trailer weight while carrying its maximum payload. That’s an impressive and useful set of numbers.

The cargo bay, which offers a competitive 6.0 cubic metres of load volume, is accessed by sliding doors on each side with 822mm opening width (although the top half of the cabin bulkhead encroaches on this) and a swing-up tailgate which restricts forklift access for rear loading (a twin barn-door option is available).

The walls and doors of the cargo bay are lined and its wooden load floor is 2678mm long and 1709mm wide with 1270mm between the rear-wheel housings. So, it could carry two 1165mm-square standard Aussie pallets or up to three 800 x 1200mm Euro pallets, secured using your choice of eight load-anchorage points. There’s also a large storage area at the base of the bulkhead which is ideal for carrying ropes, straps, load-padding etc.

There are numerous personal storage places in the cabin, including large bottle-holders and bins in the base of each door plus a second-tier at mid-height for smaller items. There are also three bins and two cupholders in the top of the dash-pad plus an overhead glasses holder, decent-sized glove box and a sizeable storage compartment hidden beneath the outer passenger seat.

The Cruiseliner Adventure Plus was great to tow. The low weight and low roof height reduces drag and it’s very stable on the road. For a little while, Avan was importing its suspension from overseas, and the system had a few teething problems. Now the Adventure Plus is fitted with Australian-made AL-KO Enduro independent coil-spring suspension, which is a very reliable and high-performing package. 

Although this is the ‘off-road’ version of the Avan, the company’s ‘off-road’ policy is very conservative, and it recommends this only for gravel roads and water crossings no deeper than the bottom of the chassis. 

The off-road pack does go a little further than Jayco’s Outback pack, though, as Avan includes and off-road hitch, upgraded drawer runners and wall hinges, over and above the upgraded suspension and chassis. 

It offers a comfortable driving position with good eyelines to all mirrors, even though the central mirror’s view through the bulkhead window is slightly obscured by the centre seat headrest.

There’s a vast blind-spot over the driver’s left shoulder caused by the bulkhead and solid cargo bay walls. This requires total reliance on the passenger-side door mirror in traffic, fortunately with the reassurance of blind-spot monitoring and rear cross-traffic alert.

The driver’s seat, with its fold-down inboard armrest and multiple adjustment, is supportive and comfortable even though the recline angle of the backrest is restricted by the bulkhead behind it. Fortunately, there’s enough recline available, even for tall drivers.

The leather-trimmed steering wheel has a luxurious feel which is in stark contrast to the foot-operated parking brake, which lets out a loud spring-loaded ‘twang’ each time you pull the dashboard lever to release it.

It’s nice to drive on a daily basis as the bulkhead seals off cargo bay noise, steering is nicely weighted, the four-wheel discs provide strong braking and the unladen ride quality with four-coil suspension is smooth and supple.

At city and suburban speeds, the nine-speed auto is efficient at keeping the turbo-diesel operating in its broad peak torque band, with energetic throttle response that never feels sluggish.

With adaptive cruise control it also has effortless highway performance, requiring only 1500rpm to maintain 100km/h and 1750rpm at 110km/h. Engine and wind noise are low, but tyre noise varies according to road surface and can be quite intrusive on coarse bitumen at these higher speeds.

To test its payload rating, we forklifted 975kg into the cargo bay. With the raised tailgate restricting forklift access, we could only load one weight-block through the rear and that was only possible using extended tynes on the forklift. The other two blocks were loaded through the side doors.

With driver the total payload was 1065kg, which was less than 20kg under its limit. The coil-spring rear suspension compressed 75mm, which engaged the long rubber cones located inside the coils that provide a second stage of load support and a ride quality that’s free of thumps over bumps. The nose rose 30mm in response.

With more than a tonne on board, the Vito handled the load with ease. Although more accelerator pedal was needed, particularly on hills, the handling remained stable and it glided over bumps.

It also scoffed at our 13 per cent gradient 2.0km-long set climb at 60km/h, self-shifting down to third gear to easily haul this load to the summit.

Engine-braking on the way down, in a manually-selected second gear, wasn’t as effective which is usually the case with relatively small diesels trying to restrain heavy payloads on steep descents. The quartet of disc brakes kept our speeds below the posted 60km/h limit.